Subscribe to Our Youtube Channel
Related Manuals for Curtec Kiuso
Summary of Contents for Curtec Kiuso
- Page 2 Washing The washing instructions below apply to the cleaning of all CurTec packaging products that are made of polyethylene and polypropylene: Best results will be achieved with a washing installation that is equipped with spray nozzles or a so-called Ultra-Sonic installation.
- Page 3 The UN marking on a Kiuso is only valid if the following closing instruction is applied. Kiuso has a unique closing concept: press down the lid to close, tear off the sealing strip and turn to open. After the sealing strips have been removed, the container can be re-closed by screwing on the lid.
- Page 4 5. The container is properly closed when the tamper evident tear- off strip touches the container rim. Note: Kiuso is also suitable for full automatic closure. CurTec can advise on the purchase of both semi and full automatic closure solutions. Contact us for more information.
- Page 5 The UN marking on Kiuso is only valid if the following closing instruction is applied. Kiuso has a unique closing concept: press down the lid to close, tear off the sealing strip and turn to open. After the sealing strips have been removed, the container can be re-closed by screwing on the lid.
- Page 6 4. To re-close, put the lid on the container as shown and turn it at least 180° until the lid catches on the container rim. Attention! A leak tight closure can no longer be obtained after the sealing strips have been removed Kiuso manual 2020-7...
- Page 7 The packaging can be opened according to instruction 2. Use the rim and the bottom to tilt the container and pour the contents. Freezing Kiuso is made of plastic which is resistant to a minimum temperature of -18°C. As of -5°C, shock load on the containers should be avoided.
- Page 8 Since CurTec has no influence on the use of its packaging by end users, they advise to test each transport mode. It remains the responsibility of end users to verify whether a package and content comply with relevant transport regulations.
- Page 9 Attention! The weights mentioned in the table have been established after simulation and can only serve as indications. CurTec recommends users to perform tests at all times. The table allows you to calculate the number of containers that can be stacked: Reduce the stacking weight mentioned with the relevant share of the total weight of intermediate layers and divide by the weight of the container with content.
- Page 10 Example How many 20 liter Kiuso's (art. no. 4620) with a content weighing 20 kg can be stacked on a pallet at 15°C during 6 months? A layer contains 8 containers and the total weight of intermediate layers is 16 kg.
- Page 11 Attention! The weights mentioned in the table have been established after simulation and can only serve as indications. CurTec recommends users to perform tests at all times. The table allows you to calculate the number of containers that can be stacked: Reduce the stacking weight mentioned with the...
- Page 12 Example How many 20 liter Kiuso's (art.no. 4620) with a content weighing 20 kg can be transported by road at 30°C during 3 weeks? A layer contains 8 containers and the total weight of intermediate layers is 16 kg. The relevant share of the total weight of intermediate layers is 16/8 = 2kg, so (173-2/2)/20 = 4.275.
- Page 13 A pallet should have an almost closed surface fitted with planks that are no more than 5 cm/ 2 inches apart. CurTec advises not to exceed a total stacking height of 2 meters. In case a pallet is placed on top of another pallet, an intermediate layer is required to enable an equal spread of the pressure.
- Page 14 Pallet schemes CurTec advises you to respect the following quantities per layer: 1200 x 800 mm 1200 x 1000 mm 48 x 40 inches Kiuso manual 2020-7...
- Page 15 CurTec manufactures packaging material for a wide range of purposes. This declaration is restricted to the packaging material as it leaves the production facility. CurTec has neither control over final end use of the product nor over processing conditions. It is...
Need help?
Do you have a question about the Kiuso and is the answer not in the manual?
Questions and answers