Page 1
TX-W32D4DP Service Manual Safety Service Support Specifications Service and repair of Block Diagrams this product is Parts List supported by Panasonic's LUCI Service interface. Information This interface provides a Adjustments link between the TV and a standard PC to allow a...
Page 2
Audio Control Power supply Video BACK D - PCB E - PCB D - Schematic E - Schematic F - PCBs G - PCB F - Schematic G - Schematic H - PCB K - PCB H - Schematic K - Schematic M - PCB Y - PCB M - Schematic...
Page 3
Y: 1V p-p 75Ω (4-pin) C: 0,3V p-p 75Ω NOTE: This Service Manual should be used in conjunction Audio(RCAx2) 500mV rms10kΩ with the EURO-5 Technical Guide. Video (RCAx1) 1V p-p 75Ω Panasonic CS ( U.K. ) Ltd. WILLOUGHBY ROAD, BRACKNELL, BERKS., RG12 8FT.
CONTENTS SAFETY PRECAUTIONS................................2 SERVICE HINTS ..................................3 SERVICE POSITION.................................4 ADJUSTMENT PROCEDURE AND SELF-CHECK ........................5 WAVEFORM PATTERN TABLE ...............................6 ALIGNMENT SETTINGS................................7 BLOCK DIAGRAMS ..................................8 PARTS LOCATION .................................12 REPLACEMENT PARTS LIST ..............................13 SCHEMATIC DIAGRAMS ...............................30 CONDUCTOR VIEWS................................39 SAFETY PRECAUTIONS GENERAL GUIDE LINES It is advisable to insert an isolation transformer in the The potential at any point should not exceed a.c.
SERVICE HINTS How to remove the rear cover 1. Remove the 10 screws as shown in Fig.2. SCREWS Fig.2. LOCATION OF CONTROLS Y - Board M - Board Focus Screen K - Board F - Board G - Board H - Board E - Board D - Board Fig.3.
HOW TO MOVE THE CHASSIS INTO SERVICE POSITION 1. Hold and lift the rear of the E-PCB chassis and gently pull the chassis toward you, as shown in Fig.4. 2. Release the respective wiring clips and rotate the chassis vertically through 90°, anti-clockwise. 3.
WAVEFORM PATTERN TABLE NOTE: All waveforms have been taken using a standard colour bar pattern. VFLB Vert Drive Vert Out IC451 Pin 5 IC451 Pin 2 IC601 Pin 1 8.6mS 8.6mS H - Out HFLB Video In IC601 Pin 8 IC601 Pin 13 IC1101 Pin 68 64µS...
ALIGNMENT SETTINGS: (The figures below are nominal and used for representative purposes only.) 1. Set the Bass to maximum position, set the Treble to minimum position, press the down button (- / v) on the customer controls at the front of the TV and at the same time press the INDEX button on the remote control, this will place the TV into the Service Mode.
Page 26
Cct Ref Parts Number Description Cct Ref Parts Number Description 220nF C362 ECUV1H224ZFX S.M. CAP R3446 ERJ6GEYJ102 S.M.CARB 0.1W 100nF C363 ECUV1H104KBX S.M. CAP R3447 ERJ6GEYJ102 S.M.CARB 0.1W 100nF R3452 ERJ6GEYJ101 S.M.CARB 0.1W C364 ECQM2104KZ FILM 250V R3453 ERJ6GEYJ101 S.M.CARB 0.1W C365 ECKC2H102J...
Page 27
Cct Ref Parts Number Description Cct Ref Parts Number Description 47pF 100µF C871 ECA0JM102GB ELECT 6.3V C623 ECUV1H470JCX S.M. CAP 47pF 2.2nF C872 ECA1CM222E ELECT C625 ECUV1H470JCX S.M. CAP 30pF 47pF C626 ECUV1H470JCX S.M. CAP C901 ECUV1H030CCX S.M. CAP 100µF 47pF C627 ECUV1H470JCX...
Page 28
Cct Ref Parts Number Description Cct Ref Parts Number Description 100nF 100nF C1518 ECUV1H104ZFX S.M. CAP C1588 ECUV1H104ZFX S.M. CAP 100µF 100nF C1519 ECA1HM101GB ELECT C1589 ECUV1H104ZFX S.M. CAP 100µF 100nF C1521 ECA1HM101GB ELECT C1590 ECUV1H104ZFX S.M. CAP 100nF 100nF C1522 ECUV1H104ZFX S.M.
Page 29
Cct Ref Parts Number Description Cct Ref Parts Number Description 100µF 220pF C1661 ECA1HM101GB ELECT C2130 ECUV1H221JCX S.M. CAP 100nF 330nF C1662 ECUV1H104ZFX S.M. CAP C2131 ECQM1H334J FILM 56pF 10µF C1663 ECUV1H560JCX S.M. CAP C2132 ECA1CM100GB ELECT 100nF 47pF C1664 ECUV1H104ZFX S.M.
Page 30
Cct Ref Parts Number Description Cct Ref Parts Number Description 1µF 470nF C2623 ECQM1H474J FILM C2436 ECEA1HKA010 ELECT 560pF 470nF C2624 ECQM1H474J FILM C2437 ECUV1H561JCX S.M. CAP 470nF 560pF C2438 ECUV1H561JCX S.M. CAP C2625 ECQM1H474J FILM 470nF 1µF C2439 ECEA1HKA010 ELECT C2627 ECQM1H474J...
Page 31
Cct Ref Parts Number Description Cct Ref Parts Number Description 10nF 470µF C3123 ECUV1H103KBX S.M. CAP C3816 ECA1CM471GB ELECT 220µF C3124 ECUV1H102KBX S.M. CAP C3817 ECA1CM221GB ELECT 4.7µF 10nF C3255 ECA1HM4R7GB ELECT C3818 ECUV1H103KBX S.M. CAP 4.7µF 1µF C3256 ECA1HM4R7GB ELECT C3819 ECA1HM010GB...
SCHEMATIC DIAGRAMS FOR MODEL TX-W32D4DP (EURO-5 CHASSIS) IMPORTANT SAFETY NOTICE Components identified by mark have special characteristics important for safety. When replacing any of these components, use only manufacturer's specified parts. NOTE RESISTOR All resistors are carbon ¼W resistor, unless marked otherwise.