Related Manuals for BOH Enviromental FPU Series
Summary of Contents for BOH Enviromental FPU Series
- Page 1 ® SYSTEMS OPERATION MANUAL (INCLUDING REPAIR PARTS & SPECIAL TOOL LIST) BOH CONTAINERIZED LATRINES BOH FPU Field Pack-up Units CHAPTER 2 OPERATOR INSTRUCTIONS BOH-PM-01-2 © 2016 BOH Environmental LLC Chapter 2 Rev. 1.03...
- Page 2 This page was intentionally left blank BOH-PM-01-2 Chapter 2 Rev. 1.03...
-
Page 3: Operator Instructions
0005 00 OPERATOR INSTRUCTIONS ® SYSTEMS OPERATION MANUAL (INCLUDING REPAIR PARTS & SPECIAL TOOL LIST) BOH CONTAINERIZED LATRINES BOH FPU Field Pack-up Units PREPARATION FOR MOVEMENT INITIAL SETUP: Unloading Maintenance Level Personnel Required Operator/Crew Two (plus one supervisor) SETUP Site Requirements WARNING The Latrine must be operated on level ground. - Page 4 0005 00 The following ground guide safety instructions apply: two ground guides directing, always in the line of sight of the MHE operator. Tare weight is 9,400 lb. GROUND GUIDE GROUND GUIDE DIRECT LINE OF SIGHT DIRECT LINE OF SIGHT WARNING Overhead power lines and obstructions can cause serious injury or damage to property.
- Page 5 0005 00 WARNING Ensure all circuit breakers and the power source are switched off before making electrical connections. Ensure the proper 120 VAC electrical cable connectors are installed by a certified electrician (Army MOS 21R). Setup Procedures 1. Set latrine unit on a level surface. Unit must be level for plumbing discharge to operate properly.
- Page 6 0005 00 Shut Off Valves 1. City Water shutoff valve and check valve (1) 2. Left and right sink shut off valve (2) 3. Urinal shut off valve (3) 4. Toilet shut off valve (4) Closed Closed Closed Closed BOH-PM-01-2 Chapter 2 Rev.
- Page 7 0005 00 Preparation for Shipment WARNING Ensure that there are no personnel in the latrine prior to any movement. The containerized latrine is not ISO-certified or CSC Safety-Approved. When transporting or storing the latrine, never stack the containerized latrine. The structure is not designed to support additional containers.
- Page 8 0005 00 WARNING The containerized latrine is not ISO-certified or CSC Safety-Approved. When transporting or storing, never stack the containerized latrine units. The container structure is not designed to support additional containers. Failure to comply could damage to the container and equipment or death or injury. END OF WORK PACKAGE BOH-PM-01-2 Chapter 2 Rev.
- Page 9 0006 00 OPERATOR INSTRUCTIONS ® SYSTEMS OPERATION MANUAL (INCLUDING REPAIR PARTS & SPECIAL TOOL LIST) BOH CONTAINERIZED LATRINES BOH FPU Field Pack-up Units Operation of the Containerized Latrine INITIAL SETUP: Reference Initial set-up None Maintenance Level Personnel Required Operator/Crew One (plus one supervisor) Latrine Operation NOTE The ground rod and strap is stored next to the toilet and the city water...
- Page 10 0006 00 Containerized Latrine Exterior Water and Electrical hook-ups OPEN 1. Ensure electrical ground has been established and is complete with ground lug and rod (5) that is stored in the first compartment (5) (See page 0006 00-1). 2. Ensure the electrical supply is still connected and operational (1). 3.
- Page 11 0006 00 CAUTION The Containerized Latrine must be placed on a level surface of a platform, pillars or ground surface to operate properly and prevent waste water backups. Black Water is discharged by gravity. Electrical and Water Connection End Black Water Cleanout End BOH-PM-01-2 Chapter 2 Rev.
- Page 12 0006 00 Containerized Latrine Electrical Layout BOH-PM-01-2 Chapter 2 Rev. 1.03 0006 00-4...
- Page 13 0006 00 Containerized Latrine Electrical Components Locations WARNING Only a certified electrician should be permitted to remove and repair the electrical components of the system. • Two Tube Fluorescent Light Fixtures (1) • GFCI Protected Interior Electrical Outlets (2) • Weather Proof Exterior Receptacles (3) WARNING Fluorescent tubes may contain hazardous material.
- Page 14 0006 00 Air Ventilation System • Air Exhaust Vents (1) • Fresh Air Intake (2) • Interior Fan (3) • Interior Exhaust Fan switch (4) END OF WORK PACKAGE BOH-PM-01-2 Chapter 2 Rev. 1.03 0006 00-6...
-
Page 15: Operation Under Unusual Conditions
0007 00 OPERATOR INSTRUCTIONS ® SYSTEMS OPERATION MANUAL (INCLUDING REPAIR PARTS & SPECIAL TOOL LIST) BOH CONTAINERIZED LATRINES BOH FPU Field Pack-up Units OPERATION UNDER UNUSUAL CONDITIONS This work package provides instructions for the operation of the FPU modules under unusual conditions. - Page 16 This page was intentionally left blank BOH-PM-01-2 Chapter 2 Rev. 1.03...
Need help?
Do you have a question about the FPU Series and is the answer not in the manual?
Questions and answers