Audi RS 3 LMS DSG User Manual page 45

2. Disassemble filter assembly by removing the four small screws at the bottom (intake side) of the
outer-body and pull out the filter element.
3. Tap the filter gently to dislodge the larger debris that have collected, do not use compressed air as
you could damage the paper elements.
4. Apply detergent to the filter. Squirt the fluid down the elements from the outside while holding the
filter at an angle over a bucket. Don't re-distribute the detergent that's collected in the bucket
through the filter again.
Once you covered the whole filter leave the filter to stand for ten minutes to allow the detergent to
break down the old oil in the filter.
5. Using another bucket rinse filter with cold water until no more debris collects appear at the bottom
of the bucket.
6. Pat your filter dry and place somewhere with good air flow and allow the filter to dry naturally. Do
not use compressed air or place in a very warm area as this could damage the filter element.
7. Once you have applied two coats of oil along both sides of the filter pleats, hold the filter and ensure
the filter is an even red colour.
8. Once it is evenly coated, leave it stand for 30 minutes. Carefully pat the excess off the filter with
paper towels.
9. Rebuild your filter taking care that the screw holes match up and fit it back in the car.
Parts subject to frequent service:
Air filter
Substitution
Cleaning
Notes:

The air filter type and measurements are identified on the Technical Form. It is not allowed any
modification or change.

A clean and properly oiled air filter is basic to ensure engine's life. It is strongly recommended to
follow the cleaning procedure as well as the replacement frequency.

After rain conditions use, it is strongly recommended the cleaning or replacement.
DSG gearbox
Control routine before start:

Check that there is no oil leakage.

Operating range 70°C to 135°C. Do not load the engine until the temperature is above 70°C.
Routine maintenance:
Torque Remarks
By hand Be careful tightening the small bolts over plastic
Clean the cotton air filter following the procedure
shown above.
Do not use compressed air or high-pressure air to
clean.
Use only recommended oil for cotton filters.
45