Page 1
MAHLE CAJ-25LP Operation Manual Truck Service Lift...
Page 2
| 2 | CAJ-25LP EVERY PERSON WHO OPERATES THIS EQUIPMENT NEEDS TO KNOW AND UNDERSTAND ALL OF THE INFORMATION IN THIS MANUAL – FAILURE TO DO SO COULD RESULT IN SERIOUS INJURY OR DEATH. READ THIS MANUAL CAREFULLY AND RETAIN...
Safety Regulations en | 4 | CAJ-25LP Safety Regulations m Always lift with either the factory supplied lift pad or extended lift pad in place. Never lift when one of these Warnings two factory furnished lift pads is not properly installed m Failure to follow all of these safety instructions can lead [see graphic on right].
Thank you for your purchase. To complement the offering Signal words call attention to a safety message or of A/C, fluid and nitrogen service equipment, MAHLE messages, or a property damage message or Service Solutions has partnered with Gray Manufacturing...
Responsibilities en | 6 | CAJ-25LP Responsibilities Specifications Receiving inspection CAJ-25LP Before attempting to operate this equipment, thoroughly Model CAJ-25LP US units Metric units read and understand this manual. Completely remove all tape and packaging. Inspect the equipment immediately Maximum capacity...
Product description CAJ-25LP | 7 | en Product description Component identification Fig. 3: Top view Lift pad Wheel Fig. 2: Top view Plastic cover for oil reservoir plug Short lift pad extension socket Tall lift pad extension socket Air control valve...
Operation en | 8 | CAJ-25LP 6. Chock the vehicle’s wheels. When raising a vehicle from Operation one end, always chock the wheels that will remain on the m WARNING - This section discusses the appropriate and ground. Make sure at least two wheels of the vehicle remain in contact with the floor at all times —...
Operation CAJ-25LP | 9 | en Lowering a vehicle 1. Make sure the vehicle load does not exceed the rated capacity of the jack (50,000 lbs. / 22,680 kg.) 2. Inspect the jack for signs of wear or damage (see “Inspection Instructions”...
Maintenance and Inspection en | 10 | CAJ-25LP Maintenance and Inspection Inspection – periodic m WARNING - The jack must be inspected according to The jack owner (or a knowledgeable person appointed by the requirements of this section. Failure to properly the owner) must give the jack a more thorough inspection inspect the jack could lead to severe injury or death.
Maintenance and Inspection CAJ-25LP | 11 | en 9. Troubleshooting Maintenance instructions This section is a list of potential problems and solutions. If m WARNING - All inspection and maintenance procedures the solution listed fails to correct the problem, call the...
Page 16
| 16 | TSL-50 MAHLE Aftermarket Inc. 916A West State Street St. Johns, Michigan 48879-1404 U.S.A. Phone: (800) 468-2321 E-mail: tech.mss@us.mahle.com www.servicesolutions.mahle.com...