CONTENTS IMPORTANT NOTICE GREEN PRODUCT PROCUREMENT LEAD-FREE SOLDER SAFETY INSTRUCTION SERVICE MODE LED INDICATIONS FOR SERVICE HOTEL MODE MAIN BOARD EXCHANGE WRITING SERIAL NUMBER INTO MAIN BOARD 10. INTERCONNECT 11. EXPLODED VIEW 12. SCHEMATIC DIAGRAM...
WARRANTY OF ANY KIND, EITHER EXPRESS OR IMPLIED WARRANTY OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. Toshiba shall not be liable for any damages, losses, expenses or costs, if any, incurred in connection with or as a result of use of any information or data provided...
Hazardous Substances. From July 1, 2006, the RoHS Directive will prohibit any marketing of new products containing the restricted substances. Increasing attention is given to issues related to the global environmental. Toshiba Corporation recognizes environmental protection as a key management tasks, and is doing its utmost to enhance and improve the quality and scope of its environmental activities.
(1/4) SAFETY INSTRUCTION WARNING: BEFORE SERVICING THIS CHASSIS, READ THE "SAFETY PRECAUTION" AND "PRODUCT SAFETY NOTICE" INSTRUCTIONS BELOW. Safety Precaution WARNING: SERVICING SHOULD NOT BE ATTEMPTED BY ANYONE UNFAMILIAR WITH THE NECESSARY PRECAUTIONS ON THIS RECEIVER. THE FOLLOWING ARE THE NECESSARY PRECAUTIONS TO BE OBSERVED BEFORE SERVICING THIS CHASSIS.
Page 11
(2/4) Always ensure that all internal wirings are in accordance before re-assembling the external casing after a repairing completed. Do not allow internal wiring to be pinched by cabinets, panels, etc. Any error in reassembly or wiring can result in electrical leakage, flame, etc., and may be hazardous.
Page 12
(3/4) The potential at any point (TOUCH CURRENT) expressed as voltage does not exceed the following value: The part or contact of a TERMINAL is not HAZARDOUS LIVE if: a) The open-circuit voltage should not exceed 35 V (peak) a.c. or 60 V d.c. or, if a) is not met.
Page 13
(4/4) Product Safety Notice Many electrical and mechanical parts in this chassis have special safety-related characteristics. These characteristics are often passed unnoticed by a visual inspection and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltage, wattage, etc.
(1/3) SERVICE MODE ENTERING SERVICE MODE 1. Press button once on Remote Control. TV mode changes as follows. Un-Mute => Mute 2. Press button again and keep pressing. (Sound Mute is canceled) 3. While pressing the button, press button on TV control panel. (Enter Service Mode)
Page 15
(2/3) KEY FUNCTION IN THE SERVICE MODE The following key entry during display of adjustment menu provides special functions. Button Function Test signal selection button (on Remote) (on Remote) Selection of the adjustment items Volume +/– (on Remote) Change of the data value [7] button Automatic A/D Adjustment (PC, Component, Composite(PAL, NTSC))
Page 16
(3/3) ADJUSTING ITEMS IN THE SERVICE MODE Item Description RCUT RED CUTOFF GCUT GREEN CUTOFF BCUT BLUE CUTOFF RDRV RED DRIVE GDRV GREEN DRIVE BDRV BLUE DRIVE OSRC COOL R-CUTOFF-OFFSET for COOL OSRC NATURAL R-CUTOFF-OFFSET for NATURAL OSRC WARM R-CUTOFF-OFFSET for WARM OSGC COOL G-CUTOFF-OFFSET for COOL OSGC NATURAL...
LED INDICATIONS FOR SERVICE SW Upgrade and Error conditions indicated by the Power LED is described below. Power LED Green blink SW Upgrade in Progress SW Upgrade Failed Green SW Upgrade Successful...
(1/18) HOTEL MODE 1. ENTERING HOTEL MODE MENU Hotel Mode Menu should be shown by the following operation. 1) Open Main Menu by pressing Menu button of RCU. 2) Press the following password number “1048” with the button of Remote Control. Note: Hotel Menu can be displayed to input the password number when there is focus in the first layer of Main Menu.
Page 19
(2/18) Factory Item Options Description Gray Out Conditions settings Hotel Mode Enable Hotel Mode Disable Hotel Mode. All the settings of Hotel Mode are disabled. Control Panel Allow use of all Control panel - Grayed out when "Hotel buttons Mode" = [Off] Off (All Functions) Prohibit use of all control panel buttons.
Page 20
(3/18) Remote Control Enable the remote control buttons. - Grayed out when "Hotel Mode" = [Off] Disable the remote control buttons. * The following remote codes are not disabled. - Super User mode (40BFFE) - S mode (40EEC3) * If “Off" is selected, RCU will not function in any menu (including no menu) except Hotel Menu.
Page 21
* Welcome image can be changed through USB Clone Function. A default welcome image (TOSHIBA) is available. Refer to 4.1 for details of Welcome image. Welcome image becomes default by “Reset Hotel Menu”...
Page 22
(5/18) default welcome image (TOSHIBA) is available. Refer to 4.1 for details of Welcome image. Welcome image becomes default by “Reset Hotel Menu” (*But Welcome image don’t becomes default by USB Live Update, Network Upgrade and OAD.) Not display a welcome image every...
Page 23
(6/18) On (AC) TV tunes to preset “POS/VIDEO” (channel or input) only when AC power is applied. When TV is powered on by power button, tune to the last channel or input. TV Tunes to the last channel or input viewed when powered on POS/INPUT/VIDEO - Grayed out when Hotel...
Page 24
(7/18) USB Control USB function available - Grayed out when "Hotel Mode" = [Off] USB function not available but allow - Grayed out when "USB USB bus power Power" = [Off] USB Control is off will make “USB Live Upgrade” and “AC on USB upgrade”...
Page 25
(8/18) Volume" = [Off] Change Picture Mode Picture setting mode is forced to - Grayed out when "Hotel (Only available when “Fixed Picture Mode” mode. Mode" = [Off] “Menu Control / “Main menu/Picture Mode”, “Quick Picture" is On.) menu/Picture Mode” and “RCU/select picture mode button”...
Page 26
(9/18) is set to “Off” and the “Wake on LAN Standby Mode” is set to “On”, the standby mode is “WoL Standby”. - When “Active Standby Mode” and “Wake on LAN Standby Mode” are set to “Off”, the standby mode is “Standby”.
Page 27
(10/18) USB Clone Function Start USB Clone Press “OK” on "Start USB Clone" Start - Grayed out when "Hotel button, USB Clone mode initial Clone Mode" = [Off] window is displayed. - Grayed out when "USB * Refer to “4. USB CLONE Power"...
Page 28
(11/18) *Tuner screen (etc.) is not displayed from power On to the contents playback as much as possible. Offline Playback contents in USB memory inserted in DTV by Media Player without confirmation message, when turning on DTV. In addition, playback contents in USB memory by Media Player without confirmation message,...
Page 29
(12/18) content, display ERROR “Unsupported file”. And return the Photo List to root of USB memory. Video Video contents in root of USB memory are selected and play back. In case of no playback content, display ERROR “Unsupported file”. And return the Video List to root of USB memory.
Page 30
(13/18) Reset Signage When select this item, Menu display “Are you sure you want to reset to default settings? (Yes/No (Default:No))” message. If select Yes, set to default all setting in Signage Mode Menu * Signage Menu settings should not be reset by “Reset TV”...
Page 31
(14/18) Explanation of AD Channel List A/D Channel List = Off A/D Channel List = On DTV Mode ATV Mode DTV Mode ATV Mode Press [LIST] key Press [LIST] key Press [LIST] key Press [LIST] key DTV Mode ATV Mode DTV Mode ATV Mode DTV Channel List...
Page 32
*However, URL can be operated on the site specially developed. ・File type: Text Note: When user would like to copy “URL of Toshiba Cloud TV Services”, the clone data should be hotelCloudConfig.txt” file exported to USB memory in advance and then put “...
Page 33
(16/18) Note: The title of the screen image changes to USB Clone. [1-1] [1-2] OK key [1-3] Complete copy Error...
Page 34
(17/18) 4.3. To write data form USB to TV (1) Press “OK” on “Start USB Clone” button of “USB Clone Function”, USB Clone mode initial window [2-1] is displayed. (2) Insert USB memory, select USB to TV [2-1], and press [OK] key. (3) The window [2-3] will be displayed.
Page 35
(18/18) Note: The title of the screen image changes to USB Clone. [2-2] [2-1] Right and Down key Up and Left key OK key [2-3] Error Complete copy [2-5] [2-4] EXIT key Restart power...
(1/3) MAIN BOARD EXCHANGE When Main board is exchanged, the Application SW (Firrmware) and Model Setting need to be updated and the serial number needs to be written the serial number into Main Board (see “WRITING SERIAL NUMBER INTO MAIN BOARD”). Please update in the following procedures.
Page 37
(2/3) Unplug TV, and then Insert the USB mass storage device to the USB slot of the TV. Plug TV. Software updating starts. If Software updating does not start and the front LED lights red, then press [Power] key on Remote Control to start Software updating.
Page 38
(3/3) Confirmation of Software updating Check the TV Model and Model Info by using self check screen. 1. Press SETUP on Remote Control. 2. Select “Get Help” >> “System Information” 3. Press “3” “5” “7” “4” Self check screen is displayed. TV model and Panel vendor [The 4...
(1/2) WRITING SERIAL NUMBER INTO MAIN BOARD When the board is broken, service man will go to customers home and change the board. After change the board service man has to put the serial number same as before. So the service man will use the PC and write the serial number to USB mass storage device.
Page 40
(2/2) After finish writing the “OK” and “Serial number” appear on TV. OK!! Serial No: C35244C00001D1 Unplug USB mass storage device. Check the serial number by using self check screen. How to enter the self check screen. Press SETUP on remote control unit. Select “Get Help”...
Page 60
7453/6453 Main 3 . 3 V D 101 116 C_POWER_DDR 5 V 1 V47A00045600 1 . 5 V _ D D R D1242 R1241 3 . 3 V D 1SS355VMTE-17 UREG 47(J) [V-LMM185*] 100mW IC124 NOT MOUNT R1240 [SBD] [SBD] D1240 D1241 0(X)
Page 61
7453/6453 Main 1.5V_DDR NOT MOUNT 102 M_DDRARESET R1242 0(X) 1.5V_DDR V46A00063900 XC6108N12AMR 3.3V_STNBY 1.5V_DDR RESET IC [V-L6108] IC123 M_DDRARST 120 VSEN VOUT R1252 0(X) M_DDRBRST 121 R1253 C1283 0(X) 100nF(K) C1284 4.7nF(K) NOT MOUNT 102 M_DDRBRESET R1243 0(X) NOT MOUNT R1245 0(X) V41A00002900...
Page 66
7453/6453 Main 5 V _ W L A N 3 . 3 V _ S T N B Y FL163 5 V _ W L A N 5 V 1 V41A00023900 Q1652 MPZ1608S221AT SSM6J414TU,LF(T [MFPI] V22A00100300 FL167 [C6A2] CN162 MPZ1608S221AT M_USB0DM M_USB0DP C1652...
Page 69
7453/6453 Main 3 . 3 V _ D A M P V R E G _ A M P V47A00062900 D-AMP [V-L5760DAPR] IC370 R3700 SFT_CLIP SPK_FAULT 373 370 A_DAMP_SD 0(X) SPK_GAIN0 G N D SPK_GAIN1 W3721 0(X) M_I2CDATA 101 116 755 FREQ/SDA M_I2CCLK 101 116 755...
Page 70
7453/6453 Main L372 10uH(X) A_DAMP_OUTA+ CLF7045T-100M Ω V C C _ A U D I O G N D D P 3 0 0 D P 3 0 1 Ω D P 3 0 2 L373 D P 3 0 3 10uH(X) A_DAMP_OUTA- CLF7045T-100M...
Page 72
7453/6453 Main DP601 DP603 DP605 DP607 DP609 [VARA] DP611 RV604 DP613 NOT MOUNT MOUNT DP619 DP604 V21A00028000 V_TV_OUT 605 [V-CN21B] G N D PJ600 NOT MOUNT R6000 [VARA] DP602 V_E1 125mW 75(J) SHIELD GND RV600 CVBS/SY IN VIDEO OUT MOUNT CVBS/SY IN RETURN NOT MOUNT VIDEO OUT RETURN...
Page 74
7453/6453 Main 3 . 3 V _ A V C6010 NOT MOUNT 100nF(K) W6003 G N D CV_E2 0(X) C6009 [TRP] NOT MOUNT Q6003 10uF(K) R6019 2SA1576UB TLQ NOT MOUNT 100(J) NOT MOUNT G N D G N D V21A00025500 FL613 Y_CS_E2 MMZ1005D220CT...
Page 75
7453/6453 Main 3 . 3 V D V44A00005700 C3600 [OTB] 1uF(K) DS360 6.3V R3601 22(J) (VCC) 105 A_SPDIF (Vin) (GND) D3600 OPT-108HA UDZVTE-176.2B G N D [V-J7F] PJ602 R6054 75(J) 100mW R6055 75(J) DP615 R_HP 100mW R6056 75(J) DP616 L_HP 100mW R6057 75(J)
Page 76
7453/6453 Main 5 V D 3 . 3 V _ A V 3 . 3 V D V47A00064200 UREG [V-L6219BXXX] IC612 VOUT 100nF(K) C6093 C6094 [VSS] 1uF(K) TCR2EF33,LM(T 6.3V G N D V47A00045900 MOUNT 100nF(K) [L2571] C6096 IC611 M_CVBSOUT1 125mW VOUT 75(J) V_TV_OUT 600...
Page 77
7453/6453 Main M_CVBS3 107 MOUNT MOUNT C6007 R6034 M_SOGIN1 107 470(J) C6127 C6008 1nF(K) 100nF(K) MOUNT C6045 NOT MOUNT R6100 100nF(K) V_E1 M_CVBS2 107 33(J) C6105 47nF(K) MOUNT 100nF(K) NOT MOUNT R6200 C6200 M_BIN0M 107 68(J) 10K(J) 47nF(K) 2.2uF(K) C6048 R6106 A_L_E1 M_AUL0 105...
Page 78
7453/6453 Main C6064 M_CVBS0 R6136 CV_E2 M_CVBS1 107 33(J) 47nF(K) C6117 C6108 100nF(K) 220pF(J) NOT MOUNT 3.3VD R6142 CR_E2_SW M_CR_SW 106 100(J) C6069 NOT MOUNT...
Page 79
7453/6453 Main MOUNT MOUNT R6094 GREEN_E1 M_GIN1P 107 C6114 RED_E1 33(J) C6082 47nF(K) MOUNT 100nF(K) BLUE_E1 NOT MOUNT MOUNT R6096 M_RIN1P 107 C6115 C6081 33(J) 47nF(K) MOUNT 100nF(K) NOT MOUNT MOUNT R6095 M_BIN1P 107 C6116 33(J) C6083 47nF(K) 100nF(K) NOT MOUNT R6164 C6073 V_PC_R...
Page 94
7453/6453 Main 3.3VD 3.3V_STNBY [ T P ] [ T P ] D P 7 1 2 D P 7 1 5 MOUNT [ T P ] R7022 D P 7 1 1 [ T P ] D P 7 1 4 0(X) NOT MOUNT [ T P ]...
Page 95
7453/6453 Main 3.3VD NOT MOUNT NOT MOUNT R7065 100(J) NOT MOUNT V47A00027400 XC6216C202PR 12V_LNB C_FANSTOP_1 UREG 106 116 [V-L6216CXXX] IC705 NOT MOUNT C_FAN_ENABLE1 VOFB [ T P ] R7063 0(X) D P 7 0 8 [ T P ] 3.3VD NOT MOUNT D P 7 0 9 V22A00098800...
Page 96
7453/6453 Main 3 . 3 V _ D E M O 0(J) R7506 R_SDA_TN R7507 0(J) R_SCL_TN NOT MOUNT FL750 C7506 0ohm 33pF(J) C7507 NEW_V86A00020500 MPZ1608S601AT 33pF(J) NOT MOUNT C7500 TUNER 10uF(K) [V-HBSTPE232] *H7501 G N D DP760 C7501 100nF(K) R_DIF_P ANT5V(GND) R_DIF_N...
Page 97
7453/6453 Main 3 . 3 V D R7560 10K(J) C7552 FL755 FL757 1uF(K) R7562 300ohm 300ohm 100(J) 750 R_DIF_N M_ADCIN 104 750 R_IFAGC R_IFAGC_SoC 104 C7550 MMZ1005Y301CT C7554 MMZ1005Y301CT C7556 R7561 8pF(D) 8pF(D) 22pF(J) 0(X) C7562 R7565 100nF(K) 47K(J) NOT MOUNT C7561 22nF(K) FL758...
Page 108
7453/6453 Main NOT MOUNT C9029 3 . 3 V D 47pF(J) FL904 R9013 R9014 30ohm 390(J) 12K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL905 1 .
Page 109
7453/6453 Main NOT MOUNT C9069 3 . 3 V D 47pF(J) FL913 R9061 R9059 30ohm 150(J) 5.6K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL914 1 .
Page 110
7453/6453 Main C9116 47pF(J) C_POWER_DB 101 116 R9104 R9103 33K(D) 1K(D) 1 2 V _ D C D C V47A00063900 TPS54427DDAR PWM SWITCH 3 . 3 V D C9114 [V-L54228] FL922 C9103 C9105 C9107 IC904 100nF(K) 220ohm 10uF(K) 10uF(K) 10uF(K) C9108 FL921 10nF(K)
Page 111
7453/6453 Main C9166 47pF(J) 5 V _ U S B I N R9153 R9154 1K(D) 56K(D) 5 V _ M H L I N FL932 1 2 V _ D C D C V47A00064000 220ohm TPS54527DDAR M P Z 2 0 1 2 S 2 2 1 A T PWM SWITCH 5 V D C9164...
Page 132
7463/6463 Main 3 . 3 V D 101 116 C_POWER_DDR 5 V 1 V47A00045600 1 . 5 V _ D D R D1242 R1241 3 . 3 V D 1SS355VMTE-17 UREG 47(J) [V-LMM185*] 100mW IC124 NOT MOUNT R1240 [SBD] [SBD] D1240 D1241 0(X)
Page 133
7463/6463 Main 1.5V_DDR NOT MOUNT 102 M_DDRARESET R1242 0(X) 1.5V_DDR V46A00063900 XC6108N12AMR 3.3V_STNBY 1.5V_DDR RESET IC [V-L6108] IC123 M_DDRARST 120 VSEN VOUT R1252 0(X) M_DDRBRST 121 R1253 C1283 0(X) 100nF(K) C1284 4.7nF(K) NOT MOUNT 102 M_DDRBRESET R1243 0(X) NOT MOUNT R1245 0(X) V41A00002900...
Page 138
7463/6463 Main 5 V _ W L A N 3 . 3 V _ S T N B Y FL163 5 V _ W L A N 5 V 1 V41A00023900 Q1652 MPZ1608S221AT SSM6J414TU,LF(T [MFPI] V22A00100300 FL167 [C6A2] CN162 MPZ1608S221AT M_USB0DM M_USB0DP C1652...
Page 141
7463/6463 Main 3 . 3 V _ D A M P V R E G _ A M P V47A00062900 D-AMP [V-L5760DAPR] IC370 R3700 SFT_CLIP SPK_FAULT 373 370 A_DAMP_SD 0(X) SPK_GAIN0 G N D SPK_GAIN1 W3721 0(X) M_I2CDATA 101 116 755 FREQ/SDA M_I2CCLK 101 116 755...
Page 142
7463/6463 Main L372 10uH(X) A_DAMP_OUTA+ CLF7045T-100M Ω V C C _ A U D I O G N D D P 3 0 0 D P 3 0 1 Ω D P 3 0 2 L373 D P 3 0 3 10uH(X) A_DAMP_OUTA- CLF7045T-100M...
Page 144
7463/6463 Main DP601 DP603 DP605 DP607 DP609 [VARA] DP611 RV604 DP613 NOT MOUNT MOUNT DP619 DP604 V21A00028000 V_TV_OUT 605 [V-CN21B] G N D PJ600 NOT MOUNT R6000 [VARA] DP602 V_E1 125mW 75(J) SHIELD GND RV600 CVBS/SY IN VIDEO OUT MOUNT CVBS/SY IN RETURN NOT MOUNT VIDEO OUT RETURN...
Page 146
7463/6463 Main 3 . 3 V _ A V C6010 NOT MOUNT 100nF(K) W6003 G N D CV_E2 0(X) C6009 [TRP] NOT MOUNT Q6003 10uF(K) R6019 2SA1576UB TLQ NOT MOUNT 100(J) NOT MOUNT G N D G N D V21A00025500 FL613 Y_CS_E2 MMZ1005D220CT...
Page 147
7463/6463 Main 3 . 3 V D V44A00005700 C3600 [OTB] 1uF(K) DS360 6.3V R3601 22(J) (VCC) 105 A_SPDIF (Vin) (GND) D3600 OPT-108HA UDZVTE-176.2B G N D [V-J7F] PJ602 R6054 75(J) 100mW R6055 75(J) DP615 R_HP 100mW R6056 75(J) DP616 L_HP 100mW R6057 75(J)
Page 148
7463/6463 Main 5 V D 3 . 3 V _ A V 3 . 3 V D V47A00064200 UREG [V-L6219BXXX] IC612 VOUT 100nF(K) C6093 C6094 [VSS] 1uF(K) TCR2EF33,LM(T 6.3V G N D V47A00045900 MOUNT 100nF(K) [L2571] C6096 IC611 M_CVBSOUT1 125mW VOUT 75(J) V_TV_OUT 600...
Page 149
7463/6463 Main M_CVBS3 107 MOUNT MOUNT C6007 R6034 M_SOGIN1 107 470(J) C6127 C6008 1nF(K) 100nF(K) MOUNT C6045 NOT MOUNT R6100 100nF(K) V_E1 M_CVBS2 107 33(J) C6105 47nF(K) MOUNT 100nF(K) NOT MOUNT R6200 C6200 M_BIN0M 107 68(J) 10K(J) 47nF(K) 2.2uF(K) C6048 R6106 A_L_E1 M_AUL0 105...
Page 150
7463/6463 Main C6064 M_CVBS0 R6136 CV_E2 M_CVBS1 107 33(J) 47nF(K) C6117 C6108 100nF(K) 220pF(J) NOT MOUNT 3.3VD R6142 CR_E2_SW M_CR_SW 106 100(J) C6069 NOT MOUNT...
Page 151
7463/6463 Main MOUNT MOUNT R6094 GREEN_E1 M_GIN1P 107 C6114 RED_E1 33(J) C6082 47nF(K) MOUNT 100nF(K) BLUE_E1 NOT MOUNT MOUNT R6096 M_RIN1P 107 C6115 C6081 33(J) 47nF(K) MOUNT 100nF(K) NOT MOUNT MOUNT R6095 M_BIN1P 107 C6116 33(J) C6083 47nF(K) 100nF(K) NOT MOUNT R6164 C6073 V_PC_R...
Page 166
7463/6463 Main 3.3VD 3.3V_STNBY [ T P ] [ T P ] D P 7 1 2 D P 7 1 5 MOUNT [ T P ] R7022 D P 7 1 1 [ T P ] D P 7 1 4 0(X) NOT MOUNT [ T P ]...
Page 167
7463/6463 Main 3.3VD NOT MOUNT NOT MOUNT R7065 100(J) NOT MOUNT V47A00027400 XC6216C202PR 12V_LNB C_FANSTOP_1 UREG 106 116 [V-L6216CXXX] IC705 NOT MOUNT C_FAN_ENABLE1 VOFB [ T P ] R7063 0(X) D P 7 0 8 [ T P ] 3.3VD NOT MOUNT D P 7 0 9 V22A00098800...
Page 168
7463/6463 Main 3 . 3 V _ D E M O 0(J) R7506 R_SDA_TN R7507 0(J) R_SCL_TN NOT MOUNT FL750 C7506 0ohm 33pF(J) C7507 NEW_V86A00020500 MPZ1608S601AT 33pF(J) NOT MOUNT C7500 TUNER 10uF(K) [V-HBSTPE232] *H7501 G N D DP760 C7501 100nF(K) R_DIF_P ANT5V(GND) R_DIF_N...
Page 169
7463/6463 Main 3 . 3 V D R7560 10K(J) C7552 FL755 FL757 1uF(K) R7562 300ohm 300ohm 100(J) 750 R_DIF_N M_ADCIN 104 750 R_IFAGC R_IFAGC_SoC 104 C7550 MMZ1005Y301CT C7554 MMZ1005Y301CT C7556 R7561 8pF(D) 8pF(D) 22pF(J) 0(X) C7562 R7565 100nF(K) 47K(J) NOT MOUNT C7561 22nF(K) FL758...
Page 180
7463/6463 Main NOT MOUNT C9029 3 . 3 V D 47pF(J) FL904 R9013 R9014 30ohm 390(J) 12K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL905 1 .
Page 181
7463/6463 Main NOT MOUNT C9069 3 . 3 V D 47pF(J) FL913 R9061 R9059 30ohm 150(J) 5.6K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL914 1 .
Page 182
7463/6463 Main C9116 47pF(J) C_POWER_DB 101 116 R9104 R9103 33K(D) 1K(D) 1 2 V _ D C D C V47A00063900 TPS54427DDAR PWM SWITCH 3 . 3 V D C9114 [V-L54228] FL922 C9103 C9105 C9107 IC904 100nF(K) 220ohm 10uF(K) 10uF(K) 10uF(K) C9108 FL921 10nF(K)
Page 183
7463/6463 Main C9166 47pF(J) 5 V _ U S B I N R9153 R9154 1K(D) 56K(D) 5 V _ M H L I N FL932 1 2 V _ D C D C V47A00064000 220ohm TPS54527DDAR M P Z 2 0 1 2 S 2 2 1 A T PWM SWITCH 5 V D C9164...
Page 193
SERVICE MANUAL LCD Color Television 42L7453D/7463D series (System Information)
Page 194
CONTENTS IMPORTANT NOTICE GREEN PRODUCT PROCUREMENT LEAD-FREE SOLDER SAFETY INSTRUCTION SERVICE MODE LED INDICATIONS FOR SERVICE HOTEL MODE MAIN BOARD EXCHANGE WRITING SERIAL NUMBER INTO MAIN BOARD 10. INTERCONNECT 11. EXPLODED VIEW 12. SCHEMATIC DIAGRAM...
WARRANTY OF ANY KIND, EITHER EXPRESS OR IMPLIED WARRANTY OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. Toshiba shall not be liable for any damages, losses, expenses or costs, if any, incurred in connection with or as a result of use of any information or data provided...
Hazardous Substances. From July 1, 2006, the RoHS Directive will prohibit any marketing of new products containing the restricted substances. Increasing attention is given to issues related to the global environmental. Toshiba Corporation recognizes environmental protection as a key management tasks, and is doing its utmost to enhance and improve the quality and scope of its environmental activities.
(1/4) SAFETY INSTRUCTION WARNING: BEFORE SERVICING THIS CHASSIS, READ THE "SAFETY PRECAUTION" AND "PRODUCT SAFETY NOTICE" INSTRUCTIONS BELOW. Safety Precaution WARNING: SERVICING SHOULD NOT BE ATTEMPTED BY ANYONE UNFAMILIAR WITH THE NECESSARY PRECAUTIONS ON THIS RECEIVER. THE FOLLOWING ARE THE NECESSARY PRECAUTIONS TO BE OBSERVED BEFORE SERVICING THIS CHASSIS.
Page 198
(2/4) Always ensure that all internal wirings are in accordance before re-assembling the external casing after a repairing completed. Do not allow internal wiring to be pinched by cabinets, panels, etc. Any error in reassembly or wiring can result in electrical leakage, flame, etc., and may be hazardous.
Page 199
(3/4) The potential at any point (TOUCH CURRENT) expressed as voltage does not exceed the following value: The part or contact of a TERMINAL is not HAZARDOUS LIVE if: a) The open-circuit voltage should not exceed 35 V (peak) a.c. or 60 V d.c. or, if a) is not met.
Page 200
(4/4) Product Safety Notice Many electrical and mechanical parts in this chassis have special safety-related characteristics. These characteristics are often passed unnoticed by a visual inspection and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltage, wattage, etc.
(1/3) SERVICE MODE ENTERING SERVICE MODE 1. Press button once on Remote Control. TV mode changes as follows. Un-Mute => Mute 2. Press button again and keep pressing. (Sound Mute is canceled) 3. While pressing the button, press button on TV control panel. (Enter Service Mode)
Page 202
(2/3) KEY FUNCTION IN THE SERVICE MODE The following key entry during display of adjustment menu provides special functions. Button Function Test signal selection button (on Remote) (on Remote) Selection of the adjustment items Volume +/– (on Remote) Change of the data value [7] button Automatic A/D Adjustment (PC, Component, Composite(PAL, NTSC))
Page 203
(3/3) ADJUSTING ITEMS IN THE SERVICE MODE Item Description RCUT RED CUTOFF GCUT GREEN CUTOFF BCUT BLUE CUTOFF RDRV RED DRIVE GDRV GREEN DRIVE BDRV BLUE DRIVE OSRC COOL R-CUTOFF-OFFSET for COOL OSRC NATURAL R-CUTOFF-OFFSET for NATURAL OSRC WARM R-CUTOFF-OFFSET for WARM OSGC COOL G-CUTOFF-OFFSET for COOL OSGC NATURAL...
LED INDICATIONS FOR SERVICE SW Upgrade and Error conditions indicated by the Power LED is described below. Power LED Green blink SW Upgrade in Progress SW Upgrade Failed Green SW Upgrade Successful...
(1/18) HOTEL MODE 1. ENTERING HOTEL MODE MENU Hotel Mode Menu should be shown by the following operation. 1) Open Main Menu by pressing Menu button of RCU. 2) Press the following password number “1048” with the button of Remote Control. Note: Hotel Menu can be displayed to input the password number when there is focus in the first layer of Main Menu.
Page 206
(2/18) Factory Item Options Description Gray Out Conditions settings Hotel Mode Enable Hotel Mode Disable Hotel Mode. All the settings of Hotel Mode are disabled. Control Panel Allow use of all Control panel - Grayed out when "Hotel buttons Mode" = [Off] Off (All Functions) Prohibit use of all control panel buttons.
Page 207
(3/18) Remote Control Enable the remote control buttons. - Grayed out when "Hotel Mode" = [Off] Disable the remote control buttons. * The following remote codes are not disabled. - Super User mode (40BFFE) - S mode (40EEC3) * If “Off" is selected, RCU will not function in any menu (including no menu) except Hotel Menu.
Page 208
* Welcome image can be changed through USB Clone Function. A default welcome image (TOSHIBA) is available. Refer to 4.1 for details of Welcome image. Welcome image becomes default by “Reset Hotel Menu”...
Page 209
(5/18) default welcome image (TOSHIBA) is available. Refer to 4.1 for details of Welcome image. Welcome image becomes default by “Reset Hotel Menu” (*But Welcome image don’t becomes default by USB Live Update, Network Upgrade and OAD.) Not display a welcome image every...
Page 210
(6/18) On (AC) TV tunes to preset “POS/VIDEO” (channel or input) only when AC power is applied. When TV is powered on by power button, tune to the last channel or input. TV Tunes to the last channel or input viewed when powered on POS/INPUT/VIDEO - Grayed out when Hotel...
Page 211
(7/18) USB Control USB function available - Grayed out when "Hotel Mode" = [Off] USB function not available but allow - Grayed out when "USB USB bus power Power" = [Off] USB Control is off will make “USB Live Upgrade” and “AC on USB upgrade”...
Page 212
(8/18) Volume" = [Off] Change Picture Mode Picture setting mode is forced to - Grayed out when "Hotel (Only available when “Fixed Picture Mode” mode. Mode" = [Off] “Menu Control / “Main menu/Picture Mode”, “Quick Picture" is On.) menu/Picture Mode” and “RCU/select picture mode button”...
Page 213
(9/18) is set to “Off” and the “Wake on LAN Standby Mode” is set to “On”, the standby mode is “WoL Standby”. - When “Active Standby Mode” and “Wake on LAN Standby Mode” are set to “Off”, the standby mode is “Standby”.
Page 214
(10/18) USB Clone Function Start USB Clone Press “OK” on "Start USB Clone" Start - Grayed out when "Hotel button, USB Clone mode initial Clone Mode" = [Off] window is displayed. - Grayed out when "USB * Refer to “4. USB CLONE Power"...
Page 215
(11/18) *Tuner screen (etc.) is not displayed from power On to the contents playback as much as possible. Offline Playback contents in USB memory inserted in DTV by Media Player without confirmation message, when turning on DTV. In addition, playback contents in USB memory by Media Player without confirmation message,...
Page 216
(12/18) content, display ERROR “Unsupported file”. And return the Photo List to root of USB memory. Video Video contents in root of USB memory are selected and play back. In case of no playback content, display ERROR “Unsupported file”. And return the Video List to root of USB memory.
Page 217
(13/18) Reset Signage When select this item, Menu display “Are you sure you want to reset to default settings? (Yes/No (Default:No))” message. If select Yes, set to default all setting in Signage Mode Menu * Signage Menu settings should not be reset by “Reset TV”...
Page 218
(14/18) Explanation of AD Channel List A/D Channel List = Off A/D Channel List = On DTV Mode ATV Mode DTV Mode ATV Mode Press [LIST] key Press [LIST] key Press [LIST] key Press [LIST] key DTV Mode ATV Mode DTV Mode ATV Mode DTV Channel List...
Page 219
*However, URL can be operated on the site specially developed. ・File type: Text Note: When user would like to copy “URL of Toshiba Cloud TV Services”, the clone data should be hotelCloudConfig.txt” file exported to USB memory in advance and then put “...
Page 220
(16/18) Note: The title of the screen image changes to USB Clone. [1-1] [1-2] OK key [1-3] Complete copy Error...
Page 221
(17/18) 4.3. To write data form USB to TV (1) Press “OK” on “Start USB Clone” button of “USB Clone Function”, USB Clone mode initial window [2-1] is displayed. (2) Insert USB memory, select USB to TV [2-1], and press [OK] key. (3) The window [2-3] will be displayed.
Page 222
(18/18) Note: The title of the screen image changes to USB Clone. [2-2] [2-1] Right and Down key Up and Left key OK key [2-3] Error Complete copy [2-5] [2-4] EXIT key Restart power...
(1/3) MAIN BOARD EXCHANGE When Main board is exchanged, the Application SW (Firrmware) and Model Setting need to be updated and the serial number needs to be written the serial number into Main Board (see “WRITING SERIAL NUMBER INTO MAIN BOARD”). Please update in the following procedures.
Page 224
(2/3) Unplug TV, and then Insert the USB mass storage device to the USB slot of the TV. Plug TV. Software updating starts. If Software updating does not start and the front LED lights red, then press [Power] key on Remote Control to start Software updating.
Page 225
(3/3) Confirmation of Software updating Check the TV Model and Model Info by using self check screen. 1. Press SETUP on Remote Control. 2. Select “Get Help” >> “System Information” 3. Press “3” “5” “7” “4” Self check screen is displayed. TV model and Panel vendor [The 4...
(1/2) WRITING SERIAL NUMBER INTO MAIN BOARD When the board is broken, service man will go to customers home and change the board. After change the board service man has to put the serial number same as before. So the service man will use the PC and write the serial number to USB mass storage device.
Page 227
(2/2) After finish writing the “OK” and “Serial number” appear on TV. OK!! Serial No: C35244C00001D1 Unplug USB mass storage device. Check the serial number by using self check screen. How to enter the self check screen. Press SETUP on remote control unit. Select “Get Help”...
Page 247
7453/6453 Main 3 . 3 V D 101 116 C_POWER_DDR 5 V 1 V47A00045600 1 . 5 V _ D D R D1242 R1241 3 . 3 V D 1SS355VMTE-17 UREG 47(J) [V-LMM185*] 100mW IC124 NOT MOUNT R1240 [SBD] [SBD] D1240 D1241 0(X)
Page 248
7453/6453 Main 1.5V_DDR NOT MOUNT 102 M_DDRARESET R1242 0(X) 1.5V_DDR V46A00063900 XC6108N12AMR 3.3V_STNBY 1.5V_DDR RESET IC [V-L6108] IC123 M_DDRARST 120 VSEN VOUT R1252 0(X) M_DDRBRST 121 R1253 C1283 0(X) 100nF(K) C1284 4.7nF(K) NOT MOUNT 102 M_DDRBRESET R1243 0(X) NOT MOUNT R1245 0(X) V41A00002900...
Page 253
7453/6453 Main 5 V _ W L A N 3 . 3 V _ S T N B Y FL163 5 V _ W L A N 5 V 1 V41A00023900 Q1652 MPZ1608S221AT SSM6J414TU,LF(T [MFPI] V22A00100300 FL167 [C6A2] CN162 MPZ1608S221AT M_USB0DM M_USB0DP C1652...
Page 256
7453/6453 Main 3 . 3 V _ D A M P V R E G _ A M P V47A00062900 D-AMP [V-L5760DAPR] IC370 R3700 SFT_CLIP SPK_FAULT 373 370 A_DAMP_SD 0(X) SPK_GAIN0 G N D SPK_GAIN1 W3721 0(X) M_I2CDATA 101 116 755 FREQ/SDA M_I2CCLK 101 116 755...
Page 257
7453/6453 Main L372 10uH(X) A_DAMP_OUTA+ CLF7045T-100M Ω V C C _ A U D I O G N D D P 3 0 0 D P 3 0 1 Ω D P 3 0 2 L373 D P 3 0 3 10uH(X) A_DAMP_OUTA- CLF7045T-100M...
Page 259
7453/6453 Main DP601 DP603 DP605 DP607 DP609 [VARA] DP611 RV604 DP613 NOT MOUNT MOUNT DP619 DP604 V21A00028000 V_TV_OUT 605 [V-CN21B] G N D PJ600 NOT MOUNT R6000 [VARA] DP602 V_E1 125mW 75(J) SHIELD GND RV600 CVBS/SY IN VIDEO OUT MOUNT CVBS/SY IN RETURN NOT MOUNT VIDEO OUT RETURN...
Page 261
7453/6453 Main 3 . 3 V _ A V C6010 NOT MOUNT 100nF(K) W6003 G N D CV_E2 0(X) C6009 [TRP] NOT MOUNT Q6003 10uF(K) R6019 2SA1576UB TLQ NOT MOUNT 100(J) NOT MOUNT G N D G N D V21A00025500 FL613 Y_CS_E2 MMZ1005D220CT...
Page 262
7453/6453 Main 3 . 3 V D V44A00005700 C3600 [OTB] 1uF(K) DS360 6.3V R3601 22(J) (VCC) 105 A_SPDIF (Vin) (GND) D3600 OPT-108HA UDZVTE-176.2B G N D [V-J7F] PJ602 R6054 75(J) 100mW R6055 75(J) DP615 R_HP 100mW R6056 75(J) DP616 L_HP 100mW R6057 75(J)
Page 263
7453/6453 Main 5 V D 3 . 3 V _ A V 3 . 3 V D V47A00064200 UREG [V-L6219BXXX] IC612 VOUT 100nF(K) C6093 C6094 [VSS] 1uF(K) TCR2EF33,LM(T 6.3V G N D V47A00045900 MOUNT 100nF(K) [L2571] C6096 IC611 M_CVBSOUT1 125mW VOUT 75(J) V_TV_OUT 600...
Page 264
7453/6453 Main M_CVBS3 107 MOUNT MOUNT C6007 R6034 M_SOGIN1 107 470(J) C6127 C6008 1nF(K) 100nF(K) MOUNT C6045 NOT MOUNT R6100 100nF(K) V_E1 M_CVBS2 107 33(J) C6105 47nF(K) MOUNT 100nF(K) NOT MOUNT R6200 C6200 M_BIN0M 107 68(J) 10K(J) 47nF(K) 2.2uF(K) C6048 R6106 A_L_E1 M_AUL0 105...
Page 265
7453/6453 Main C6064 M_CVBS0 R6136 CV_E2 M_CVBS1 107 33(J) 47nF(K) C6117 C6108 100nF(K) 220pF(J) NOT MOUNT 3.3VD R6142 CR_E2_SW M_CR_SW 106 100(J) C6069 NOT MOUNT...
Page 266
7453/6453 Main MOUNT MOUNT R6094 GREEN_E1 M_GIN1P 107 C6114 RED_E1 33(J) C6082 47nF(K) MOUNT 100nF(K) BLUE_E1 NOT MOUNT MOUNT R6096 M_RIN1P 107 C6115 C6081 33(J) 47nF(K) MOUNT 100nF(K) NOT MOUNT MOUNT R6095 M_BIN1P 107 C6116 33(J) C6083 47nF(K) 100nF(K) NOT MOUNT R6164 C6073 V_PC_R...
Page 281
7453/6453 Main 3.3VD 3.3V_STNBY [ T P ] [ T P ] D P 7 1 2 D P 7 1 5 MOUNT [ T P ] R7022 D P 7 1 1 [ T P ] D P 7 1 4 0(X) NOT MOUNT [ T P ]...
Page 282
7453/6453 Main 3.3VD NOT MOUNT NOT MOUNT R7065 100(J) NOT MOUNT V47A00027400 XC6216C202PR 12V_LNB C_FANSTOP_1 UREG 106 116 [V-L6216CXXX] IC705 NOT MOUNT C_FAN_ENABLE1 VOFB [ T P ] R7063 0(X) D P 7 0 8 [ T P ] 3.3VD NOT MOUNT D P 7 0 9 V22A00098800...
Page 283
7453/6453 Main 3 . 3 V _ D E M O 0(J) R7506 R_SDA_TN R7507 0(J) R_SCL_TN NOT MOUNT FL750 C7506 0ohm 33pF(J) C7507 NEW_V86A00020500 MPZ1608S601AT 33pF(J) NOT MOUNT C7500 TUNER 10uF(K) [V-HBSTPE232] *H7501 G N D DP760 C7501 100nF(K) R_DIF_P ANT5V(GND) R_DIF_N...
Page 284
7453/6453 Main 3 . 3 V D R7560 10K(J) C7552 FL755 FL757 1uF(K) R7562 300ohm 300ohm 100(J) 750 R_DIF_N M_ADCIN 104 750 R_IFAGC R_IFAGC_SoC 104 C7550 MMZ1005Y301CT C7554 MMZ1005Y301CT C7556 R7561 8pF(D) 8pF(D) 22pF(J) 0(X) C7562 R7565 100nF(K) 47K(J) NOT MOUNT C7561 22nF(K) FL758...
Page 295
7453/6453 Main NOT MOUNT C9029 3 . 3 V D 47pF(J) FL904 R9013 R9014 30ohm 390(J) 12K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL905 1 .
Page 296
7453/6453 Main NOT MOUNT C9069 3 . 3 V D 47pF(J) FL913 R9061 R9059 30ohm 150(J) 5.6K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL914 1 .
Page 297
7453/6453 Main C9116 47pF(J) C_POWER_DB 101 116 R9104 R9103 33K(D) 1K(D) 1 2 V _ D C D C V47A00063900 TPS54427DDAR PWM SWITCH 3 . 3 V D C9114 [V-L54228] FL922 C9103 C9105 C9107 IC904 100nF(K) 220ohm 10uF(K) 10uF(K) 10uF(K) C9108 FL921 10nF(K)
Page 298
7453/6453 Main C9166 47pF(J) 5 V _ U S B I N R9153 R9154 1K(D) 56K(D) 5 V _ M H L I N FL932 1 2 V _ D C D C V47A00064000 220ohm TPS54527DDAR M P Z 2 0 1 2 S 2 2 1 A T PWM SWITCH 5 V D C9164...
Page 319
7463/6463 Main 3 . 3 V D 101 116 C_POWER_DDR 5 V 1 V47A00045600 1 . 5 V _ D D R D1242 R1241 3 . 3 V D 1SS355VMTE-17 UREG 47(J) [V-LMM185*] 100mW IC124 NOT MOUNT R1240 [SBD] [SBD] D1240 D1241 0(X)
Page 320
7463/6463 Main 1.5V_DDR NOT MOUNT 102 M_DDRARESET R1242 0(X) 1.5V_DDR V46A00063900 XC6108N12AMR 3.3V_STNBY 1.5V_DDR RESET IC [V-L6108] IC123 M_DDRARST 120 VSEN VOUT R1252 0(X) M_DDRBRST 121 R1253 C1283 0(X) 100nF(K) C1284 4.7nF(K) NOT MOUNT 102 M_DDRBRESET R1243 0(X) NOT MOUNT R1245 0(X) V41A00002900...
Page 325
7463/6463 Main 5 V _ W L A N 3 . 3 V _ S T N B Y FL163 5 V _ W L A N 5 V 1 V41A00023900 Q1652 MPZ1608S221AT SSM6J414TU,LF(T [MFPI] V22A00100300 FL167 [C6A2] CN162 MPZ1608S221AT M_USB0DM M_USB0DP C1652...
Page 328
7463/6463 Main 3 . 3 V _ D A M P V R E G _ A M P V47A00062900 D-AMP [V-L5760DAPR] IC370 R3700 SFT_CLIP SPK_FAULT 373 370 A_DAMP_SD 0(X) SPK_GAIN0 G N D SPK_GAIN1 W3721 0(X) M_I2CDATA 101 116 755 FREQ/SDA M_I2CCLK 101 116 755...
Page 329
7463/6463 Main L372 10uH(X) A_DAMP_OUTA+ CLF7045T-100M Ω V C C _ A U D I O G N D D P 3 0 0 D P 3 0 1 Ω D P 3 0 2 L373 D P 3 0 3 10uH(X) A_DAMP_OUTA- CLF7045T-100M...
Page 331
7463/6463 Main DP601 DP603 DP605 DP607 DP609 [VARA] DP611 RV604 DP613 NOT MOUNT MOUNT DP619 DP604 V21A00028000 V_TV_OUT 605 [V-CN21B] G N D PJ600 NOT MOUNT R6000 [VARA] DP602 V_E1 125mW 75(J) SHIELD GND RV600 CVBS/SY IN VIDEO OUT MOUNT CVBS/SY IN RETURN NOT MOUNT VIDEO OUT RETURN...
Page 333
7463/6463 Main 3 . 3 V _ A V C6010 NOT MOUNT 100nF(K) W6003 G N D CV_E2 0(X) C6009 [TRP] NOT MOUNT Q6003 10uF(K) R6019 2SA1576UB TLQ NOT MOUNT 100(J) NOT MOUNT G N D G N D V21A00025500 FL613 Y_CS_E2 MMZ1005D220CT...
Page 334
7463/6463 Main 3 . 3 V D V44A00005700 C3600 [OTB] 1uF(K) DS360 6.3V R3601 22(J) (VCC) 105 A_SPDIF (Vin) (GND) D3600 OPT-108HA UDZVTE-176.2B G N D [V-J7F] PJ602 R6054 75(J) 100mW R6055 75(J) DP615 R_HP 100mW R6056 75(J) DP616 L_HP 100mW R6057 75(J)
Page 335
7463/6463 Main 5 V D 3 . 3 V _ A V 3 . 3 V D V47A00064200 UREG [V-L6219BXXX] IC612 VOUT 100nF(K) C6093 C6094 [VSS] 1uF(K) TCR2EF33,LM(T 6.3V G N D V47A00045900 MOUNT 100nF(K) [L2571] C6096 IC611 M_CVBSOUT1 125mW VOUT 75(J) V_TV_OUT 600...
Page 336
7463/6463 Main M_CVBS3 107 MOUNT MOUNT C6007 R6034 M_SOGIN1 107 470(J) C6127 C6008 1nF(K) 100nF(K) MOUNT C6045 NOT MOUNT R6100 100nF(K) V_E1 M_CVBS2 107 33(J) C6105 47nF(K) MOUNT 100nF(K) NOT MOUNT R6200 C6200 M_BIN0M 107 68(J) 10K(J) 47nF(K) 2.2uF(K) C6048 R6106 A_L_E1 M_AUL0 105...
Page 337
7463/6463 Main C6064 M_CVBS0 R6136 CV_E2 M_CVBS1 107 33(J) 47nF(K) C6117 C6108 100nF(K) 220pF(J) NOT MOUNT 3.3VD R6142 CR_E2_SW M_CR_SW 106 100(J) C6069 NOT MOUNT...
Page 338
7463/6463 Main MOUNT MOUNT R6094 GREEN_E1 M_GIN1P 107 C6114 RED_E1 33(J) C6082 47nF(K) MOUNT 100nF(K) BLUE_E1 NOT MOUNT MOUNT R6096 M_RIN1P 107 C6115 C6081 33(J) 47nF(K) MOUNT 100nF(K) NOT MOUNT MOUNT R6095 M_BIN1P 107 C6116 33(J) C6083 47nF(K) 100nF(K) NOT MOUNT R6164 C6073 V_PC_R...
Page 353
7463/6463 Main 3.3VD 3.3V_STNBY [ T P ] [ T P ] D P 7 1 2 D P 7 1 5 MOUNT [ T P ] R7022 D P 7 1 1 [ T P ] D P 7 1 4 0(X) NOT MOUNT [ T P ]...
Page 354
7463/6463 Main 3.3VD NOT MOUNT NOT MOUNT R7065 100(J) NOT MOUNT V47A00027400 XC6216C202PR 12V_LNB C_FANSTOP_1 UREG 106 116 [V-L6216CXXX] IC705 NOT MOUNT C_FAN_ENABLE1 VOFB [ T P ] R7063 0(X) D P 7 0 8 [ T P ] 3.3VD NOT MOUNT D P 7 0 9 V22A00098800...
Page 355
7463/6463 Main 3 . 3 V _ D E M O 0(J) R7506 R_SDA_TN R7507 0(J) R_SCL_TN NOT MOUNT FL750 C7506 0ohm 33pF(J) C7507 NEW_V86A00020500 MPZ1608S601AT 33pF(J) NOT MOUNT C7500 TUNER 10uF(K) [V-HBSTPE232] *H7501 G N D DP760 C7501 100nF(K) R_DIF_P ANT5V(GND) R_DIF_N...
Page 356
7463/6463 Main 3 . 3 V D R7560 10K(J) C7552 FL755 FL757 1uF(K) R7562 300ohm 300ohm 100(J) 750 R_DIF_N M_ADCIN 104 750 R_IFAGC R_IFAGC_SoC 104 C7550 MMZ1005Y301CT C7554 MMZ1005Y301CT C7556 R7561 8pF(D) 8pF(D) 22pF(J) 0(X) C7562 R7565 100nF(K) 47K(J) NOT MOUNT C7561 22nF(K) FL758...
Page 367
7463/6463 Main NOT MOUNT C9029 3 . 3 V D 47pF(J) FL904 R9013 R9014 30ohm 390(J) 12K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL905 1 .
Page 368
7463/6463 Main NOT MOUNT C9069 3 . 3 V D 47pF(J) FL913 R9061 R9059 30ohm 150(J) 5.6K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL914 1 .
Page 369
7463/6463 Main C9116 47pF(J) C_POWER_DB 101 116 R9104 R9103 33K(D) 1K(D) 1 2 V _ D C D C V47A00063900 TPS54427DDAR PWM SWITCH 3 . 3 V D C9114 [V-L54228] FL922 C9103 C9105 C9107 IC904 100nF(K) 220ohm 10uF(K) 10uF(K) 10uF(K) C9108 FL921 10nF(K)
Page 370
7463/6463 Main C9166 47pF(J) 5 V _ U S B I N R9153 R9154 1K(D) 56K(D) 5 V _ M H L I N FL932 1 2 V _ D C D C V47A00064000 220ohm TPS54527DDAR M P Z 2 0 1 2 S 2 2 1 A T PWM SWITCH 5 V D C9164...
Page 375
FILE NO. 050-2014022 SERVICE MANUAL LCD Color Television 42L7453D/7463D series (System Information)
Page 376
REVISION HISTORY REV Date Reason for Change Oct/2/2014 On "Updating of Software and Model Setting" in "MAIN BOARD EXCHANGE": Addition of Note in Procedure 1. Addition of Note in Procedure 2. Change of Procedure 3.
Page 377
CONTENTS IMPORTANT NOTICE GREEN PRODUCT PROCUREMENT LEAD-FREE SOLDER SAFETY INSTRUCTION SERVICE MODE LED INDICATIONS FOR SERVICE HOTEL MODE MAIN BOARD EXCHANGE WRITING SERIAL NUMBER INTO MAIN BOARD 10. INTERCONNECT 11. EXPLODED VIEW 12. SCHEMATIC DIAGRAM...
WARRANTY OF ANY KIND, EITHER EXPRESS OR IMPLIED WARRANTY OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. Toshiba shall not be liable for any damages, losses, expenses or costs, if any, incurred in connection with or as a result of use of any information or data provided...
Hazardous Substances. From July 1, 2006, the RoHS Directive will prohibit any marketing of new products containing the restricted substances. Increasing attention is given to issues related to the global environmental. Toshiba Corporation recognizes environmental protection as a key management tasks, and is doing its utmost to enhance and improve the quality and scope of its environmental activities.
(1/4) SAFETY INSTRUCTION WARNING: BEFORE SERVICING THIS CHASSIS, READ THE "SAFETY PRECAUTION" AND "PRODUCT SAFETY NOTICE" INSTRUCTIONS BELOW. Safety Precaution WARNING: SERVICING SHOULD NOT BE ATTEMPTED BY ANYONE UNFAMILIAR WITH THE NECESSARY PRECAUTIONS ON THIS RECEIVER. THE FOLLOWING ARE THE NECESSARY PRECAUTIONS TO BE OBSERVED BEFORE SERVICING THIS CHASSIS.
Page 381
(2/4) Always ensure that all internal wirings are in accordance before re-assembling the external casing after a repairing completed. Do not allow internal wiring to be pinched by cabinets, panels, etc. Any error in reassembly or wiring can result in electrical leakage, flame, etc., and may be hazardous.
Page 382
(3/4) The potential at any point (TOUCH CURRENT) expressed as voltage does not exceed the following value: The part or contact of a TERMINAL is not HAZARDOUS LIVE if: a) The open-circuit voltage should not exceed 35 V (peak) a.c. or 60 V d.c. or, if a) is not met.
Page 383
(4/4) Product Safety Notice Many electrical and mechanical parts in this chassis have special safety-related characteristics. These characteristics are often passed unnoticed by a visual inspection and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltage, wattage, etc.
(1/3) SERVICE MODE ENTERING SERVICE MODE 1. Press button once on Remote Control. TV mode changes as follows. Un-Mute => Mute 2. Press button again and keep pressing. (Sound Mute is canceled) 3. While pressing the button, press button on TV control panel. (Enter Service Mode)
Page 385
(2/3) KEY FUNCTION IN THE SERVICE MODE The following key entry during display of adjustment menu provides special functions. Button Function Test signal selection button (on Remote) (on Remote) Selection of the adjustment items Volume +/– (on Remote) Change of the data value [7] button Automatic A/D Adjustment (PC, Component, Composite(PAL, NTSC))
Page 386
(3/3) ADJUSTING ITEMS IN THE SERVICE MODE Item Description RCUT RED CUTOFF GCUT GREEN CUTOFF BCUT BLUE CUTOFF RDRV RED DRIVE GDRV GREEN DRIVE BDRV BLUE DRIVE OSRC COOL R-CUTOFF-OFFSET for COOL OSRC NATURAL R-CUTOFF-OFFSET for NATURAL OSRC WARM R-CUTOFF-OFFSET for WARM OSGC COOL G-CUTOFF-OFFSET for COOL OSGC NATURAL...
LED INDICATIONS FOR SERVICE SW Upgrade and Error conditions indicated by the Power LED is described below. Power LED Green blink SW Upgrade in Progress SW Upgrade Failed Green SW Upgrade Successful...
(1/18) HOTEL MODE 1. ENTERING HOTEL MODE MENU Hotel Mode Menu should be shown by the following operation. 1) Open Main Menu by pressing Menu button of RCU. 2) Press the following password number “1048” with the button of Remote Control. Note: Hotel Menu can be displayed to input the password number when there is focus in the first layer of Main Menu.
Page 389
(2/18) Factory Item Options Description Gray Out Conditions settings Hotel Mode Enable Hotel Mode Disable Hotel Mode. All the settings of Hotel Mode are disabled. Control Panel Allow use of all Control panel - Grayed out when "Hotel buttons Mode" = [Off] Off (All Functions) Prohibit use of all control panel buttons.
Page 390
(3/18) Remote Control Enable the remote control buttons. - Grayed out when "Hotel Mode" = [Off] Disable the remote control buttons. * The following remote codes are not disabled. - Super User mode (40BFFE) - S mode (40EEC3) * If “Off" is selected, RCU will not function in any menu (including no menu) except Hotel Menu.
Page 391
* Welcome image can be changed through USB Clone Function. A default welcome image (TOSHIBA) is available. Refer to 4.1 for details of Welcome image. Welcome image becomes default by “Reset Hotel Menu”...
Page 392
(5/18) default welcome image (TOSHIBA) is available. Refer to 4.1 for details of Welcome image. Welcome image becomes default by “Reset Hotel Menu” (*But Welcome image don’t becomes default by USB Live Update, Network Upgrade and OAD.) Not display a welcome image every...
Page 393
(6/18) On (AC) TV tunes to preset “POS/VIDEO” (channel or input) only when AC power is applied. When TV is powered on by power button, tune to the last channel or input. TV Tunes to the last channel or input viewed when powered on POS/INPUT/VIDEO - Grayed out when Hotel...
Page 394
(7/18) USB Control USB function available - Grayed out when "Hotel Mode" = [Off] USB function not available but allow - Grayed out when "USB USB bus power Power" = [Off] USB Control is off will make “USB Live Upgrade” and “AC on USB upgrade”...
Page 395
(8/18) Volume" = [Off] Change Picture Mode Picture setting mode is forced to - Grayed out when "Hotel (Only available when “Fixed Picture Mode” mode. Mode" = [Off] “Menu Control / “Main menu/Picture Mode”, “Quick Picture" is On.) menu/Picture Mode” and “RCU/select picture mode button”...
Page 396
(9/18) is set to “Off” and the “Wake on LAN Standby Mode” is set to “On”, the standby mode is “WoL Standby”. - When “Active Standby Mode” and “Wake on LAN Standby Mode” are set to “Off”, the standby mode is “Standby”.
Page 397
(10/18) USB Clone Function Start USB Clone Press “OK” on "Start USB Clone" Start - Grayed out when "Hotel button, USB Clone mode initial Clone Mode" = [Off] window is displayed. - Grayed out when "USB * Refer to “4. USB CLONE Power"...
Page 398
(11/18) *Tuner screen (etc.) is not displayed from power On to the contents playback as much as possible. Offline Playback contents in USB memory inserted in DTV by Media Player without confirmation message, when turning on DTV. In addition, playback contents in USB memory by Media Player without confirmation message,...
Page 399
(12/18) content, display ERROR “Unsupported file”. And return the Photo List to root of USB memory. Video Video contents in root of USB memory are selected and play back. In case of no playback content, display ERROR “Unsupported file”. And return the Video List to root of USB memory.
Page 400
(13/18) Reset Signage When select this item, Menu display “Are you sure you want to reset to default settings? (Yes/No (Default:No))” message. If select Yes, set to default all setting in Signage Mode Menu * Signage Menu settings should not be reset by “Reset TV”...
Page 401
(14/18) Explanation of AD Channel List A/D Channel List = Off A/D Channel List = On DTV Mode ATV Mode DTV Mode ATV Mode Press [LIST] key Press [LIST] key Press [LIST] key Press [LIST] key DTV Mode ATV Mode DTV Mode ATV Mode DTV Channel List...
Page 402
*However, URL can be operated on the site specially developed. ・File type: Text Note: When user would like to copy “URL of Toshiba Cloud TV Services”, the clone data should be hotelCloudConfig.txt” file exported to USB memory in advance and then put “...
Page 403
(16/18) Note: The title of the screen image changes to USB Clone. [1-1] [1-2] OK key [1-3] Complete copy Error...
Page 404
(17/18) 4.3. To write data form USB to TV (1) Press “OK” on “Start USB Clone” button of “USB Clone Function”, USB Clone mode initial window [2-1] is displayed. (2) Insert USB memory, select USB to TV [2-1], and press [OK] key. (3) The window [2-3] will be displayed.
Page 405
(18/18) Note: The title of the screen image changes to USB Clone. [2-2] [2-1] Right and Down key Up and Left key OK key [2-3] Error Complete copy [2-5] [2-4] EXIT key Restart power...
(1/3) MAIN BOARD EXCHANGE When Main board is exchanged, the Application SW (Firrmware) and Model Setting need to be updated and the serial number needs to be written the serial number into Main Board (see “WRITING SERIAL NUMBER INTO MAIN BOARD”). Please update in the following procedures.
Page 407
(2/3) Unplug TV, and then Insert the USB mass storage device to the USB slot of the TV. Note : Please unplug TV after turning ON TV by "Power" key on remote control. During pressing “-” key of side key on TV, plug TV. Note : Please continue pressing "-"...
Page 408
(3/3) Confirmation of Software updating Check the TV Model and Model Info by using self check screen. 1. Press SETUP on Remote Control. 2. Select “Get Help” >> “System Information” 3. Press “3” “5” “7” “4” Self check screen is displayed. TV model and Panel vendor [The 4...
(1/2) WRITING SERIAL NUMBER INTO MAIN BOARD When the board is broken, service man will go to customers home and change the board. After change the board service man has to put the serial number same as before. So the service man will use the PC and write the serial number to USB mass storage device.
Page 410
(2/2) After finish writing the “OK” and “Serial number” appear on TV. OK!! Serial No: C35244C00001D1 Unplug USB mass storage device. Check the serial number by using self check screen. How to enter the self check screen. Press SETUP on remote control unit. Select “Get Help”...
Page 430
7453/6453 Main 3 . 3 V D 101 116 C_POWER_DDR 5 V 1 V47A00045600 1 . 5 V _ D D R D1242 R1241 3 . 3 V D 1SS355VMTE-17 UREG 47(J) [V-LMM185*] 100mW IC124 NOT MOUNT R1240 [SBD] [SBD] D1240 D1241 0(X)
Page 431
7453/6453 Main 1.5V_DDR NOT MOUNT 102 M_DDRARESET R1242 0(X) 1.5V_DDR V46A00063900 XC6108N12AMR 3.3V_STNBY 1.5V_DDR RESET IC [V-L6108] IC123 M_DDRARST 120 VSEN VOUT R1252 0(X) M_DDRBRST 121 R1253 C1283 0(X) 100nF(K) C1284 4.7nF(K) NOT MOUNT 102 M_DDRBRESET R1243 0(X) NOT MOUNT R1245 0(X) V41A00002900...
Page 436
7453/6453 Main 5 V _ W L A N 3 . 3 V _ S T N B Y FL163 5 V _ W L A N 5 V 1 V41A00023900 Q1652 MPZ1608S221AT SSM6J414TU,LF(T [MFPI] V22A00100300 FL167 [C6A2] CN162 MPZ1608S221AT M_USB0DM M_USB0DP C1652...
Page 439
7453/6453 Main 3 . 3 V _ D A M P V R E G _ A M P V47A00062900 D-AMP [V-L5760DAPR] IC370 R3700 SFT_CLIP SPK_FAULT 373 370 A_DAMP_SD 0(X) SPK_GAIN0 G N D SPK_GAIN1 W3721 0(X) M_I2CDATA 101 116 755 FREQ/SDA M_I2CCLK 101 116 755...
Page 440
7453/6453 Main L372 10uH(X) A_DAMP_OUTA+ CLF7045T-100M Ω V C C _ A U D I O G N D D P 3 0 0 D P 3 0 1 Ω D P 3 0 2 L373 D P 3 0 3 10uH(X) A_DAMP_OUTA- CLF7045T-100M...
Page 442
7453/6453 Main DP601 DP603 DP605 DP607 DP609 [VARA] DP611 RV604 DP613 NOT MOUNT MOUNT DP619 DP604 V21A00028000 V_TV_OUT 605 [V-CN21B] G N D PJ600 NOT MOUNT R6000 [VARA] DP602 V_E1 125mW 75(J) SHIELD GND RV600 CVBS/SY IN VIDEO OUT MOUNT CVBS/SY IN RETURN NOT MOUNT VIDEO OUT RETURN...
Page 444
7453/6453 Main 3 . 3 V _ A V C6010 NOT MOUNT 100nF(K) W6003 G N D CV_E2 0(X) C6009 [TRP] NOT MOUNT Q6003 10uF(K) R6019 2SA1576UB TLQ NOT MOUNT 100(J) NOT MOUNT G N D G N D V21A00025500 FL613 Y_CS_E2 MMZ1005D220CT...
Page 445
7453/6453 Main 3 . 3 V D V44A00005700 C3600 [OTB] 1uF(K) DS360 6.3V R3601 22(J) (VCC) 105 A_SPDIF (Vin) (GND) D3600 OPT-108HA UDZVTE-176.2B G N D [V-J7F] PJ602 R6054 75(J) 100mW R6055 75(J) DP615 R_HP 100mW R6056 75(J) DP616 L_HP 100mW R6057 75(J)
Page 446
7453/6453 Main 5 V D 3 . 3 V _ A V 3 . 3 V D V47A00064200 UREG [V-L6219BXXX] IC612 VOUT 100nF(K) C6093 C6094 [VSS] 1uF(K) TCR2EF33,LM(T 6.3V G N D V47A00045900 MOUNT 100nF(K) [L2571] C6096 IC611 M_CVBSOUT1 125mW VOUT 75(J) V_TV_OUT 600...
Page 447
7453/6453 Main M_CVBS3 107 MOUNT MOUNT C6007 R6034 M_SOGIN1 107 470(J) C6127 C6008 1nF(K) 100nF(K) MOUNT C6045 NOT MOUNT R6100 100nF(K) V_E1 M_CVBS2 107 33(J) C6105 47nF(K) MOUNT 100nF(K) NOT MOUNT R6200 C6200 M_BIN0M 107 68(J) 10K(J) 47nF(K) 2.2uF(K) C6048 R6106 A_L_E1 M_AUL0 105...
Page 448
7453/6453 Main C6064 M_CVBS0 R6136 CV_E2 M_CVBS1 107 33(J) 47nF(K) C6117 C6108 100nF(K) 220pF(J) NOT MOUNT 3.3VD R6142 CR_E2_SW M_CR_SW 106 100(J) C6069 NOT MOUNT...
Page 449
7453/6453 Main MOUNT MOUNT R6094 GREEN_E1 M_GIN1P 107 C6114 RED_E1 33(J) C6082 47nF(K) MOUNT 100nF(K) BLUE_E1 NOT MOUNT MOUNT R6096 M_RIN1P 107 C6115 C6081 33(J) 47nF(K) MOUNT 100nF(K) NOT MOUNT MOUNT R6095 M_BIN1P 107 C6116 33(J) C6083 47nF(K) 100nF(K) NOT MOUNT R6164 C6073 V_PC_R...
Page 464
7453/6453 Main 3.3VD 3.3V_STNBY [ T P ] [ T P ] D P 7 1 2 D P 7 1 5 MOUNT [ T P ] R7022 D P 7 1 1 [ T P ] D P 7 1 4 0(X) NOT MOUNT [ T P ]...
Page 465
7453/6453 Main 3.3VD NOT MOUNT NOT MOUNT R7065 100(J) NOT MOUNT V47A00027400 XC6216C202PR 12V_LNB C_FANSTOP_1 UREG 106 116 [V-L6216CXXX] IC705 NOT MOUNT C_FAN_ENABLE1 VOFB [ T P ] R7063 0(X) D P 7 0 8 [ T P ] 3.3VD NOT MOUNT D P 7 0 9 V22A00098800...
Page 466
7453/6453 Main 3 . 3 V _ D E M O 0(J) R7506 R_SDA_TN R7507 0(J) R_SCL_TN NOT MOUNT FL750 C7506 0ohm 33pF(J) C7507 NEW_V86A00020500 MPZ1608S601AT 33pF(J) NOT MOUNT C7500 TUNER 10uF(K) [V-HBSTPE232] *H7501 G N D DP760 C7501 100nF(K) R_DIF_P ANT5V(GND) R_DIF_N...
Page 467
7453/6453 Main 3 . 3 V D R7560 10K(J) C7552 FL755 FL757 1uF(K) R7562 300ohm 300ohm 100(J) 750 R_DIF_N M_ADCIN 104 750 R_IFAGC R_IFAGC_SoC 104 C7550 MMZ1005Y301CT C7554 MMZ1005Y301CT C7556 R7561 8pF(D) 8pF(D) 22pF(J) 0(X) C7562 R7565 100nF(K) 47K(J) NOT MOUNT C7561 22nF(K) FL758...
Page 478
7453/6453 Main NOT MOUNT C9029 3 . 3 V D 47pF(J) FL904 R9013 R9014 30ohm 390(J) 12K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL905 1 .
Page 479
7453/6453 Main NOT MOUNT C9069 3 . 3 V D 47pF(J) FL913 R9061 R9059 30ohm 150(J) 5.6K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL914 1 .
Page 480
7453/6453 Main C9116 47pF(J) C_POWER_DB 101 116 R9104 R9103 33K(D) 1K(D) 1 2 V _ D C D C V47A00063900 TPS54427DDAR PWM SWITCH 3 . 3 V D C9114 [V-L54228] FL922 C9103 C9105 C9107 IC904 100nF(K) 220ohm 10uF(K) 10uF(K) 10uF(K) C9108 FL921 10nF(K)
Page 481
7453/6453 Main C9166 47pF(J) 5 V _ U S B I N R9153 R9154 1K(D) 56K(D) 5 V _ M H L I N FL932 1 2 V _ D C D C V47A00064000 220ohm TPS54527DDAR M P Z 2 0 1 2 S 2 2 1 A T PWM SWITCH 5 V D C9164...
Page 502
7463/6463 Main 3 . 3 V D 101 116 C_POWER_DDR 5 V 1 V47A00045600 1 . 5 V _ D D R D1242 R1241 3 . 3 V D 1SS355VMTE-17 UREG 47(J) [V-LMM185*] 100mW IC124 NOT MOUNT R1240 [SBD] [SBD] D1240 D1241 0(X)
Page 503
7463/6463 Main 1.5V_DDR NOT MOUNT 102 M_DDRARESET R1242 0(X) 1.5V_DDR V46A00063900 XC6108N12AMR 3.3V_STNBY 1.5V_DDR RESET IC [V-L6108] IC123 M_DDRARST 120 VSEN VOUT R1252 0(X) M_DDRBRST 121 R1253 C1283 0(X) 100nF(K) C1284 4.7nF(K) NOT MOUNT 102 M_DDRBRESET R1243 0(X) NOT MOUNT R1245 0(X) V41A00002900...
Page 508
7463/6463 Main 5 V _ W L A N 3 . 3 V _ S T N B Y FL163 5 V _ W L A N 5 V 1 V41A00023900 Q1652 MPZ1608S221AT SSM6J414TU,LF(T [MFPI] V22A00100300 FL167 [C6A2] CN162 MPZ1608S221AT M_USB0DM M_USB0DP C1652...
Page 511
7463/6463 Main 3 . 3 V _ D A M P V R E G _ A M P V47A00062900 D-AMP [V-L5760DAPR] IC370 R3700 SFT_CLIP SPK_FAULT 373 370 A_DAMP_SD 0(X) SPK_GAIN0 G N D SPK_GAIN1 W3721 0(X) M_I2CDATA 101 116 755 FREQ/SDA M_I2CCLK 101 116 755...
Page 512
7463/6463 Main L372 10uH(X) A_DAMP_OUTA+ CLF7045T-100M Ω V C C _ A U D I O G N D D P 3 0 0 D P 3 0 1 Ω D P 3 0 2 L373 D P 3 0 3 10uH(X) A_DAMP_OUTA- CLF7045T-100M...
Page 514
7463/6463 Main DP601 DP603 DP605 DP607 DP609 [VARA] DP611 RV604 DP613 NOT MOUNT MOUNT DP619 DP604 V21A00028000 V_TV_OUT 605 [V-CN21B] G N D PJ600 NOT MOUNT R6000 [VARA] DP602 V_E1 125mW 75(J) SHIELD GND RV600 CVBS/SY IN VIDEO OUT MOUNT CVBS/SY IN RETURN NOT MOUNT VIDEO OUT RETURN...
Page 516
7463/6463 Main 3 . 3 V _ A V C6010 NOT MOUNT 100nF(K) W6003 G N D CV_E2 0(X) C6009 [TRP] NOT MOUNT Q6003 10uF(K) R6019 2SA1576UB TLQ NOT MOUNT 100(J) NOT MOUNT G N D G N D V21A00025500 FL613 Y_CS_E2 MMZ1005D220CT...
Page 517
7463/6463 Main 3 . 3 V D V44A00005700 C3600 [OTB] 1uF(K) DS360 6.3V R3601 22(J) (VCC) 105 A_SPDIF (Vin) (GND) D3600 OPT-108HA UDZVTE-176.2B G N D [V-J7F] PJ602 R6054 75(J) 100mW R6055 75(J) DP615 R_HP 100mW R6056 75(J) DP616 L_HP 100mW R6057 75(J)
Page 518
7463/6463 Main 5 V D 3 . 3 V _ A V 3 . 3 V D V47A00064200 UREG [V-L6219BXXX] IC612 VOUT 100nF(K) C6093 C6094 [VSS] 1uF(K) TCR2EF33,LM(T 6.3V G N D V47A00045900 MOUNT 100nF(K) [L2571] C6096 IC611 M_CVBSOUT1 125mW VOUT 75(J) V_TV_OUT 600...
Page 519
7463/6463 Main M_CVBS3 107 MOUNT MOUNT C6007 R6034 M_SOGIN1 107 470(J) C6127 C6008 1nF(K) 100nF(K) MOUNT C6045 NOT MOUNT R6100 100nF(K) V_E1 M_CVBS2 107 33(J) C6105 47nF(K) MOUNT 100nF(K) NOT MOUNT R6200 C6200 M_BIN0M 107 68(J) 10K(J) 47nF(K) 2.2uF(K) C6048 R6106 A_L_E1 M_AUL0 105...
Page 520
7463/6463 Main C6064 M_CVBS0 R6136 CV_E2 M_CVBS1 107 33(J) 47nF(K) C6117 C6108 100nF(K) 220pF(J) NOT MOUNT 3.3VD R6142 CR_E2_SW M_CR_SW 106 100(J) C6069 NOT MOUNT...
Page 521
7463/6463 Main MOUNT MOUNT R6094 GREEN_E1 M_GIN1P 107 C6114 RED_E1 33(J) C6082 47nF(K) MOUNT 100nF(K) BLUE_E1 NOT MOUNT MOUNT R6096 M_RIN1P 107 C6115 C6081 33(J) 47nF(K) MOUNT 100nF(K) NOT MOUNT MOUNT R6095 M_BIN1P 107 C6116 33(J) C6083 47nF(K) 100nF(K) NOT MOUNT R6164 C6073 V_PC_R...
Page 536
7463/6463 Main 3.3VD 3.3V_STNBY [ T P ] [ T P ] D P 7 1 2 D P 7 1 5 MOUNT [ T P ] R7022 D P 7 1 1 [ T P ] D P 7 1 4 0(X) NOT MOUNT [ T P ]...
Page 537
7463/6463 Main 3.3VD NOT MOUNT NOT MOUNT R7065 100(J) NOT MOUNT V47A00027400 XC6216C202PR 12V_LNB C_FANSTOP_1 UREG 106 116 [V-L6216CXXX] IC705 NOT MOUNT C_FAN_ENABLE1 VOFB [ T P ] R7063 0(X) D P 7 0 8 [ T P ] 3.3VD NOT MOUNT D P 7 0 9 V22A00098800...
Page 538
7463/6463 Main 3 . 3 V _ D E M O 0(J) R7506 R_SDA_TN R7507 0(J) R_SCL_TN NOT MOUNT FL750 C7506 0ohm 33pF(J) C7507 NEW_V86A00020500 MPZ1608S601AT 33pF(J) NOT MOUNT C7500 TUNER 10uF(K) [V-HBSTPE232] *H7501 G N D DP760 C7501 100nF(K) R_DIF_P ANT5V(GND) R_DIF_N...
Page 539
7463/6463 Main 3 . 3 V D R7560 10K(J) C7552 FL755 FL757 1uF(K) R7562 300ohm 300ohm 100(J) 750 R_DIF_N M_ADCIN 104 750 R_IFAGC R_IFAGC_SoC 104 C7550 MMZ1005Y301CT C7554 MMZ1005Y301CT C7556 R7561 8pF(D) 8pF(D) 22pF(J) 0(X) C7562 R7565 100nF(K) 47K(J) NOT MOUNT C7561 22nF(K) FL758...
Page 550
7463/6463 Main NOT MOUNT C9029 3 . 3 V D 47pF(J) FL904 R9013 R9014 30ohm 390(J) 12K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL905 1 .
Page 551
7463/6463 Main NOT MOUNT C9069 3 . 3 V D 47pF(J) FL913 R9061 R9059 30ohm 150(J) 5.6K(D) 1 2 V _ D C D C V47A00063900 M P Z 2 0 1 2 S 3 0 0 A T TPS54427DDAR PWM SWITCH FL914 1 .
Page 552
7463/6463 Main C9116 47pF(J) C_POWER_DB 101 116 R9104 R9103 33K(D) 1K(D) 1 2 V _ D C D C V47A00063900 TPS54427DDAR PWM SWITCH 3 . 3 V D C9114 [V-L54228] FL922 C9103 C9105 C9107 IC904 100nF(K) 220ohm 10uF(K) 10uF(K) 10uF(K) C9108 FL921 10nF(K)
Page 553
7463/6463 Main C9166 47pF(J) 5 V _ U S B I N R9153 R9154 1K(D) 56K(D) 5 V _ M H L I N FL932 1 2 V _ D C D C V47A00064000 220ohm TPS54527DDAR M P Z 2 0 1 2 S 2 2 1 A T PWM SWITCH 5 V D C9164...