Breaking In Engine; Procedure For 4-Stroke Models; Preoperation Checks; Fuel - Yamaha F4A Owner's Manual

board (if packed). For details, consult
your Yamaha dealer.
EWM00650
WARNING
Avoid using bolts, nuts or washers other
than those contained in the engine pack-
aging. If used, they must be of at least the
same quality of material and strength and
must be tightened securely. After tighten-
ing, test run the engine and check their
tightness.
1
1. Bolts
EMU30173

Breaking in engine

Your new engine requires a period of break-
in to allow mating surfaces of moving parts to
wear in evenly. Correct break-in will help en-
sure proper performance and longer engine
life.
ECM00800
CAUTION:
Failure to follow the break-in procedure
could result in reduced engine life or
even severe engine damage.
EMU27081

Procedure for 4-stroke models

Run the engine under load (in gear with a
propeller installed) for 10 hours as follows.
1. First hour:
Run the engine at 2000 r/min or at ap-
proximately half throttle.
2. Second hour:
Run the engine at 3000 r/min or at ap-
proximately three-quarter throttle.
3. Remaining eight hours:
Run the engine at any speed. However,
avoid operating at full throttle for more
than 5 minutes at a time.
4. After the first 10 hours:
Operate the engine normally.
EMU27102
EWM00080
WARNING
If any item in the preoperation check is
not working properly, have it inspected
and repaired before operating the out-
board motor. Otherwise an accident
could occur.
ZMU02637
ECM00120
CAUTION:
Do not start the engine out of water. Over-
heating and serious engine damage can
occur.
EMU27111

Fuel

Check to be sure you have plenty of fuel
G
for your trip.
Make sure there are no fuel leaks or gaso-
G
line fumes.
Check fuel line connections to be sure they
G
are tight (if equipped Yamaha fuel tank or
boat tank).
Be sure the fuel tank is positioned on a se-
G
cure, flat surface, and that the fuel line is
not twisted or flattened, or likely to contact
sharp objects (if equipped Yamaha fuel
tank or boat tank).
Operation

Preoperation checks

16