SUNSET NEB300BASKETBALL Instruction Manual

Cleaning

Cleaning of the compressor
Deluxe Nasal Pillow CPAP Mask
Use a clean dry cloth and mild detergents to clean the outside of
the unit.
ATTENTION During cleaning, make sure the internal parts of the unit
CM036
Item#
are not in contact with liquids and the power cord is disconnected.

Intended Use

Cleaning and disinfection of the accessories
After each use, disassemble and wash all nebulizer kit parts except the
The nasal pillow mask is intended to provide an interface for Continuous Positive Airway Pressure (CPAP) or bilevel system.
long thin air tubing tubing in warm soapy water and rinse well, shake off
The mask to be used by adult patients (>66lb/30kg) for whom positive airway pressure has been prescribed. The mask is for
excess water and allow to air dry (do not towel dry). Never immerse the
single-patient re-use in the home environment and multi-patient re-use in the hospital/institutional environment.
long thin air tubing in water.
Do not boil or autoclave angled mouthpieces, air tubes, or masks.
Caution
It is important that the cleaning instructions are carefully US federal law restricts this device to sale by or on the order of a physician.
followed to ensure optimal operation.

Excluding patient population

This mask may not be suitable for patients with the following conditions: impaired cardiac sphincter function, excessive

Replacement of Nebulizer Kit

reflux, impaired cough reflex and hiatal hernia. It should not be used if the patient is unresponsive, obtunded, unable to
remove the mask, or uncooperative.
RES2210 Pediatric Aerosol Mask
(Included in NEB300BASKETBALL and NEB300BASKETBALL -R)
The pediatric aerosol mask should be replaced after a long period of

Warnings

inactivity, or if it is obstructed by dry medication, dust, etc. With normal
use, the pediatric aerosol mask should last 1 month.
This mask is designed for use with CPAP or bilevel systems recommended by your health care professional or respiratory
RES091 Disposable Nebulizer Kit with Clear Tubing
therapist. Do not wear this mask unless the CPAP or bilevel system is turned on and operating properly. Do not block or try
(Included in NEB300BASKETBALL and NEB300BASKETBALL -R)
to seal the exhalation port.
The disposable nebulizer T-Piece kit should be replaced after a long
CPAP systems are intended to be used with special masks with connectors which have vent holes to allow continuous ow of air out of the mask. When the
period of inactivity, or if it is obstructed by dry medication, dust,etc. With
normal use, the disposable nebulizer T-piece kit should last 1 month. device is turned on and functioning properly, new air from the device ushes the exhaled air out through the attached mask exhalation port. However, when
the device is not operating, enough fresh air will not be provided through the mask, and exhaled air may be re-breathed. At low pressures, the air ow through
RES093 Reusable Nebulizer Kit with Green Tubing
the exhalation port may not be enough to clear all of the exhaled gas (CO2) from the mask. You may breathe in some of the air that you have exhaled.
(Included in NEB300BASKETBALL -R)
The reusable nebulizer T-Piece kit should be replaced after a long period
If oxygen is used with the device, the oxygen flow must be turned off when the device is not operating.
of inactivity, or if it is obstructed by dry medication, dust, etc. With
normal use, the reusable nebulizer T-piece kit should last 6 months. • When the device is not in operation, and the oxygen ow is left on, oxygen delivered into the ventilator tubing may accumulate within the device enclosure.
Oxygen accumulated in the device enclosure will create a risk of re.
• Oxygen supports combustion. Oxygen should not be used while smoking or in the presence of an open ame.

Replacement of the filter

• At a xed ow rate of supplemental oxygen ow, the inhaled oxygen concentration will vary, depending on the pressure settings, patient breathing pattern,
nasal interface selection, and the leak rate.
The filter is to be replaced after approximately 30 hours of use, or when
it appears dirty. Open the filter holder to replace the filter with a new
one. Use Sunset BF018 Nebulizer Filters. Some users may experience skin redness. If this happens, contact your health care professional.
Do not use the device without the filter.

Cleaning the Mask

The cushion, nasal interface, and tubing should be cleaned daily or as needed.

Maintenance and Repair

• Hand wash in warm water with a mild liquid dishwashing detergent. Do not use bleach, alcohol, or cleaning solutions
containing alcohol. Do not use cleaners containing conditioners or moisturizers.
Never open the device. There are no serviceable parts within the unit.
• Rinse thoroughly. Pat with a towel and air dry completely before use
The compressor does not require lubrication or maintenance.
• Inspect all parts for damage or wear; replace if necessary.

Troubleshooting

Symptom Probable Cause Solution
Noisy operation No filter in the unit. Put a filter in the unit.
Nebulizer power Turn nebulizer power
switch is off. switch on.
Make sure the plug is
Plug is loose. firmly inserted into the
electrical outlet.
Make sure the device has
Operating for longer been operating within
than the nebulizer is the indicated limits:
designed to operate 30 minutes ON/
30 minutes OFF.
Nebulizer kit nozzle
or other parts are Clean the nebulizer kit.
obstructed
Nebulizer does
Remove any bends or
not run or
kinks in the air tube.
nebulization is
Air tube is bent Make sure the ends of
weak
or not connected the air tube are fitted
firmly. tightly onto the main
unit and onto the
nebulizer.
The filter is clogged. Replace the filter.
Use the appropriate
amount of medicine
Medicine cup is
prescribed by your
empty or overfilled.
physician to the medicine
container.
Reattach the medicine
The medicine cup
cup cap and make sure
cap or baffle is
the baffle is inserted
loose.
properly. See diagrams.
Adjust the amount of
medicine in the medicine
container to the appro-
Medication has been
priate level, connect
overfilled
the air tube to the air
There is conden-
compressor, and turn the
sation in the air
unit on.
tube
Open and close the
The nebulizer kit
nebulizer kit
was washed but not
repeatedly until the drops
dried.
disappear.
Instruction Manual
Pediatric
Compressor
Nebulizer
NEB300BASKETBALL
NEB300BASKETBALL-R
NEB300BASKETBALL-IFU V 1.01
2020-09-03