75 pounds 75 pounds SAFE OPERATING LOADS OF OPTIONAL STORAGE COMPARTMENT Top Shelf 20 pounds Bottom Shelf 20 pounds Stryker reserves the right to change specifications without notice. Return To Table of Contents 3150-009-001 REV B 3150-009-001 REV B www.stryker.com www.stryker.com...
Note This provides special information to make maintenance easier or important instructions clearer. Symbols Warning, consult accompanying documentation Safe Working Load Symbol Return To Table of Contents www.stryker.com www.stryker.com www.stryker.com 3150-009-001 REV B 3150-009-001 REV B 3150-009-001 REV B...
• Make sure that nothing is on top of the unit and that you have the unit fully supported so not to cause damage to the overbed table nor to cause injury to yourself. Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Pull out the optional vanity (B) with the flip up mirror in either direction (if equipped). WARNING Do not lean on table. Leaning on table may cause the table to tip which may result in injury to the individual or damage to the unit. Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Pull out the vanity (C) with the flip up mirror in either direction. WARNING Do not lean on table. Leaning on table may cause the table to tip which may result in injury to the individual or damage to the unit. Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Release the clip. WARNING Do not lean on table. Leaning on table may cause the table to tip which may result in injury to the individual or damage to the unit. Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Push bin in to close. WARNING Do not lean on table. Leaning on table may cause the table to tip which may result in injury to the individual or damage to the unit. Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Spray the top weldment tube with pure silicone spray before reassembly. DO NOT use WD-40 or any other lubricant or damage to the table could occur. Return To Table of Contents www.stryker.com 3150-009-001 REV B...
15 light weight load applied. Add 1/4” washers under the four main base bolts. Squeaky noise in between base and column. NOTE: Remove and reinstall bolts one at a time. Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Using a Phillips screwdriver, remove the ten #10 Phillips screws that hold the vanity tracks to the bottom of the table top. Remove the vanity tray from the table top. Reverse procedures to install the new top. Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Turn the table top upside down and separate the primary and secondary tops. Turn over the secondary top, turn the vanity tray approximately 45 degrees and remove it from the table top. Reverse procedures to install the new top. Return To Table of Contents 3150-009-001 REV B www.stryker.com...
When reinstalling the upper bushing, compress the gas spring slightly before tightening the two T27 Torx screws that connect the upper bushing to the lower column. Gas Spring Release Lever Removal Return To Table of Contents www.stryker.com 3150-009-001 REV B...
T27 torx driver, hand-tighten the truss head screws to secure the leg ballasts in place. NOTE: Do not overtighten the screws to avoid stripping them out. Verify proper operation of the product before returning it to service. Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Turn the base and cover over. Using the Phillips screwdriver, remove the six #8 Phillips screws that hold the cover to the base. Turn the base back over and remove the cover. 10. Reverse procedures to install the new cover. Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Turn over the table top, turn the vanity tray approximately 45 and remove it from the table top. Reverse procedures to install the new vanity tray. Return To Table of Contents 3150-009-001 REV B www.stryker.com...
While holding the top of the broken mirror with one hand, use your other hand to flex the bottom of the mirror in the middle and remove it from the vanity. Reverse procedures to install the new mirror. Return To Table of Contents www.stryker.com 3150-009-001 REV B...
0027-019-000 Rue Clip 3150-002-205 Lift Handle 3150-002-310 Gas Spring Assembly (see page 43) 1 3150-002-405 Lower Bushing 3150-002-410 Upper Bushing 3150-009-100 Label 3150-010-115 Top Support Weldment 0023-256-000 Phillips Pan Head Screw Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Page 21
Item Part No. Part Name Qty. (see table above) Base Cover 3150-001-105 Base Weldment 3150-001-200 Caster 3150-002-100 Lower Column 0023-116-000 Phillips Pan Head Screw 0025-122-000 Rivet 3150-001-223 Torx Flat Head Screw Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Page 22
Tops Prior to 2/1/2005 (Available as Service Parts Only) Hearth Oak Pewter 3150-092-444 Royal Maple Pewter 3150-092-445 Hearth Oak Coffee 3150-090-444 Royal Maple Coffee 3150-090-445 Hearth Oak Graphite 3150-091-444 Royal Maple Graphite 3150-091-445 Return To Table of Contents 3150-009-001 REV B www.stryker.com...
3150-002-410 Upper Bushing 3150-009-100 Label 3150-010-105 Top Support Weldment 0023-256-000 Phillips Pan Head Screw 3150-010-221 Long Track 3150-010-222 Short Track 3150-010-500 Vanity Tray 3150-010-510 Vanity Mirror 0020-020-000 Phillips Head Wood Screw Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Page 24
Item Part No. Part Name Qty. (see table above) Base Cover 3150-001-105 Base Weldment 3150-001-200 Caster 3150-002-100 Lower Column 0023-116-000 Phillips Pan Head Screw 0025-122-000 Rivet 3150-001-223 Torx Flat Head Screw Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Page 25
Tops Prior to 2/1/2005 (Available as Service Parts Only) Hearth Oak Pewter 3150-096-444 Royal Maple Pewter 3150-096-445 Hearth Oak Coffee 3150-097-444 Royal Maple Coffee 3150-097-445 Hearth Oak Graphite 3150-098-444 Royal Maple Graphite 3150-098-445 Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Rue Clip 3150-002-205 Lift Handle 3150-002-330 Gas Spring Assembly (see page 43) 1 3150-002-405 Lower Bushing 3150-002-410 Upper Bushing 3150-009-100 Label 3150-010-110 Top Support Weldment 0017-002-000 Cap Nut 3100-100-079 Gear 0016-128-000 Pushnut Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Page 27
(see table above) Gear Rack 0004-136-000 Pan Head Machine Screw 3150-010-421 Overbed Table End Slide 3150-010-422 Overbed Table Mid Slide 0020-020-000 Philllips Head Wood Screw (see page Secondary Split-top Assembly 3150-010-500 Vanity Tray Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Page 28
Item Part No. Part Name Qty. (see table above) Base Cover 3150-001-105 Base Weldment 3150-001-200 Caster 3150-002-100 Lower Column 0023-116-000 Phillips Pan Head Screw 0025-122-000 Rivet 3150-001-223 Torx Flat Head Screw Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Page 29
Tops Prior to 2/1/2005 (Available as Service Parts Only) Hearth Oak Pewter 3150-092-444 3150-094-444 Royal Maple Pewter 3150-092-445 3150-094-445 Hearth Oak Coffee 3150-090-444 3150-093-444 Royal Maple Coffee 3150-090-445 3150-093-445 Hearth Oak Graphite 3150-091-444 3150-095-444 Royal Maple Graphite 3150-091-445 3150-095-445 Return To Table of Contents www.stryker.com 3150-009-001 REV B...
0027-019-000 Rue Clip 3150-002-205 Lift Handle 3151-002-101 Gas Spring Assembly (see page 43) 1 3150-002-405 Lower Bushing 3150-002-410 Upper Bushing 3150-009-100 Label 3150-010-115 Top Support Weldment 0023-256-000 Phillips Pan Head Screw Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Page 31
Base Weldment 3150-001-200 Caster 3150-002-100 Lower Column 0023-116-000 Phillips Pan Head Screw 0025-122-000 Rivet 3150-001-223 Torx Flat Head Screw 3151-050-807 Left Leg Ballast 3151-050-809 Right Leg Ballast 0007-065-000 Truss Head Screw Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Page 32
Frame Assembly 3151-050-390 3151-050-391 3151-050-392 3151-050-393 Top Shelf 3151-050-190 3151-050-191 3151-050-192 3151-050-193 Upper Column Clamp 3151-050-490 3151-050-491 3151-050-492 3151-050-493 Upper Column Cover 3151-050-790 3151-050-791 3151-050-792 3151-050-793 Bag Clip 3151-050-590 3151-050-591 3151-050-592 3151-050-593 Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Page 33
Tops Prior to 2/1/2005 (Available as Service Parts Only) Hearth Oak Pewter 3150-092-444 Royal Maple Pewter 3150-092-445 Hearth Oak Coffee 3150-090-444 Royal Maple Coffee 3150-090-445 Hearth Oak Graphite 3150-091-444 Royal Maple Graphite 3150-091-445 Return To Table of Contents www.stryker.com 3150-009-001 REV B...
0027-019-000 Rue Clip 3150-002-205 Lift Handle 3151-002-102 Gas Spring Assembly (see page 43) 1 3150-002-405 Lower Bushing 3150-002-410 Upper Bushing 3150-009-100 Label 3150-010-105 Top Support Weldment 0023-256-000 Phillips Pan Head Screw Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Page 35
For Reference Only: Part Number 3150-000-500 Item Part No. Part Name Qty. (see page Primary Split-top Assembly 3150-010-221 Long Track 3150-010-222 Short Track 3150-010-500 Vanity Tray 3150-010-510 Vanity Mirror 0020-020-000 Phillips Head Wood Screw Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Page 36
Base Weldment 3150-001-200 Caster 3150-002-100 Lower Column 0023-116-000 Phillips Pan Head Screw 0025-122-000 Rivet 3150-001-223 Torx Flat Head Screw 3151-050-807 Left Leg Ballast 3151-050-809 Right Leg Ballast 0007-065-000 Truss Head Screw Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Page 38
Tops Prior to 2/1/2005 (Available as Service Parts Only) Hearth Oak Pewter 3150-092-444 Royal Maple Pewter 3150-092-445 Hearth Oak Coffee 3150-090-444 Royal Maple Coffee 3150-090-445 Hearth Oak Graphite 3150-091-444 Royal Maple Graphite 3150-091-445 Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Rue Clip 3150-002-205 Lift Handle 3151-002-103 Gas Spring Assembly (see page 43) 1 3150-002-405 Lower Bushing 3150-002-410 Upper Bushing 3150-009-100 Label 3150-010-110 Top Support Weldment 0017-002-000 Cap Nut 3100-100-079 Gear 0016-128-000 Pushnut Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Page 40
(see table above) Gear Rack 0004-136-000 Pan Head Machine Screw 3150-010-421 Overbed Table End Slide 3150-010-422 Overbed Table Mid Slide 0020-020-000 Philllips Head Wood Screw (see page Secondary Split-top Assembly 3150-010-500 Vanity Tray Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Page 41
Base Weldment 3150-001-200 Caster 3150-002-100 Lower Column 0023-116-000 Phillips Pan Head Screw 0025-122-000 Rivet 3150-001-223 Torx Flat Head Screw 3151-050-807 Left Leg Ballast 3151-050-809 Right Leg Ballast 0007-065-000 Truss Head Torx Screw Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Page 42
Frame Assembly 3151-050-390 3151-050-391 3151-050-392 3151-050-393 Top Shelf 3151-050-190 3151-050-191 3151-050-192 3151-050-193 Upper Column Clamp 3151-050-490 3151-050-491 3151-050-492 3151-050-493 Upper Column Cover 3151-050-790 3151-050-791 3151-050-792 3151-050-793 Bag Clip 3151-050-590 3151-050-591 3151-050-592 3151-050-593 Return To Table of Contents 3150-009-001 REV B www.stryker.com...
Page 43
Tops Prior to 2/1/2005 (Available as Service Parts Only) Hearth Oak Pewter 3150-092-444 3150-094-444 Royal Maple Pewter 3150-092-445 3150-094-445 Hearth Oak Coffee 3150-090-444 3150-093-444 Royal Maple Coffee 3150-090-445 3150-093-445 Hearth Oak Graphite 3150-091-444 3150-095-444 Royal Maple Graphite 3150-091-445 3150-095-445 Return To Table of Contents www.stryker.com 3150-009-001 REV B...
Mid Pressure (Single-top With Vanity) 3150-002-320 High Pressure (Split-top) 3150-002-330 FOR OPTIONAL STORAGE COMPARTMENT ONLY: Gas Spring Type Part Number Low Pressure (Single-top) 3151-002-101 Mid Pressure (Single-top With Vanity) 3151-002-102 High Pressure (Split-top) 3151-002-103 Return To Table of Contents 3150-009-001 REV B www.stryker.com...
ONE YEAR WARRANTY Stryker warrants the following products for one year under normal use and proper care. For one year from date of shipment, Stryker will repair or, at our option, replace defective merchandise free of charge (parts, labor and shipping included).
Stryker authorized parts used Service during regular business hours (8−5) * Does not include maintenance due to abuse or for any disposable items. Stryker reserves the right to change options without notice. Stryker Medical also offers personalized service contracts. Pricing is determined by age, location, model and condition of product.
Page 48
Stryker Medical 3800 E. Centre Ave. Portage, Michigan 49002 2015/08 3150-009-001 REV B www.stryker.com...