Personal Precautions - Pro-Logix PL2545 Operator's Manual

1. SAVE THESE INSTRUCTIONS – This
manual contains important safety and
operating instructions for Model No. PL2545.
2. Do not expose charger to rain or snow.
3. Use of an attachment not recommended or
sold by the manufacturer may result in a risk
of fire, electric shock, or injury to persons.
4. To reduce risk of damage to electric plug
and cord, pull by plug rather than cord when
disconnecting charger.
5. An extension cord should not be used unless
absolutely necessary. Use of an improper
extension cord could result in a risk of fire and
electric shock. If extension cord must be used,
make sure:
a. That pins on plug of extension cord are the
same number, size, and shape as those of
plug on charger,
b. That extension cord is properly wired and in
good electrical condition; and
c. That the wire size is large enough for the
length of cord as specified below.
Cord Length: ft.(m)
AWG size of cord:
B
1. Someone should be within range of your voice
or close enough to come to your aid when you
work near a lead-acid battery.
2. Have plenty of fresh water and soap nearby
in case battery acid contacts skin, clothing, or
eyes.
3. Wear complete eye protection and clothing
protection. Avoid touching eyes while working
near battery.
4. If battery acid contacts skin or clothing, wash
immediately with soap and water. If acid
enters eye, immediately flood eye with cold
running water for at least 10 minutes and get
medical attention immediately.
5. NEVER smoke or allow a spark or flame in
vicinity of battery or engine.
25(8) 50(16) 100(31) 150(46)
18 16 14

PERSONAL PRECAUTIONS

6. To prevent electric shock - Dispose of battery
charger if cord becomes defective.
7. Do not operate charger if it has received
a sharp blow, been dropped, or otherwise
damaged in any way; take it to a qualified
service center.
8. Do not disassemble charger; take it to a
qualified service center when service or repair
is required. Incorrect reassembly may result in
a risk of electric shock or fire.
9. To reduce risk of electric shock, unplug the
charger from outlet before attempting any
maintenance or cleaning. Turning off controls
will not reduce this risk.
10. Monitor battery charger daily when using it to
maintain battery for extended periods.
11. WARNING – RISK OF EXPLOSIVE GASES.
a. Working in vicinity of a lead-acid battery is
dangerous. Batteries generate explosive
gases during normal battery operation. For
this reason, it is of utmost importance that
each time before using your charger, you
read this manual and follow the instructions
exactly.
b. To reduce risk of battery explosion, follow
12
these instructions and those published
by the battery manufacturer and the
manufacturer of any equipment you intend
to use in the vicinity of the battery. Review
cautionary markings on these products and
in the engine compartment.
6. Be extra cautious to reduce risk of dropping a
metal tool onto battery. It might spark or short-
circuit battery or other electrical part that may
cause explosion.
7. Remove personal metal items such as rings,
bracelets, necklaces, and watches when
working with a lead-acid battery. A lead-acid
battery can produce a short-circuit current
high enough to weld a ring or other jewelry to
metal, causing a severe burn.
8. Use charger for charging LEAD-ACID batteries
only. It is not intended to supply power to a
low voltage electrical system other than in a
starter-motor application. Do not use battery
charger for charging dry-cell batteries that
are commonly used with home appliances.
These batteries may burst and cause injury to
persons and damage to property.
9. NEVER charge a frozen battery.