Page 1
This Service Manual describes replacement parts for the green products. When repairing these green products, use the parts described in this manual and lead-free solder (*2). For (*1) and (*2), see the next page. TOSHIBA CORPORATION, 2006 Published in Japan, Apr. 2006 (YC)
Hazardous Substances. From July 1, 006, the RoHS Directive will prohibit any marketing of new products containing the restricted substances. Increasing attention is given to issues related to the global environmental. Toshiba Corporation recognizes environmental protection as a key management tasks, and is doing its utmost to enhance and improve the quality and scope of its environmental activities.
SERVICE SAFETY PRECAUTIONS • The caution items shown here describe major safety issues and should always be observed. • The meanings of the various indications are as follows. Indicates a hypothetical situation in which service personnel and nearby third parties, or even WARNING end users due to a product defect after the service operation is completed, could possibly be in danger of injury or even death in the event of operational error.
Page 4
WARNING • Always advise users to keep children away. There is danger of injury to children from tools, disassembled products, etc. KEEP CHILDREN AWAY • Always disconnect the power plug before starting work whenever power is not required. Failure to disconnect the power plug before starting work can result in electrical shock. UNPULUG •...
HANDLING THE LCD MODULE Safety Precautions 3. If the panel surface becomes soiled, wipe with cotton or a In the event that the screen is damaged or the liquid crystal soft cloth. If this does not remove the soiling, breathe on (fluid) leaks, do not breathe in or drink this fluid.
Page 6
7. Do not expose the LCD module to direct sunlight or strong ultraviolet rays for an extended period of time. 8. Do not store the LCD module below the temperature con- ditions described in the specifications. Failure to do so could result in freezing of the liquid crystal due to cold air or loss of resilience or other damage.
SERVICE MODE 1. ENTERING SERVICE MODE 1) Press button once on ) Press button again and 3) While pressing the button, Remote Control. keep pressing. press MENU button on TV set. ADDR DATA BINARY 0000H 00H 00000000B or Sound Mute (Service mode display) 2.
Page 8
SELECTING THE ADJUSTING ITEMS 1) Every pressing of CHANNEL ▲ button in the service mode changes the adjustment items in the order of table-1. (▼ button for reverse order) ADJUSTING THE DATA 1) Pressing of VOLUME +/– button will change the value of data in the range from 00H to FFH. The variable range depends on the adjusting item.
Page 9
NG is abnormal(Red indication). When type name of semiconductor indicates. Block : TV reception mode V1-V : VIDEO 1- input mode : PC mode : YUV mode : DTV mode WL66A,E,R,T (Composite/Component) (S-VIDEO) (Component) HDMI 32WL66A/E/R/T - -...
Page 10
: A/D adjustment set incorrect. LCD Panel Vender information display The following Panel Vender and screen size are displayed. Panel Vender Screen Size(Inch) Example : AUO-32 indicates that Vender is AUO and Screen Size is 32 inch. 32WL66A/E/R/T - 10 -...
Page 11
10. STATUS CHECK MODE 1) Press “9” button thrice on Remote Control during display of adjustment menu in the service mode. The status of this model will begin to check. ) During Status Check, the following displays are shown. Status check ...
Page 12
11. SETTING HOTEL MODE Enter to service mode and select Hotel Mode menu by pressing P▲ or P▼. + to enter details setting in Hotel Mode. After selecting Hotel Mode, press To select menu, press P▲ or P▼ and press OK to enter the adjustment menu of OPT. + or −.
Page 13
12. SETTING & ADJUSTING DATA [SERVICE MODE] ADJUSTING ITEMS AND DATA IN THE SERVICE MODE: Item Name of adjustment ASIA Item Name of adjustment ASIA Preset Data Preset Data RCUT R CUT OFF VOLUX MAX VOLUME LIMITED GCUT G CUT OFF PLLW0 PLL WAIT TIME BCUT...
LOCATION OF CONTROLS TV top and front panel controls TV top view TV front view You can swivel the TV screen. Swivel angle: 15 degrees to left and right. o (Input source selection) — When no menu is on- 1 (Power on/Standby) — Press to turn the TV on/ screen, this button selects the input source.
Page 15
TV side and back panel connections TV back view Power cord Cable holder Right side view Headphones (Not supplied) 10 O MONITOR (output terminals) — Standard video 15 D (Headphone jack) — For use with headphones. and standard audio outputs. Note: 11 o (3) (Video 3 input terminals) —...
Page 16
Learning about the remote control Location of controls Teletext on/off Power on/Standby • CALL • Initial/index function for Teletext Number buttons (0-9) • Input source selection To return to the previous program (O1 - O3, HDMI, PC) • To access sub-pages Picture mode selection when in teletext Picture size selection...
• The part number must be used when ordering parts, in order to assist in processing, be sure to include the Model number and Description. ∗ • The PC board assembly with mark is no longer available after the end of the production. Model : 32WL66A/32WL66E/32WL66R/32WL66T Capacitors ....CD Ceramic Disk : Plastic Film : Electrolytic Resistors ....
Page 20
Location Parts No. Description Location Parts No. Description C666 #1 76073083 ELECTROLYTIC, 50V 3.3UF M 3A CA71 76100104 CERAMIC CHIP, 5V F 0.1UF Z # 76073083 ELECTROLYTIC, 50V 3.3UF M 3A CA90 76100104 CERAMIC CHIP, 5V F 0.1UF Z #3 76669339 ELECTROLYTIC, 50V 3.3UF M CA91 76105101...
Page 21
Location Parts No. Description Location Parts No. Description CG07 #1 76073086 ELECTROLYTIC, 50V 10UF M 3A CG55 7610910 CERAMIC CHIP, 50V B 1000PF K # 76073086 ELECTROLYTIC, 50V 10UF M 3A CS01 760976 CERAMIC CHIP, 10V B .UF K #3 76669100 ELECTROLYTIC, 50V 10UF M CS03 760976...
Page 31
FRONT AV BOARD PE0031D2 (U02B) LED BOARD PE0031D3 (U02C) BOTTOM (FOIL) SIDE BOTTOM (FOIL) SIDE V8A00004A0 CB0 PA01B PV5A CB04 R-1786 RB09 R-1786 KB01 RB RB08 V8A00004A0 DB04 DB01 DV10 RV11 RV1 RC1 RC11 CC11 CC1 GR605 P661 PV61 PV60 FRONT AV BOARD PE0031D2 (U02B) LED BOARD PE0031D3 (U02C) TOP (COMPONENT) SIDE...
Page 32
SCHEMATIC DIAGRAM MODEL : 32WL66A / 32WL66E / 32WL66R / 32WL66T WARNING : BEFORE SERVICING THIS CHASSIS, READ THE "SERVICE SAFETY PRECAUTIONS" ON PAGE 4 OF THIS MANUAL. CAUTION : The international hazard symbols " " in the schematic diagram and the parts list designate components which have special characteristics important for safety and should be replaced only with types identical to those in the original circuit or specified in the parts list.
Page 33
n SCHEMATIC DIAGRAM STRUCTURE: 3WL66A/E/T CONNECTOR [SHEET-1] ..1/35 MAIN_POWER [SHEET-] ../35 SUB_POWER [SHEET-3] ..3/35 AC-INPUT [SHEET-4] ..4/35 REGULATOR 1 [SHEET-5] ..5/35 FOR UK DIGITAL [SHEET-6] ..6/35 FOR HDD [SHEET-7] ..7/35 FOR FAN [SHEET-8] ..8/35 PROTECTER [SHEET-9] ..9/35 REGULATOR [SHEET-10] ..10/35 3WL66R CONNECTOR [SHEET-1] ..11/35...
Aspect ratio LCD color television 16 : 9 Visible size (diagonal) Model 80.0 cm 32WL66A, 32WL66E, 32WL66R, 32WL66T Number of pixels Power source 1366 (H) dots X 768 (V) dots 32WL66A: 220V-240V AC, 50Hz 32WL66E: 220V-240V AC, 50/60Hz Audio power...
SCHEMATIC DIAGRAM MODEL : 32WL66A / 32WL66E / 32WL66R / 32WL66T WARNING : BEFORE SERVICING THIS CHASSIS, READ THE "SERVICE SAFETY PRECAUTIONS" ON THE MANUAL FOR THIS MODEL. CAUTION : The international hazard symbols " " in the schematic diagram and the parts list designate components which have special characteristics important for safety and should be replaced only with types identical to those in the original circuit or specified in the parts list.
Page 38
SCHEMATIC DIAGRAM STRUCTURE: 32WL66A/E/T CONNECTOR [SHEET-1] ..1/35 MAIN_POWER [SHEET-2] ..2/35 SUB_POWER [SHEET-3] ..3/35 AC-INPUT [SHEET-4] ..4/35 REGULATOR 1 [SHEET-5] ..5/35 FOR UK DIGITAL [SHEET-6] ..6/35 FOR HDD [SHEET-7] ..7/35 FOR FAN [SHEET-8] ..8/35 PROTECTER [SHEET-9] ..9/35 REGULATOR 2 [SHEET-10] ..10/35...
Page 45
ZE91 OPEN 75mA OPEN 12VD 1-E3 CE97 OPEN DE97 RE73 RE74 OPEN OPEN OPEN DE96 OPEN QE92 OPEN LE90 6.2V/500mA OPEN 1-C1 RE92 RE94 DE98 CE94 GJ75 OPEN OPEN CE98 OPEN OPEN OPEN OPEN 32WL66A/E/T FOR UK DIGITAL [SHEET-6] (6/35)
Page 46
DE57 OPEN RE66 OPEN RE77 OPEN 1-C1,5-B1 POWER_DB QE77 POWER_HDD 1-D1 RE78 OPEN OPEN 1200mA 5V_HDD 1-B4 RE63 RE64 RE67 QE81 CE58 OPEN OPEN QE80 OPEN CE59 OPEN OPEN OPEN OPEN DE58 OPEN RE68 OPEN 32WL66A/E/T FOR HDD [SHEET-7] (7/35)
Page 47
1-C4,1-C5,2-B7,8-B1,10-A1 AUDIO_VCC 12V_HDD VCC_HDD_FAN DE95 RE90 1-A4,7-A2 1-A2,8-B2 OPEN OPEN DE91 RE47 OPEN RE45 QE43 1-D1 FAN_CTR RE49 R896 R897 OPEN OPEN 1-C4,1-C5,2-B7,8-A1,10-A1 AUDIO_VCC R894 R866 OPEN 1-A2,8-A2 VCC_HDD_FAN D897 OPEN R895 OPEN R867 R868 32WL66A/E/T FOR FAN [SHEET-8] (8/35)
Page 50
TO SET FAN TO HDD FAN TO POWER BOARD TO HDD TO LOWB BOARD P808A P813B PG04 P813A PG02 P818 P819 PLUG_2mm_6P\B6B-PH-K-S 2.0mm3P\B3B-PH-K-S OPEN OPEN EARTH TERMINAL\MET31-0332 GND_1 EARTH TERMINAL\MET31-0332 2.0mm3P\B3B-PH-K-S To chassis GND GND_1 2-C7 To chassis GND 7-A2,8-A2 12V_HDD 5V_HDD 7-B2...
Page 55
QE75 OPEN QE35B OPEN QE35A OPEN OPEN QE35 3.4V/1200mA 800mA LE76 3.3VD 3.3VD 2.5VD 1-E3 OPEN 18V1 1-E3,6-A2 1-E3,6-A2 RE35 RE75 RE76 RE71 RE72 DE76 OPEN 3-D8,5-A1,7-A1,8-A1 CE72 GJ76 OPEN OPEN OPEN OPEN OPEN CE60 RE36 OPEN OPEN CE35 OPEN CE36 OPEN OPEN...
Page 56
QE76 OPEN LE74 370mA OPEN 3-D8,5-A1,6-A1,8-A1 1-A4,8-A2 18V1 12V_HDD RE69 RE70 RE65 CE56 QE79 GJ74 OPEN OPEN CE54 QE78 OPEN OPEN OPEN OPEN OPEN OPEN DE57 OPEN RE66 OPEN RE77 OPEN 1-C1,5-B1 POWER_DB QE77 POWER_HDD 1-D1 RE78 OPEN OPEN 1200mA 5V_HDD 1-B4 RE63...
Page 57
HDD FAN REG only LHT66 QE46 OPEN SET FAN REG RE41 OPEN QE91B RE42 QE91A OPEN OPEN QE91 ZE90 OPEN OPEN 180mA 3-D8,5-A1,6-A1,7-A1 18V1 1-A2 12V_FAN QE45 CE93 VCC_HDD_FAN OPEN 1-C4,1-C5,2-B7,8-B1,10-A1 1-A4,7-A2 AUDIO_VCC 12V_HDD VCC_HDD_FAN DE95 RE90 1-A2,8-B2 OPEN OPEN DE91 RE47 OPEN...
Page 66
PV90 KRD-8622 PC-DSUB GR35 SHORT RR04 RR01 1/8W75 DR01 OPEN RR02 RR05 1/8W75 DR02 OPEN BLUE_PC RR03 RR06 1/8W75 DR03 OPEN DR04 DR05 OPEN OPEN 32WL66A/E/R/T PC-IN BOARD [SHEET-7] (27/35)
Page 67
S801 ESB92S21B 23344530 P802E LOCK 2P BLACK P802D P802C OPEN OPEN LINE LINE NEUTRAL NEUTRAL TO POWER FROM ACINPUT only 42WL66C 32WL66A/E/R/T AC SW [SHEET-8] (28/35)