Page 1
FRYER Manual Instructions AEF-3540S LP, AEF 3540 NG, AEF-4050S LP, AEF-4050S NG AEF-2525 S LP, AEF 2525 NG, AEF-75 S LP, AEF- 75 NG Manual instructions Manueltalimatları Installation and Operation Kurulum ve Çalıştırma Manual de instrucciones Manuel d’instructions Uso y mantenimiento...
MACHINE INTRODUCTION 1.1 INTRODUCTION TO MACHINE& MODELS All equipment manufactured by ASBER. is for use with the type of gas specified on the rating plate and for installation will be in accordance with National Fuel Gas Code ANSI Z223.1 (latest edition) Instruction to be followed in the event the user smells gas shall be posted in a prominent location.
2.4 Gas Connections 2.1 Transport, handling, unpacking, location Upon receiving your new ASBER Equipment, check the package and the machine for any damages that may have occurred during transportation. Visually inspect the exterior of the package. If damaged, open and inspect the contents with the carrier. Any damage should be noted and reported on the delivering carrier’s receipt.
asberprofessional.com 2.3 Installation and assembly SHIPPING DAMAGE CLAIM PROCEDURE The equipment is inspected and crated by skilled personnel before leaving our factory. The transportation company assumes full responsibility for safe delivery upon acceptance of this equipment. If shipment arrives damaged: Visible loss or damage: Note on freight bill or express delivery and signed by person making delivery.
Page 6
2.4 How to install caster on asber fryer. STEP 1: Turn furnishing in order to see fryer bottom. STEP 2: This is how the base frame must see. Important. you will have 2 wheels with brake and 2 wheels no brake. Identify...
2.5.2 PRESSURE REGULATOR Commercial cooking equipment must have a pressure regulator on the incoming service line for safe and efficient operation; the gas pressure regulator supplied by ASBER must be installed at the gas inlet of each piece of equipment.
asberprofessional.com 2.5.4 PRESSURE REGULATOR CONVERSION A. Remove cap and snap out plastic plunger from bottom of cap. B. Turn plunger over and snap back in original location. C. Re-insert the cap assembly into the regulator and tighten. Failure to install the pressure regulator will void the appliance warranty The fryer needs to be restrained to prevent tipping when installed in order to avoid the splashing of hot liquid.
asberprofessional.com OPERATION 3.1 General information. 3.2 Lighting Instructions. 3.3Daily Shut-Down. 3.1 General information. Operation of this equipment must be performed by qualified or authorized personnel who have read and are familiar with the functions of the equipment. WARINING Hot oil and hot surfaces can cause severe burns. Use caution when operating the fryer. Do not attempt to move the fryer filled whit hot oil or shortening.
asberprofessional.com MAINTENANCE 4.1 Cleaning 4.1 CLEANING For continued performance efficiency and longevity of your Fryer it is essential to carry out a good maintenance program. 4.1.1 DAILY 1. Remove and wash thoroughly all “loose” parts (basket hanger, baskets, crumb screen, etc.).
asberprofessional.com TROUBLE SHOOTING PROBLEM PROBABLE CAUSE REMEDY Pilot will not a. No gas a. Turn main gas valve “ON” light b. Gas tap dial not set at “Pilot” b. Set dial position and depressed. combination gas valve to “Pilot”. Depress and hold while lighting.
ASBER shall not be liable whether in contract or in tort or under any other legal theory for loss of revenue or profit, or for any substitute use or performance or for incidental, indirect, special or consequential damages, or for any other loss or cost of similar type.
Page 13
ASBER Circuito Exportación N° 201 Parque Industrial Tres Naciones San Luís Potosí, S.L.P. México 13105 NW 47th Ave Miami, Fl. 33054 www.asberprofessional.com MULTI-SOLUTION MANUFACTURER OF FOODSERVICE EQUIPMENT asberprofessional.com...
Need help?
Do you have a question about the AEF-3540S LP and is the answer not in the manual?
Questions and answers