Advertisement
Data
Table
Innovative Electronics
Ozone science (for microbe + colour control)
1.
2
3.
4.
The problems with drinking chlorinated water:
-
Chlorine and organic matter create THMs (tri-halomethanes) which are
carcinogens.
-
Chlorine struggles to kill protozoa such as Giardia and Cryptosporidium.
-
Chlorine can create odours and discoloration.
-
Chlorine leaves a chemical residue.
-
Chlorine is a relatively weak oxidant (50% weaker than ozone).
-
Chlorine is a relatively slow acting oxidant (kills cellular microbes 3,000 times
slower than ozone).
The problem with particulate filters:
When used alone they do not remove the following:
-
bacteria and viruses
-
chlorine, fluoride
and they must be replaced regularly, e.g. 6 monthly.
The problem with carbon filters:
When used alone they do not remove the following:
-
bacteria and viruses
-
dissolved ions
and they are easily colonised by bacteria. They must be replaced regularly or
pollutants just pass straight through them.
Particulate Filters + Carbon + Ozone can solve these problems.
Useful Conversions
1m = 1000 mm = 3.38 feet
1kg = 1000 g = 2.20 pounds
1Pa = 0.102 mm water = 0.004 inches water
3
1 l/s = 3.60 m
/hr = 2.12 cfm
1kW = 1000 W = 1.34 hp
Ozone: 1 ppm (by volume) = 2 mg/m
(at 1 atmosphere and 25˚C).
K 4
BOAHW014
Water Purifier Code →
Application
Outlets supplied as standard
- Nozzle
- Valve
- Hose
Oxidant output, maximum (dryer chamber fitted) (mg/hour)
Oxidant concentration, maximum (ppm)
Air/gas flow rate, maximum (litres/minute)
Rated power, nominal (watts)
Weight, nominal (kg)
Dimensions, as standard
- Width W (mm)
- Length L (mm)
- Height H (mm)
Water flow rate, design level (litres/minute)
Filter life, recommendation to change (operating hours)
Filter life, at 5% utilisation (years)
Height of tank or vessel, maximum (m)
Features
- plasma ozone emitter, tubular
- air pump
- plastic body
- certified: no electromagnetic interference
- Dryer Chamber accessory can be fitted
- cyclical timer
- automatic on/off, via flow switch and venturi
- on/off switch and safety micro switch
The air contains pure oxygen
molecules.
Ozone is formed by the Plasma
emitters and then dissolved into
the water.
The third oxygen atom attaches to
a pollutant to oxidise it to a
harmless molecule.
Leaving pure oxygen again.
-
organic contaminants
-
minerals
-
fluoride
-
minerals
= 2000 µg/m
3
3
© Ozone Pollution Technology 2001
WT1
WP1
WP1-750
Connect to
Drop ball
Drop ball
tap faucet
into vessel
into tank
Tap connector
Porous ball
Porous ball
Check valve
–
Check valve
1m hose
3m hose
6m hose
200
200
750
1,500
1,500
2,000
0.5
0.5
1.0
30
30
120
5.0
4.0
8.0
140
140
140
170
330
550
380
170
170
2
–
–
1,500
–
–
3.5
3.5
3.5
–
1
4
–
–
–
–
–
–
Accessories
Filter Cartridge for
WT1. Code 3848UV.
Check Valve for all
models. Code 3847UV.
Replacement Filters & Check Valves
Purifier
Hose (Type)
Hose Code
WT1
10mm x 1m
HS10
WP1
6mm x 5m
HS6
WP1-750
6mm x 5m
HS6
Spare Hose
The problems with ultraviolet products (radiation type):
When used correctly they can kill microbes, but they have no effect on other
pollutants such as:
-
organic contaminants
-
minerals
-
chlorine
Their ability to kill microbes reduces dramatically:
-
if there is organic load or sediment in the water, which shields the
microbes from UV rays
-
if the UV tubes are not regularly cleaned
-
if the water flow rate is too high.
The UV tubes break easily.
The UV radiation is carcinogenic if it escapes from the chamber.
Application notes
1. For the very best results with the WT1, run the treated water from the tap
into a glass or bottle or vessel. Then leave for 4 minutes prior to drinking.
2. Replace filters and check valves periodically.
3. For best results with the WP1 and WP1-750, run water through pipes to
clean pipes, prior to drinking. Regularly check microbe levels in tank,
ozone levels, and adjust disinfectant levels as required.
4. Water Purifiers are not suitable for water which is biologically unsafe.
5. Read Instruction Manual before use.
Ozone Pollution Technology,
Sydney Head Office, 212 Silverwater Road,
Silverwater NSW 2128, Australia.
Phone
Fax
Email
Web Site
For drying feedstock air, to maximise ozone
output and product life, for model WP1 and
WP1-750
Dryer Chamber
CD1
Simple device for indicating ozone in water
levels, using the DPD method. Comprises a
set of tablets. Fits in your shirt pocket.
"Ozone In Water" Tester
EW0
-
off-tastes
-
off-colours
-
salts and scale.
02-9748 7748
02-9748 7749
sales@ozonetec.com
http://www.ozonetec.com
Specifications subject to change
Advertisement
