Operation Start up procedure........................17 Shutdown ..........................17 Maintenance Fan replacement ........................18 Stepping on the unit .........................18 Spare parts..........................19 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Air Cooled Liquid Coolers Product Manual AHE00050. Both manuals must be carefully examined and instructions should be followed up at all times. Alfa LU-VE does not accept liabil- ity for any damage resulting from non-compliance to the instructions as given in the manuals and order-related documents.
- AC fan step control cabinet (BST) - EC fan speed control cabinet (ICM) - Basic EC switchboard panel (ECCB) 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
2. Handle with care HANDLE When handling the unit, always take maximum WITH CARE care. HANDLE WITH CARE 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Page 6
READ INSTRUCTION MANUAL BEFORE INSTALLATION AND MAINTENANCE TO AVOID INJURIES OR DAMAGE coil has been pres- sure tested in the factory 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Page 7
Grounding is designed for the electrical equipment supplied with the unit and is not to be intended as protection from external sourc- 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Remove any obstacle to allow the skid sliding out of the container. • Ensure the truck is stopped. 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Page 9
Remove hooks and chains and drive away with forklift A. Slowly drive forward with the truck until the unit is completely outside the container. 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
If one chain is not fully loaded another chain will be extra loaded. This is not allowed. DETAIL A 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Page 11
6 MOD 10 FANS 12 FANS 7 MOD 8 MOD 14 FANS 16 FANS 9 MOD 18 FANS 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Container skid components are connected to the unit by means of screws, as highlighted below. To remove the skid and the additional support feet it is needed to slightly lift the unit. 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Expansion joints are also helpful in order to reduce vibrations in the piping. 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Vibration dampers For active and passive isolation of vibrations and reducing noise transmission, Alfa LU-VE strongly recommends the installation of vibration dampers. Installation of vibration dampers must be carried out before positioning the unit. Vibration dampers are to be positioned between the unit feet and the mounting base with the supplied M16 screw.
In case of doubt, to determine optimal unit spacing for specific conditions on site please contact your Alfa LU-VE representative for advise. 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
(N-1)/2 (N-1)/1.2 N= number of units on the platform. All three conditions (H, d, h) shall be met. Contact Alfa LU-VE in case a different lay out is required. Special care should be taken in particular circumstances, such as: •...
Make sure all drained liquid will be collected in a suitable vessel. • Compressed air helps to drain in less time. Compressed air shall be oil free. 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Never step on the fan grids and on the liquid connections. It is not allowed to step outside the areas highlighted in the example below. = walkable areas 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
④ Protection grids (available on request) ⑤ Contact your local Alfa LU-VE representative for spare parts order and assistance. 30366474EN-03 Alfa LU-VE is a trademark registered and owned by LU-VE Group. Alfa LU-VE reserves the right to change specifications without prior notification.
Need help?
Do you have a question about the Alfa LU-VE Alfa-V VDD and is the answer not in the manual?
Questions and answers