Campbell Hausfeld Maxus PW2515 Operating Instructions And Parts List Manual page 10

Pressure Washer
Maintenance
Observe regular maintenance intervals to ensure maximum
performance and life from the pressure washer. Refer to the
schedule for recommended maintenance. If you operate the
pressure washer in dusty conditions, perform maintenance
checks more often.
ENGINE OIL CHANGING INSTRUCTIONS
Before tipping the engine or equipment to
CAUTION
!
drain oil, drain fuel from the fuel tank.
NOTE: Change oil while the engine is cool.
1. Disconnect the spark plug wire from the spark plug.
2. Locate and remove the engine oil drain plug (See
13).
3. Drain old oil.
4. Replace the drain plug and set the unit upright.
5. Refill the unit with new oil of a recommended type and
quantity. Fill the unit to the proper level shown on the dipstick.
PUMP OIL CHANGING INSTRUCTIONS
Changing or refilling the oil in the pump requires removal of
the pump from the engine and should not be required unless
oil has leaked out due to worn or damaged oil seals in the
pump. If oil has leaked out of the pump, bring the pressure
washer to a certified Campbell Hausfeld service center for
repair.
Maintenance Schedule
Maintenance Schedule
Daily • Check water inlet screen and
• Check engine oil levels. Fill as
• Check gasoline level. Fill as
• Change engine break-in oil.
After first 5 hours of
operation
Every 25 hours of • Change oil if operating under
operation
• Clean or replace paper air
Every 50 hours of • Change oil.
operation • Replace spark plug.
Each 100 hours of • Replace paper air cleaner
operation or every 3
• Change engine oil.
months
www.chpower.com
Action needed
filter.
necessary.
necessary.
Use SAE30 or 10W-30
detergent oil.
heavy load or high ambient
temperature.
cleaner cartridge. Tap gently
to remove dirt.
cartridge.
Figure
Figure 13 - Oil Drain Location
Technical and Consumer Information
Vertical Oriented Pressure Washers
Engine Oil Type
Engine Oil Capacity
Honda engines
Engine Fuel Capacity
Honda engines
Pump Oil Type
Wobble pumps
Pump Oil Capacity
Vertical wobble pumps
Pump Detergent Suction
Water to detergent ratio
Water Supply Requirements
Minimum inlet pressure
Maximum inlet pressure
Maximum inlet temperature
Minimum inlet flow rate
Inlet garden hose size
Maximum inlet garden
hose length
10
SAE 10W-30
SAE 30W (Above 60˚ F)
18.5 fl. oz.
0.29 gal
SAE20W or SAE30W
non-detergent oil
4.0 fl. oz.
8 to 1 (12% detergent)
20 psi
100 psi
100˚ F
5 gpm
5/8" I.D.
50 ft