Table of Contents
Advertisement
SECTION 4:
CONNECTION
CAUTION:
The 1lb LP cylinder does not have a shut off valve. As soon
as the LP cylinder is connected to the gas regulator the gas
will flow. Ensure the appliance gas valve is 'OFF' before
connecting the LP cylinder!
1. Ensure the Tonga Torch gas
valve is "off".
2. Connect the 1lb LP (Propane)
cylinder.
a) Engage threaded coupling
connection to gas regulator.
b) Turn LP cylinder clock-wise
to connect.
c) Do not use tools. Hand
tighten only.
CAUTION:
When making the connection, hold the regulator in a
straight line with the cylinder valve, so as not to cross thread
the connection.
3. Unwind any twists or kinks
in the gas hose. Ensure the
hose is straight.
4. Slide the 1lb LP gas cylinder
into cylinder holder.
SECTION 5:
DO NOT USE OR PERMIT SOURCES OF IGNITION IN THE
AREA WHILE DOING THE LEAK TEST.
THIS INCLUDES SMOKING.
IMPORTANT: Leak testing should be done once per year or
whenever the LP gas cylinder or any other gas system part is
taken apart, serviced or replaced, whichever is more frequent.
1. Be sure the appliance valve is "off".
2. Ensure all gas system coupling joints are tight and properly
OFF
3. Prepare a leak testing solution of half liquid detergent and
4. Apply the solution to the LP gas delivery system at points as
Connect 1lb
LP Cylinder
LEAK TEST
WARNING:
attached.
half water.
shown in illustration:
• LP Cylinder Valve Coupling
• Gas Hose Regulator
• Mid-point gas connection
a) If parts of the fitting begin to produce bubbles, spray
liquid, or if you smell liquid propane gas, immediately
close the valve on the tank. Wait 5 minutes for any gas
to dissipate. After waiting for
5 minutes, the leak(s) must be
stopped by tightening the loose
joints, if possible, or by replacing
the faulty parts(s) with the part(s)
recommended by the appliance
manufacturer.
b) If no adverse reaction is observed
and the connections all seem fine
then move to the ignition sequence.
Valve Coupling
1-888-514-1663 |
WWW.OUTLANDLIVING.COM
Mid-
point gas
connection
Gas Hose
Regulator
LP Cylinder
En-6
Advertisement
Table of Contents
