The Generator; Specifications - Honeywell 10 kW Owner's Manual

For generators 12 kW and greater, the Emission Control System
code is EM (Engine Modification) and consists of the following
components:
• Air Induction System
~ Intake Pipe / Manifold
~ Air Cleaner
• Fuel Metering System
~ Carburetor / Mixer Assembly
~ Fuel Regulator
• Ignition System
~ Spark Plug
~ Ignition Module
• Exhaust System
~ Exhaust Manifold
~ Muffler
1.5

THE GENERATOR

Figure 1.1 – 10kW, V-twin, GT-530 Engine
(door removed)
Oil
Dipstick
Exhaust
Enclosure
Composite Base
Figure 1.2 – 12, 15 and 20kW, V-twin,
GT-990/GT-999 Engine (door removed)
Oil
Dipstick
Exhaust
Enclosure
Composite Base
Data Label Control
(see sample) Panel
Oil Filter Battery Compartment
Data Label
(see sample)
Control
Panel
Air Filter
Oil Filter Battery Compartment
1.6
1.6.1
Model
Rated Voltage
Rated Maximum Load Current
(Amps) at 240 Volts (LP)*
Main Circuit Breaker
Phase
Number of Rotor Poles
Rated AC Frequency
Battery Requirement
Weight (unit only in lbs.)
Enclosure
Normal Operating Range
These generators are rated in accordance with UL2200, Safety Standard for Stationary
Engine Generator Assemblies; and CSA-C22.2 No. 100-04 Standard for Motors and
Generators.
* Natural Gas ratings will depend on specific fuel Btu content. Typical derates are
between 10-20% off the LP gas rating.
** Circuits to be moved must be protected by same size breaker. For example, a 15 amp
Circuit
circuit in the main panel must be a 15 amp circuit in the transfer switch.
Breaker
Air
1.6.2
Filter
Fuel Inlet
Model
(back)
Type of Engine
Fuel
Number of Cylinders
Regulator
Rated Horsepower @
3,600 rpm*
Displacement
Cylinder Block
Valve Arrangement
Ignition System
Recommended Spark Plug
Spark Plug Gap
Compression Ratio
Circuit
Starter
Breakers
Oil Capacity Including Filter
Recommended Oil Filter
Recommended Air Filter
Fuel Inlet
(back)
Operating RPM
Fuel
* Engine power is subject to and limited by such factors as fuel Btu content, ambient
Regulator
temperature and altitude. Engine power decreases about 3.5 percent for each 1,000 feet
above sea level; and also will decrease about 1 percent for each 6 C (10 F) above 16 C
(60 F) ambient temperature.
General Information

SPECIFICATIONS

GENERATOR
10 kW
41.6
45 Amp
Part No. 0H3421S, Group 26R, 12 Volts and 525 CCA
353
Aluminum
This unit is tested in accordance to UL 2200 standards
with an operating temperature of 20 °F (-29 °C) to 122
°F. (50 °C). For areas where temperatures fall below 32
°F (0 °C), a cold weather kit is highly recommended.
When operated above 77º F (25º C) there may be a
decrease in engine power. (Please reference the engine
specifications section).
ENGINE
10 kW 12 kW
GT-530 GT-990
18
530cc 992cc
Aluminum w/Cast Iron Sleeve
Solid-state w/Magneto
Part No. Part No.
0E9368 0E7585A
0.76 mm 1.02 mm
(0.030 inch) (0.040 inch)
9.5:1 9.5:1
Approx. 1.7 Approx. 1.9
Qts
Part # Part #
0E9581 0C8127
12 kW 15 kW 20 kW
240
50.0 62.5 83.3
50 Amp 65 Amp 100 Amp
1
2
60 Hz
Minimum
439 421 450
Steel Aluminum
15 kW 20 kW
GT-990 GT-999
2
32 32 36
992cc 999cc
Overhead Valves
Part No. Part No.
0E7585A 0G0767A
1.02 mm 0.76 mm
(0.040 inch) (0.030 inch)
9.5:1 9.5:1
12 VDC
Approx. 1.9 Approx. 1.9
Qts Qts Qts
Part # 070185F
Part # Part #
0C8127 0G5894
3,600
5