Page 1
Premier M10000 Passenger Set OPERATOR’S MANUAL Compatibility This engine will operate on any traditional O-72 Gauge track system, including ® ™ M.T.H.’s RealTrax or ScaleTrax traditional tubular track. It is also compatible with most standard AC transformers. (See page 21 for a complete list of compatible transformers and wiring instructions.) PLEASE READ BEFORE USE AND SAVE...
(see Fig. 3). Failure either to add fluid to the unit or to turn it off may damage the smoke unit heating element and/or wicking material. Premier M10000 Locomotive Set...
Simply depress the vestibule and pull the cars apart. Don’t forget to unplug the cable. At this point, you are ready to put your engine on the track and begin running it. Figure 4: Connecting The Cars Premier M10000 Locomotive Set...
Neutral cycle neutral-forward-neutral-reverse with Reverse Forward each press and release of the direction button. The engine is programmed to Neutral restart in neutral each time the track voltage is turned off for 25 seconds or more. Premier M10000 Locomotive Set...
Page 6
To adjust the volume of all sounds made by this engine, turn the master volume control knob located next to the rear truck of the power unit clockwise to increase the volume and counter-clockwise to decrease the volume. Proto-Sound 2.0 Volume Adjustment Knob Figure 5: Proto-Sound Manual Volume Adjustment Premier M10000 Locomotive Set...
Fire the Front Coupler 1 Bell, 4 Horns Speed Control On/Off 1 Horn, 2 Bells (from Neutral only) Lock into a Direction 1 Horn, 3 Bells Reset to Factory Defaults 1 Horn, 5 Bells (from Neutral only) Premier M10000 Locomotive Set...
Once the bell turns off, the operator Operator Direction Direction Direction Direction Horn Horn Bell Controls When Bell Turns Off Sound System Cued to Play Passenger Sequence Sequence Sequence Sequence Station Announcements (PSA) Premier M10000 Locomotive Set...
Page 9
PSA can be triggered from Neutral. It will operate the same as if triggered while in motion except that, at the conclusion of the PSA, the engine will depart in the next direction of travel, as opposed to the direction it was traveling before entering Neutral. Premier M10000 Locomotive Set...
Each time you shut down the engine completely, it will automatically turn speed control on. Speed Control Two Horn Blasts Place Bell Bell Horn Engine into (indicates change is made) Neutral Repeat to Return to Normal Condition Premier M10000 Locomotive Set...
• Cab Chatter plays at random intervals when the engine idles in neutral. • Engine Start-up and Shut-down sounds play when the engine is initially powered on or is powered off for five seconds or more. Premier M10000 Locomotive Set...
1. To access the gear box, remove the cab from the chassis by unscrewing the chassis screws as seen in Figure 6 & 7 and lifting the cab from the chassis. Body Mount Screws Motor Mounting Screw Figure 7: Removing the body from the observation car Premier M10000 Locomotive Set...
Thereafter, keep an eye on the track and clean it when it gets dirty to ensure good electrical contact and to lengthen the life of the tires. Premier M10000 Locomotive Set...
5. Reassemble in the reverse order. One set of replacement tires is packaged with your model. Additional sets are available directly from the M.T.H. Parts Department (order online: www.mth-railking.com, e-mail: parts@mth-railking.com; mail: 7020 Columbia Gateway Drive, Columbia MD 21046-1532, FAX: 410-381-6122). Premier M10000 Locomotive Set...
15 minutes. Recharge: If the sounds are improved at the end of the 15-minute test charge, the battery charge has run down and can be recharged. There are a number of ways you can do this: Premier M10000 Locomotive Set...
The smoke unit is essentially a small heating element and wick that soaks up and then heats a mineral oil-based fluid that emits a harmless smoke. The smoke is then Figure 12: Filling The Smoke Unit Premier M10000 Locomotive Set...
Page 17
Figure 13: Inspecting The Smoke Unit Wick and hard, it should be replaced. Replacement parts and wick replacement instructions are available directly from the M.T.H. Parts Department:(order online: www.mth-railking.com, e-mail: parts@mth-railking.com; mail: 7020 Columbia Gateway Drive, Columbia MD 21046-1532, FAX: 410-381-6122). Premier M10000 Locomotive Set...
When I try to fire the coupler, PSA whistle button presses. starts. Try lubricating the coupler knuckle The Proto-Coupler won’t let the engine with a dry graphite lubricant. Do NOT uncouple on the fly. use oil. Premier M10000 Locomotive Set...
Page 19
Because there are a limited number of sound clips available in each PSA sequence, it is probable that some of these sound clips will be repeated from time to time. Premier M10000 Locomotive Set...
Page 20
PSA cycle. Wait of PSA after fourth press of the at least 30 seconds in each PSA direction button. sound clip before pressing the direction button. Premier M10000 Locomotive Set...
Standard Lionel SW Unknown 130-Watt Standard Lionel TW 8-18v 175-Watt Standard Lionel ZW A,B,C or D 8-20v 275-Watt Standard Lionel Post-War A,B,C or D Common 0-20v 135/190 Watt Electronic Celebration Series ZW * Conventional Mode Only Premier M10000 Locomotive Set...
Direction Control Set Up-User can set initial individual start-up direction (start in forward or reverse) for double-heading operations • Locomotive Consist Set-up-User can determine locomotive values for consist make-ups, allowing multiple locomotives belonging to a consist to operate together Premier M10000 Locomotive Set...
Service & Warranty Information How to Get Service Under the Terms of the Limited One-Year Warranty For warranty repair, follow the instructions below to obtain warranty service. First, e-mail, write, call or fax an Authorized M.T.H. Service Center in your area or M.T.H. Electric Trains to obtain Repair Authorization.
Page 24
Y. O. R. K. TRAINS 978-532-1615 860-646-0610 MUNSTER www.netrains .com bobbell@nehobby.com 219-838-9999 yorktrains@aol.com MICHIGAN DELAWARE BRASSEUR ELECTRIC TRAINS INC. K R R B MODEL TRAINS INC. SAMUELSON'S TRAIN SHOP SAGINAW NEWARK VALPARAISO 517-793-4753 302-292-2779 219-462-2708 bob@traindoctor.com info@krrb.com www.traindoctor.com www.krrb.com Premier M10000 Locomotive Set...