Advertisement
Quick Links
O
P
E
R
OBAE, OBAEXU, ON BOARD Battery Chargers
INTRODUCTION:
The OBAE line of chargers are designed for the permanent installation on battery powered
vehicles and equipment. They are an electronically controlled two stage charger. The first stage
brings the batteries to the gassing threshold where a three hour timer starts. The batteries are then
gassed for three hours. After three hours, the charger drops into a low float mode where the
charge is maintained in the batteries indefinitely. Finish current is below 1 amp.
SOME APPLICATIONS:
Golf cars, pallet trucks, personnel carriers, scissor lifts, floor scrubbers, stand-by power
applications, robotics.
IMPORTANT: DO NOT USE THIS CHARGER UNTIL YOU HAVE READ ALL THE
INSTRUCTIONS.
INITIAL INSTALLATION:
Before making AC connections, refer to the AC requirements labeled on the charger. If your
charger is not equipped with an AC plug (a 220 volt model) have a qualified electrician install
one.
CAUTION: To reduce the risk of fire, use this charger only on circuits provided with
!
a maximum of 20 ampere branch circuit protection (circuit breaker or fuse),
In accordance with the National Electric Code, ANSI/NFPA 70, and all local
codes and ordinances.
GROUNDING INSTRUCTIONS:
This battery charger must be grounded to reduce the risk of electric shock. If the charger is
equipped with a grounding type plug, it must be plugged into a nominal 115 volt, 60 Hertz circuit.
If the charger is supplied with no plug, have a qualified service person install one.
WARNING: Improper connection of the equipment grounding conductor can result in a
!
risk of an electric shock. DO NOT USE THIS CHARGER ON A TWO
POLE UNGROUNDED OUTLET OR ATTEMPT TO BREAK OFF THE
GROUND PRONG FOR USE ON A RECEPTACLE OR EXTENSION
CORD NOT HAVING A GROUND.
The use of an extension cord with this charger should be avoided. The use of an improper
extension cord result in a risk of a fire or electric shock. If an extension cord must be used, make
sure it is in good condition. Use a three conductor cord no smaller than 14 AWG. And keep it as
short as possible. Locate all cords so that they will not be stepped on, tripped over, or otherwise
subjected to damage or stress.
Do not operate this charger if it shows any signs of physical damage.
Quick Charge Corp. 1032 S.W. 22nd St. Oklahoma City, OK. 73109 800 658-2841
C O R P O R A T I O N
A
T
I
N
G
I
N
S
T
R
U
C
1
T
I
O
N
S
Advertisement
Related Manuals for Quick Charge OBAE
Summary of Contents for Quick Charge OBAE
- Page 1 OBAE, OBAEXU, ON BOARD Battery Chargers INTRODUCTION: The OBAE line of chargers are designed for the permanent installation on battery powered vehicles and equipment. They are an electronically controlled two stage charger. The first stage brings the batteries to the gassing threshold where a three hour timer starts. The batteries are then gassed for three hours.
- Page 2 PROPER CARE AND USE OF BATTERIES: CAUTION: Always wear protective eye shields and clothing when working with batteries. Batteries contain acids which can cause bodily harm. Do not put wrenches or other metal objects across the battery terminal or battery top. Arcing or explosion of the battery can result.
-
Page 3: Normal Operation
3). The LED on the charger will light, indicating charge current is flowing. 4). The OBAE chargers are equipped with a electronic timer. At the battery gassing threshold, (2.3 volts per cell) the timer will activate and run for three hours. During this period, the batteries are in a gassing or equalizing mode. - Page 4 Oklahoma City, OK. 73109 Quick Charge, will at it s option, repair or replace the charger or component in question. The repaired item will then be returned, freight prepaid by Quick Charge. This warranty is void if the charger or component have been altered, changed, or repaired by anyone not authorized by Quick Charge, or if the charger or component, have been subjected to misuse, negligence, or harsh environmental conditions.
- Page 5 This document was created with Win2PDF available at http://www.daneprairie.com. The unregistered version of Win2PDF is for evaluation or non-commercial use only.