Related Manuals for TRADEair MCFRC241
Summary of Contents for TRADEair MCFRC241
- Page 1 -------------------------------------------------------------------------------------------------------------- Direct Drive Oil-free Silent Air Compressor MCFRC241,242,243...
-
Page 2: Warranty
This warranty does not include items considered as consumables. Statutory Rights This warranty is in addition to and in no way affects your statutory rights. SPECIFICA TIONS Part No. MCFRC241 MCFRC242 MCFRC243 Voltage 230V/50HZ 230V/50HZ... -
Page 3: General Safety Instructions
-------------------------------------------------------------------------------------------------------------- GENERAL SAFETY INSTRUCTIONS Before attempting to operate this compressor the following basic safety precautions should always be taken to reduce the risk of fire, electric shock and personal injury. It is important to read the instruction manual to understand the application, limitations and potential hazards associated with any tool. - Page 4 -------------------------------------------------------------------------------------------------------------- hand and leaves both hands free to control the air tool. Do Not Over-reach Do not over-reach, keep proper footing and maintain your balance at all times. Maintain Tools with Care Keep cutting tools sharp and clean for better and safer performance. Follow the instructions for lubricating and changing accessories.
-
Page 5: General View And Main Components
-------------------------------------------------------------------------------------------------------------- authorized service facility. Check Damaged Parts Before using the compressor it should be carefully checked to determine that it will operate properly and perform its intended function. Check for the correct alignment of moving parts ensuring they do not bind. Check for broken or missing parts and have them replaced or repaired at an authorized service centre. - Page 6 -------------------------------------------------------------------------------------------------------------- 2. ) Flexible delivery pipe 3) Pressure switch 4) Pressure Regulator 5) 5 in 1 quick coupler 6) Regulated pressure gauge 7) Tank pressure gauge 8) Drain cock 9) Wheel 10) Air Tank 11) Anti-vibration foot 12) Non-return valve 13) Solenoid valve 14) Air filter 13 13...
-
Page 7: Initial Start-Up
-------------------------------------------------------------------------------------------------------------- Wheels and axle set Rubber foot Air Filter • Fit the wheels to the unit using the axle kit provided and insert the rubber stopper into the spigot on the bottom of the tank. • Fit the air filter to cylinder head of the compressor. INITIAL STARTUP •... - Page 8 -------------------------------------------------------------------------------------------------------------- turned off. The pressure will then decrease as the air is used until the set minimum is reached after which the pressure switch turns the motor on again. The operator of the compressor should be well aware that during use of the compressor the motor will cycle (start and stop) under the influence of the rising or falling pressure in the tank and the motor will start without any warning.
- Page 9 -------------------------------------------------------------------------------------------------------------- MAINTENANCE Warning: Before maintenance operation, stop the air compressor, disconnect the unit from the mains supply and discharge all air in the air tank. Daily 1. Drain the condensation from the air receiver. 2. Check for air leaks. Weekly 1.
-
Page 10: Troubles And Remedies
-------------------------------------------------------------------------------------------------------------- TROUBLES AND REMEDIES Trouble Possible causes Remedies ⑴ Fault in line, or voltage insufficient ⑴ Check the line ⑵ Power wire too thin or too long ⑵ Replace the wire ⑶ Fault in pressure switch ⑶ Repair or replace ⑷... - Page 11 -------------------------------------------------------------------------------------------------------------- EXPLOADED VIEW...
- Page 12 -------------------------------------------------------------------------------------------------------------- PART LIST FOR OIL-FREE & SILENT AIR COMPRESSOR NAME UNIT QTY NAME UNIT QTY CYLINDER BOLT BOT FOR OUTLET VALVE PLAIN CUSHION O-RING FOR ALUMINUM TUBE CYLINDER HEAD ALUMINUM TUBE AIR FLITER CONNECTOR SEAL PACKING COLLAR ANTI-VIBRATION FOOT AIR ADMISSION CLAMP Nut M8 VALVE PIECE SCREW...
- Page 13 --------------------------------------------------------------------------------------------------------------...
Need help?
Do you have a question about the MCFRC241 and is the answer not in the manual?
Questions and answers