Subscribe to Our Youtube Channel
Related Manuals for pilotair SCR Series
Summary of Contents for pilotair SCR Series
- Page 1 Pilot SCR7.5 Scroll Air Compressor SCR Series Scroll Compressors Instructions and Parts List P a g e SCR SERIES Instructions and Parts List...
- Page 2 Should you experience any trouble, or for further information, please do not hesitate to contact Best Regards, PILOT AIR COMPRESSORS http://www.pilotair.com Phone: 1300 667 579 Email: service@pilotair.com.au / spares@pilotair.com.au P a g e SCR SERIES Instructions and Parts List...
- Page 3 INDEX Safety Specification Chart Installation Commission & Operation Operation Maintenance Wiring Diagram Warrant Terms and Conditions P a g e SCR SERIES Instructions and Parts List...
- Page 4 Heat build up in the pump may cause burns to unwary. Never operate the unit without factory fitted belt guard. (Belt Drive Models) or Pump Shroud (Direct Drive Models). Never operate the unit with damaged or exposed electrical wiring. P a g e SCR SERIES Instructions and Parts List...
- Page 5 Pilot Air or an authorised Pilot Air agent. Whenever transporting an air compressor, ensure all air is drained from the air receiver. There should be NO residual air pressure in the air receiver. P a g e SCR SERIES Instructions and Parts List...
- Page 6 Specification Chart Max. Noise F.A.D Motor Size Dimensions Weight Pressure Level L/Min D(B) A SCR2.2/ 240V (240V) (240V) SCR2.2 SCR4 14.1 SCR5.5 21.2 SCR7.5 30.0 P a g e SCR SERIES Instructions and Parts List...
-
Page 7: Precautions Before Operation
• Never operate the compressor at higher Discharge pressure than those specified on the Compressor Nameplate pressure specification. • Care needs to be exercised and the operation of the unit needs to be monitored in ambient conditions of 40 degrees or more P a g e SCR SERIES Instructions and Parts List... - Page 8 Installation PANEL NAME NAME Power Indicator Reset Stop Indicator Hour Meter Running Remote / Local Pressure Phase Reversal Overload Over Temp. START Emergency STOP Pressure P a g e SCR SERIES Instructions and Parts List...
-
Page 9: Primary Checks
3. Check pressure is rising or not. If pressure does not rise, turn the unit off, check the Pressure Gauge, rotation of Air end and pressure pipe. 4. If the unit is running in normal status, close all the covers. P a g e SCR SERIES Instructions and Parts List... - Page 10 ATTENTION: All the part and pipe in the compressor is at high temperature. DO NOT touch any part or pipe without any protection or cause serious injury. 10 | P a g e SCR SERIES Instructions and Parts List...
-
Page 11: Maintenance Precautions
• Never use combustible liquid to clean the Valve set and the Cooler. • Carefully treat all the waste grease and waste water by following local • Environmental Regulations. 11 | P a g e SCR SERIES Instructions and Parts List... - Page 12 4. LEAKAGE • Check if any leakage in the compressor system. 5. BELT TENSION • Check the belts for tightness and adjust it daily if necessary. 12 | P a g e SCR SERIES Instructions and Parts List...
-
Page 13: Belt Maintenance
3. Make alignment by locating a steel ruler between pully of Air end and motor, and the clearance between two pulley below 1.0 mm. 4. Replace all belts. 5. Follow steps A. (ADJUSTMENT BELT TENSION), C. (BELT TENSION MEASUREMENT) 13 | P a g e SCR SERIES Instructions and Parts List... -
Page 14: Enclosure Filter
Discharge temperature. • Clean with compressed air or neutral detergent and water if necessary. ELECTRICAL SYSTEM • Check all the electrical connections are firmly connected。 14 | P a g e SCR SERIES Instructions and Parts List... - Page 15 Troubleshooting 15 | P a g e SCR SERIES Instructions and Parts List...
- Page 16 Troubleshooting 16 | P a g e SCR SERIES Instructions and Parts List...
- Page 17 Wiring Diagram 17 | P a g e SCR SERIES Instructions and Parts List...
- Page 18 Pilot Air are not covered by this warranty. Purchasers are referred to the individual manufacturer’s warranty. Purchasers can request a copy of the applicable warranties by contacting Pilot Air using the contact details below. 18 | P a g e SCR SERIES Instructions and Parts List...
- Page 19 Pilot Air literature current at the time of installation and must be installed in conjunction with the components or products specified in the Pilot Air literature. To obtain copies of such literature go to www.pilotair.com.au or telephone Pilot Air on (02) 9648 3099;...
- Page 20 Product is to be returned to it. Any unapproved courier, transport or freight related costs will be to the claimant’s account. 20 | P a g e SCR SERIES Instructions and Parts List...
- Page 21 For more information or to make a claim under any warranty specified herein please telephone Pilot Air on (02) 9648 3099, email Pilot Air via our website: http://www.pilotair.com.au or write to Pilot Air at: Pilot Air Compressors Pty Ltd 115 Beaconsfield Road...
Need help?
Do you have a question about the SCR Series and is the answer not in the manual?
Questions and answers