Page 1
Specification and Manual Customer: Description: AC220V 50/60Hz Heater 300W (Din Mounting) Customer Part No.: Rev.: Delta Model No.: HEH030BB Rev.: Sample Date Code: Sample Issue Date: MAY.29 2020 Please send one copy of this specification back after you signed approval for production pre-arrangement...
Delta model no.: HEH030BB Description This document is an installation and the characteristics of Delta HEH series. Before installing the unit, please read this manual thoroughly, and following the instructions contained in it. The document is the exclusive property of Delta Electronics, Inc.
Page 4
Part no.: Delta model no.: HEH030BB Use this unit only in the manner intended by the manufacturer. If there is any question please contact the manufacturer. Install the heater in accordance with the instructions in this installation manual. Improper installation may result in damage, electric shock or fire.
Page 5
Part no.: Delta model no.: HEH030BB Do not install heater at any place where there is a danger or flammable gas leakage. To avoid injury, do not touch exhaust air or surface during operating or just turn off products. This appliance is not to be used by any persons with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given proper supervision or instruction.
Page 6
Part no.: Delta model no.: HEH030BB Specification for Approval Customer : Description : AC220V 50/60Hz Heater 300W (Din Mounting) Customer P/N : Rev. : Delta model no. : HEH030BB Rev. : 01 Sample revision. : Date Code : Sample issue date : MAY.29 2020...
Part no.: Delta model no.: HEH030BB 1. Product Instruction 1-1. General Description The heater is designed for warming up the air in enclosure. It can avoid equipment damaged at lower temperature and water condensation. The heater can be mounted on the wall of cabinet.
Part no.: Delta model no.: HEH030BB Key Components Controller Communication port Fans Delta High Efficiency Fan * The Heating capacity (W) is defined as W=V*A at 0 W : power consumption V: Operating Voltage A : Operating current ** Test condition are AC input 220Vac that is cold start at ambient temperature 25 C.
Part no.: Delta model no.: HEH030BB 1-4. Thermal and Airflow The cool air flow into the heater and warmed up by heating sink inside the case, then heated air is supplied to the system. * Minimum gap for both of cool air inlet and warm air exhaust is required to avoid short circulation 2 Electrical Specification 2-1.
Part no.: Delta model no.: HEH030BB Startup average current and inrush current: The startup average and inrush current waveform defined as bellow table. These experiments are all finished at ambient 25˚C at 220Vac. Tested waveform to startup average current and inrush current.
Part no.: Delta model no.: HEH030BB 4. Reliability Table Test item Condition High temperature IEC 60068-2-2 Low temperature IEC 60068-2-1 High temp. /High humidity IEC 60068-2-14 TEST Nb Temperature cycle IEC 60068-2-3 Vibration ETSI 300 019-1-4 CLASS 4.1 Package bump IEC 60068-2-29 ...
Part no.: Delta model no.: HEH030BB • Please contact Delta or authorized Delta service agent. • Fan lock • Power off product than Power on, the Fan • Heater failure is stop but the check the Fan blade is no...