Table of Contents
Advertisement
Model No.:
36306 – 15 gal Extractor
36306CETL (Canada)
CAUTION: Read the instruction manual
before using the appliance.
KLEENRITE
1122 MAPLE STREET
MADERA CA 93637 U.S.A.
FAX: 1-559-673-5725
CUSTOMER SERVICE: 1-800-241-4865
36306
MegaXL Water Extractor and Pump
Operator and Parts Manual
MNL36306 & MNL36306CETL
®
Rev. 01 (8-16)
Advertisement
Table of Contents
Summary of Contents for KleenRite MegaXL 36306
- Page 1 Operator and Parts Manual Model No.: 36306 – 15 gal Extractor 36306CETL (Canada) CAUTION: Read the instruction manual before using the appliance. KLEENRITE 1122 MAPLE STREET MADERA CA 93637 U.S.A. MNL36306 & MNL36306CETL FAX: 1-559-673-5725 Rev. 01 (8-16) CUSTOMER SERVICE: 1-800-241-4865...
- Page 2 IMPORTANT SAFETY INSTRUCTIONS When using an electrical appliance, basic precautions must always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE. This machine is for commercial use. To reduce the risk of fire, electric shock, or injury: WARNING: Do not operate machine unless trained and authorized.
- Page 3 CONSIGNES DE SÉCURITÉ IMPORTANTES L’utilisation d’un appareil électrique demande certaines précautions: LIRE TOUTES LES INSTRUCTIONS AVANT D'UTILISER CETTE MACHINE. Cette machine est pour un usage commercial. Pour réduire le risque d'incendie, d'électrocution AVERTISSIMENT: ou de blessures : N'utilisez pas la machine à moins formés et habilités. Se connecter à...
-
Page 4: Table Of Contents
© Kleenrite Printed in U.S.A. distributor or directly from Kleenrite. Kleenrite is a registered United States trademark This machine will provide excellent service. However, the best results will be obtained at minimum costs if: The machine is operated with reasonable care. -
Page 5: Safety Precautions
OPERATION 3. When using machine: SAFETY PRECAUTIONS – Do not run machine over cord. – Do not pull machine by plug or cord. – This machine is intended for commercial use. It is Do not pull cord around sharp edges or designed to extract water from carpet and hard corners. - Page 6 OPERATION grounding connector and grounding plug. The GROUNDING INSTRUCTIONS plug must be plugged into a GFCI outlet that is Machine must be grounded. If it should properly installed in accordance with all local malfunction or breakdown, grounding provides a codes and ordinances. Do not remove ground pin; path of least resistance for electrical current to if missing, replace plug before use.
-
Page 7: Machine Components
OPERATION MACHINE COMPONENTS Handle 1. Vacuum Inlet Tank Latch 2. Power Cords Separate Circuit Indicator Light 3. Discharge Connector 10. Discharge Pump Switch 4. Manual Drain 5. 10” Wheels 11. Vacuum #1 Switch 12. Vacuum #2 Switch 6. Vacuum Lid MACHINE SETUP 1. -
Page 8: Machine Operation
OPERATION ATTENTION: Excessive foam buildup will not activate the float shut-off screen. ATTENTION: Discharge pump will not pump foam. Use a defoamer. USING THE MEGAXL WITH WEIGHTED EXTRACTION TOOL Fig. 3 Fig. 4 1. If using a weighted extraction tool with the 4. -
Page 9: Machine Maintenance
OPERATION MACHINE MAINTENANCE To keep machine in good working condition simple follow machine’s daily, weekly, and monthly maintenance procedures. For Safety: When servicing machine, unplug cord from wall outlet. DAILY MAINTENANCE (Every 4 hours of Operation Fig. 12 1. Empty and rinse out recovery tank thoroughly. 8. -
Page 10: Storing Machine
OPERATION RECOMMENDED STOCK ITEMS MONTHLY MAINTENANCE (Every 80 hours of operation 1. Lubricate wheels with water resistant oil. Refer to Parts List section for recommended stock items. Stock items are clearly identified with a bullet 2. Inspect machine for water leaks and loose preceding the part number. -
Page 11: Specifications
OPERATION SPECIFICATIONS Model 36306 & 36306CETL LENGTH 787 mm (31 in) WIDTH 470 mm (18.5 in) HEIGHT 991 mm (39 in) WEIGHT 54.9 Kg (121lbs) RECOVERY TANK CAPACITY 56.7 L (15 gal) DISCHARGE PUMP 120 V, 238 LPM (63 GPM), 5.1 A VACUUM MOTORS 2 @ 120 V, 12.5 A, 1500 W SEALED WATER LIFT... -
Page 12: Electrical Diagram
ELECTRICAL DIAGRAM 36306 & 36306CETL 120 V WIRING DIAGRAM SK-09.25B Canada Part # Description Qty. Part # Description Qty. C-03.02 CLAMP, HOSE 1/4 #4 K-21W SWITCH, SPST WATER RESIS K-13.2 LIGHT, GREEN ROUND SK-09.25B CORD, 25' 12/3 SJTW 20 AMP W/TERM K-16.75 RELAY, 120V EDGE DPDT 25AMP SK-84MEGAX/BASE HARNESS, MEGAX BASE VVP... -
Page 13: Parts List
PARTS LIST 36306 & 36306CETL GROUP ONE A 50’ extension pump out hose is available. Part #SE-10.7/50EXT Part # Description Part # Description B-26.7 10-32 X 1 1/2 PHXZINC C-95 VELCRO, ONE WRAP STRAP 1/2" X 12" B-40.91 3/8-16 X 1 1/2 HEX ZINC E-11.5/50 HOSE, 1 1/2"... - Page 14 PARTS LIST 36306 & 36306CETL BASE GROUP 36306 & 36306CETL(8-16)
- Page 15 PARTS LIST 36306 & 36306CETL BASE GROUP Part # Description Qty. Part # Description Qty. B-10 6-32 X 1/2 PHXSS C-51 MUFFLER, FOAM EDGE B-10 6-32 X 1/2 PHXSS C-59 PUSHNUT FASTNER, 1/2 CAP B-14 NUT 6-32 HEX SS G-37.5FOAM VALVE,VAC SHUT OFF DUAL 2 FOAM B-14 NUT 6-32 HEX SS...
- Page 16 PARTS LIST 36306 & 36306CETL TANK GROUP 36306 & 36306CETL(8-16)
- Page 17 PARTS LIST 36306& 36306CETL TANK GROUP Part # Description Qty. Part # Description Qty. B-11.2 6-32 X 3/4 FHXSS 100 DEG D-29.6A BODY SS,1/4-32THD INLINE FILTER B-12.5 6-32 X 1 1/4 PHXSS D-94.25 VALVE, CHECK 1-1/2 CLEAR PVC B-14.5 NUT 6-32 HEX SS NYLOK J-41MEGAXL/EXTRACT TANK, GRAY ROTO MEGA XL EXTRA B-16.2...
- Page 18 PARTS LIST 36306 & 36306CETL HANDLE GROUP Part # Description Part # Description B-09.1 6-32 X 3/8 PHXSS K-21W SWITCH, SPST WATER RESIS B-14.5 NUT 6-32 HEX SS NYLOK K-28.05 TIE, WIRE NYLON #10 SCREW B-21 10-32 X 5/16 PHXSS M-0792.13 PLATE,HANDLE SW COVR MEGA X B-23...
-
Page 19: Warranty Policy
Kleenrite can inspect the part that is suspected to be faulty or have a chance to repair it, Kleenrite will ship the requested part on a COD basis (part plus freight) or if credit has been established prior to the request the part will be shipped on an Open Account basis (part plus freight). - Page 20 Kleenrite’s control. In no event shall Kleenrite be liable for loss of use, incidental or consequential damages or any damages to persons or property.
- Page 21 Kleenrite’s control. In no event shall Kleenrite be liable for loss of use, incidental or consequential damages or any damages to persons or property.