Page 1
TX-W32D5DPF Service Manual Safety Service Support Specifications Service and repair of Block Diagrams this product is Parts List supported by Panasonic's LUCI Service interface. Information This interface provides a Adjustments link between the TV and a standard PC to allow a...
Page 2
Audio Control Power supply Video BACK D - PCB E - PCB D - Schematic E - Schematic F - PCBs G - PCB F - Schematic G - Schematic H - PCB K - PCB H - Schematic K - Schematic M - PCB Y - PCBs M - Schematic...
CONTENTS INHALT SAFETY PRECAUTIONS ............ 2 SICHERHEITSVORKEHRUNGEN ........2 SERVICE HINTS ..............4 SERVICE HINWEISE ............4 SERVICE POSITION ............5 SERVICEPOSITION ............5 SELF CHECK ..............6 SELBSTDIAGNOSE ............6 ADJUSTMENT PROCEDURE ..........7 ABGLEICH ................7 WAVEFORM PATTERN TABLE .......... 8 SIGNAL TABELLE...............
Page 5
LEAKAGE CURRENT HOT CHECK MESSUNG DES KRIECHSTROMS IM EINGESCHALTETEN ZUSTAND Plug the AC cord directly into the AC outlet. Do not use an isolation transformer for this check. Den Netzstecker direkt in eine Netsteckdose stecken. Connect a 2kΩ 10W resistor in series with an Für diese Messung keinen Trenntransformator exposed metallic part on the receiver and an earth, verwenden.
SERVICE HINTS SERVICE HINWEISE HOW TO REMOVE THE REAR COVER ENTFERNEN DER GERÄTERÜCKWAND Remove the 10 screws as shown in Fig.2. Die 10 Schrauben entfernen, siehe Abb.2. Screws Schrauben Fig.2. Abb.2. LOCATION OF CONTROLS LAGE DER EINSTELLREGLER Y - Board Focus Fokusregler Screen...
How to move the chassis into Comment placer le chassis en position Service position Service Hold and lift the rear of the chassis and gently pull Das Chassis am hinteren Ende leicht anheben und nach the chassis toward you, as shown in Fig.4. hinten herausziehen, wie in Abbildung 4 dargestellt.
SELF CHECK SELBSTDIAGNOSE Self-check is used to automatically check the bus Die Selbstdiagnose dient zum automatischen Prüfen lines and hexadecimal code of the TV set. der Bus-Leitungen sowie des Hexadezimalcodes des FS-Geräts. Zum Umschalten auf Selbstdiagnose To get into the Self-Check mode press the down zunächst die Taste "STATUS"...
WAVEFORM PATTERN TABLE SIGNAL TABELLE NOTE: All waveforms have been taken using a standard colour bar pattern. HINWEIS: Alle oszillogramme wurden unter Verwendung des Standard Farbbalken Testbildes aufgenommen. Vert Drive VFLB Vert Out IC451 Pin 2 IC451 Pin 5 IC601 Pin 1 8.6mS 8.6mS H - Out...
ALIGNMENT SETTINGS: (The figures below are nominal and used for representative purposes only.) 1. Set the Bass to maximum position, set the Treble to minimum position, press the down button (- / v) on the customer controls at the front of the TV and at the same time press the INDEX button on the remote control, this will place the TV into the Service Mode.
ABGLEICHTABELLE: (Die angegebenen Werte sind Mittelwerte und Können individuell nach oben oder unten nach dem korrekten Abgleich abweichen.) 1. Um in den Service-Mode zu gelangen, gehen sie bitte wie folgt vor. 2. Stellen sie im Toneinstellungs-Menü die Bässe auf Maximun und die Höhen auf Minimum. 3.
PARTS LOCATION EXPLOSIONSZEICHNUNG NOTE: Anmerking: The numbers on the exploded view below Die Nummer auf den mechanischen Teilen refer to the mechanical section of the Zeigt die Bezugsnummer der Ersatzteilliste Replacement Parts List.
Page 31
Cct Ref Parts Number Description Cct Ref Parts Number Description 220nF 100nF C268 ECQM1H224J FILM C613 ECUV1H104ZFX S.M. CAP 47µF 100nF C269 ECA1HM470GB ELECT C614 ECUV1H104ZFX S.M. CAP 220nF 100nF C270 ECQM1H224J FILM C615 ECJ2VB1C104K ELECT 350V 220nF 100nF C271 ECQM1H224J FILM C616...
Page 32
Cct Ref Parts Number Description Cct Ref Parts Number Description 470µF 1µF C857 ECA1EM471GB ELECT C1508 ECEA1HN010UB ELECT 270µF 100nF C858 ECOS2EA271BB ELECT 250V C1509 ECUV1H104ZFX S.M. CAP 470pF 100µF C859 ECKC2H471J CERAMIC 500V C1510 ECA1HM101GB ELECT 220µF 100nF C861 ECOS2EA221AB ELECT 250V...
Page 33
Cct Ref Parts Number Description Cct Ref Parts Number Description 100nF 100nF C1578 ECUV1H104ZFX S.M. CAP C1650 ECUV1H104ZFX S.M. CAP 100nF 100nF C1579 ECUV1H104ZFX S.M. CAP C1651 ECUV1H104ZFX S.M. CAP 100nF 100µF C1580 ECUV1H104ZFX S.M. CAP C1652 ECA1HM101GB ELECT 100nF 100nF C1581 ECUV1H104ZFX...
Page 34
Cct Ref Parts Number Description Cct Ref Parts Number Description 100nF 47µF C1825 ECUV1C104KBX S.M. CAP C2301 ECA1CM470GB ELECT 100nF 47µF C1826 ECUV1C104KBX S.M. CAP C2302 ECA1CM470GB ELECT 100nF 10nF C1827 ECUV1C104KBX S.M. CAP C2307 ECUV1H103KBX S.M. CAP 15pF 10nF C1828 ECUV1H150JCX S.M.
Page 35
Cct Ref Parts Number Description Cct Ref Parts Number Description 0R1µF 10nF C2449 EEANA1E1R0B CERAMIC C2637 ECUV1H103ZFX S.M. CAP 15pF 470nF C2450 ECUV1H150JCX S.M. CAP C2638 ECQM1H474J FILM 15pF C2451 ECUV1H150JCX S.M. CAP C2639 ECUV1H102KBX S.M. CAP 10nF 100pF C2452 ECUV1H103ZFX S.M.
Page 36
Cct Ref Parts Number Description Cct Ref Parts Number Description 10nF 10nF C3120 ECUV1H103KBX S.M. CAP C3810 ECUV1H103KBX S.M. CAP 1µF C3122 ECUV1H102KBX S.M. CAP C3814 ECA1HM010GB ELECT 10nF 470µF C3123 ECUV1H103KBX S.M. CAP C3816 ECA1CM471GB ELECT 220µF C3124 ECUV1H102KBX S.M.
SCHEMATIC DIAGRAMS FOR MODEL ZEICHENERKLÄRUNG FÜR MODELL TX-W32D5DPF TX-W32D5DPF (EURO - 5 CHASSIS) (EURO - 5 CHASSIS) WICHTIGER SICHERHEITSHINWEIS IMPORTANT SAFETY NOTICE Components identified by mark have special Teile, die mit einen Hinweis gekennzeichnet sind, characteristics important for safety. When replacing any of sind wichtig für die Sicherheit, Sollte ein Auswechsein...