Control Panels; Local Control Panel; Remote Control Panels - Onan MDKBH Series Service Manual

2. Control Panels

LOCAL CONTROL PANEL

Refer to Figure 2-1.
Control Switch
Starting: Push and Hold START to preheat, crank
and start the genset. The green status lamp comes
on when the genset is running. (Preheat is the peri-
od of time prior to engine cranking when the glow
plugs preheat the combustion chambers. The time
is automatically varied by the genset controller on
the basis of engine temperature.)
Stopping: Push and Release STOP (Prime) to
stop the genset.
Priming: Push and Hold STOP (Prime to prime the
fuel system (amber lamp comes on in 2 seconds to
indicate priming).
Status Lamps
The control switch has two status lamps. The amber
status lamp comes on during priming, blinks rapidly
during cranking and goes out when the engine is up
to speed. If the genset shuts down abnormally, this
lamp will slowly blink a numerical code to indicate
the cause of shutdown. See Troubleshooting (Sec-
tion 11). The green status lamp comes on to indi-
cate that the genset is running.
LINE CIRCUIT BREAKER
CONTROL SWITCH &
STATUS INDICATOR LAMPS
EMERGENCY
STOP SWITCH
HOUR METER
SmartCraft is a trademark of the Brunswick Corporation.
Emergency Stop Switch
In an emergency push the switch to OFF. Push it to
ON after all necessary repairs to the genset and
connected equipment have been made.
Line Circuit Breaker
The line circuit breaker protects the AC power leads
connected to the genset from overloads and equip-
ment short circuits.
Hour Meter
The hour meter records genset operating time in
hours. It cannot be reset.
Remote Control
The boat may be equipped with several remote con-
trol stations having e-Series Digital Displays
(p. 2-2) or control switches with status lamps.
Boat Monitoring System
The boat may be equipped to monitor genset opera-
tion on an integrated monitoring system using an
SAE J1939 or SmartCraft network protocol.
FIGURE 2-1. LOCAL CONTROL PANEL
2-1

REMOTE CONTROL PANELS

OIL FILL NECK
Redistribution or publication of this document,
by any means, is strictly prohibited.