Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
Page 2
EN 2 TPM15.5L LA Revision List 1. Revision List Manual xxxx xxx xxxx.0 Manual xxxx xxx xxxx.2 • First release. • Chapter 2:Updated table 2.1 Technical Specifications Chapter 4 : Updated figure • 4-2 Cable dressing (40" & 43" 5000 series).
Page 3
Technical Specs, Diversity, and Connections TPM15.5L LA EN 3 Connections Rear Connectors Side Connectors HDMI 2 SERV.U HDMI 1 TV ANTENNA SPDIF CVBS 19760_001.eps Figure 2-1 Connection overview Note: The following connector colour abbreviations are used 5 - Service / UART (acc.
Page 4
EN 4 TPM15.5L LA Technical Specs, Diversity, and Connections 7- HDMI 1: Digital Video - In, Digital Audio with ARC - In/Out 10 - CLK+ Data channel 11 - Shield 12 - CLK- Data channel 13 - Easylink/CEC Control channel 10000_017_090121.eps...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 6
EN 6 TPM15.5L LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M.
Page 7
Precautions, Notes, and Abbreviation List TPM15.5L LA EN 7 Digital Noise Reduction: noise The SDI signal is self-synchronizing, reduction feature of the set uses 8 bit or 10 bit data words, and has DRAM Dynamic RAM a maximum data rate of 270 Mbit/s,...
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPM15.5L LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal 4.4 Set Re-assembly...
Page 10
EN 10 TPM15.5L LA Mechanical Instructions ECN408 CN8601 CN408 MAIN POWER SUPPLY (1054) (1053) ECN701 ECN403 LOUDSPEAKER LOUDSPEAKER (1184) (1184) IR/LED BOARD (1056) 19760_101.eps Figure 4-2 Cable dressing (40" & 43" 5000 series) ECN701 CN8101 CN9301 ECN408 MAIN POWER SUPPLY...
Page 11
Mechanical Instructions TPM15.5L LA EN 11 Service Positions Assembly/Panel Removal For easy servicing of a TV set, the set should be put face down Instructions below apply to the 32PHG5000/78, but will be on a soft flat surface, foam buffers or other specific workshop similar for other 5000 series and 32"4900 series models.
Page 12
EN 12 TPM15.5L LA Mechanical Instructions M3× 8 M3× 6 19760_103.eps Figure 4-5 Rear cover removal 4.3.3 Keyboard Control Unit Refer to Figure 4-6 for details. 1. Release the connector [2] from the keyboard control panel. Caution: be careful, as these are very fragile connectors! 2.
Page 13
Mechanical Instructions TPM15.5L LA EN 13 19760_105.eps Figure 4-6 Keyboard Control unit removal 4.3.4 Small Signal Board (SSB) Refer to Figure 4-7 for details. Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the SSB.
Page 14
EN 14 TPM15.5L LA Mechanical Instructions 4.3.6 Speakers 1. Gently release the tapes that secure the speaker cables. 2. Unplug the speaker connector from the SSB. 3. Take the speakers out. When defective, replace the both units. 4.3.7 IR/LED Board 1.
Service Modes, Error Codes, and Fault Finding TPM15.5L LA EN 15 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: SAM in a decimal value. Every two soft-resets increase the 5.1 Test Points hour by + 1. Stand-by hours are not counted.
Page 16
EN 16 TPM15.5L LA Service Modes, Error Codes, and Fault Finding Table 5-1 SAM mode overview Main Menu Sub-menu 1 Sub-menu 2 Description System Information Op Hour e.g. 00057 This represents the life timer. The timer counts normal operation hours, but does not count Stand-by hours.
Page 17
Service Modes, Error Codes, and Fault Finding TPM15.5L LA EN 17 Table 5-2 Factory mode overview Default value Item Item value 32" 40" 43" 48" Description F/W VERSION Press OK Displays the software versions of the supplier, Flash PQ, Smart Picture, BL Dimming, Source Meter, the Picture Quality checksum, the Dimming library, the Source meter library, the Flash AQ, the MTK, MCU and OAD software versions.
Page 18
EN 18 TPM15.5L LA Service Modes, Error Codes, and Fault Finding Default value Item Item value 32" 40" 43" 48" Description ESTICKER NVM19 ESTICKER value ESTICKER NVM20 ESTICKER value ESTICKER RESET Press OK ESTICKER reset DIM_LIB RESET Press OK Reset the Dimming...
Page 19
Service Modes, Error Codes, and Fault Finding TPM15.5L LA EN 19 How to Navigate How to Exit CSM By means of the “CURSOR-DOWN/UP” knob (or the scroll To exit CSM, use one of the following methods. wheel) on the RC-transmitter, can be navigated through the •...
Page 20
A description on how to upgrade the main 1. ComPair helps to quickly get an understanding on how to software can be found in the DFU or on the Philips website. repair the chassis in a short and effective way.
Page 21
Service Modes, Error Codes, and Fault Finding TPM15.5L LA EN 21 • FUS_clustername_version.zip: Contains the file downloaded which is needed to upgrade the TV main software and the software download application. • NVM_clustername_version.zip: Default NVM content. Must be programmed via ComPair.
Page 22
EN 22 TPM15.5L LA Service Modes, Error Codes, and Fault Finding – ERROR: 034 013 000 000 000: Error code 13 was Caution: detected first and error code 34 is the last detected • Do not change these, without understanding the function of...
Alignments TPM15.5L LA EN 23 6. Alignments Index of this chapter: In case you have a colour analyser: 6.1 General Alignment Conditions • Measure with a calibrated (phosphor- independent) color 6.2 Hardware Alignments analyser (e.g. Minolta CA-210) in the centre of the screen.
EN 24 TPM15.5L LA Alignments which ICs to address. The presence / absence of these • Select the item and press <OK> on the RC. MT5561 ICs is made known by the option codes. Notes: Notes: • Only applicable to all related models that are “Smart TV •...
7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The TPM15.5L LA is a new chassis launched in LATAM in 7.2 Power Supply 2015. The whole range is covered by MT5561. 7.3 DC/DC Converters The major deltas versus its predecessor support NTSC;...
Page 26
EN 26 TPM15.5L LA Circuit Descriptions 7.1.3 SSB Cell Layout DC/DC HDMI MT5561 Headphone ANALOG I/O SERVICE CONNECTOR TUNER HDMI SPDIF 19760_200.eps Figure 7-1 SSB layout cells (top view) back to 2015-Aug-08 div.table...
The following displays can be distinguished: specifications! This part is available in the regular market. • CCFL/EEFL backlight: power panel is conventional IPB Consult the Philips Service web portal for the order codes of the • LED backlight: boards. - side-view LED without scanning: PSL power panel - side-view LED with scanning: PSLS power panel Important delta’s with the TPM15.5L LA classis platform are:...
Page 28
EN 28 TPM15.5L LA Circuit Descriptions 7.2.3 Connector overview Table 7-1 Connector overview Connector 32" 40" & 43" 48" Number CN9101 CN8604 CN9101 CN8601 CN9301 CN8101 Description to SSB to Panel to SSB to panel to SSB to panel VLED+...
Page 29
Circuit Descriptions TPM15.5L LA EN 29 Figure 7-3 DC/DC converters Front-End Analogue and DVB-T, DVB-C; HDMI ISDB-T reception Refer to figure 7-6 HDMI input configuration for the application. 7.4.1 Front-End Analogue part The Front-End for analogue tuner consist of the following key...
EN 30 TPM15.5L LA IC Data Sheets 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic”...
Page 31
IC Data Sheets TPM15.5L LA EN 31 Pinning Information MT5561LVNT 3 3 2 1 1 0 DVSS AO0P AOCKP AE1P DVSS CI_A3 GPIO0 AO0N AOCKN AE1N CI_D0 CI_REG# TCON4 TCON2 AO1P AO2P AO3P AE0P AE2P AE3P CI_A1 CI_MOVAL TCON5 TCON7...
Page 32
EN 32 TPM15.5L LA IC Data Sheets Pinning Information MT5561LVNT 1 1 1 1 1 2 1 1 3 1 1 4 1 1 5 1 1 6 1 1 7 1 1 8 1 1 9 2 2 0...
Page 33
IC Data Sheets TPM15.5L LA EN 33 Diagram 10-4-1 System Power B01, M5723B (IC U703) Block diagram Current Sense Current Sense M5723B HDRV HDRV VREF VREF 100mΩ 100mΩ 0.6V 0.6V CONTROL CONTROL LDRV LDRV 80mΩ 80mΩ UVLO UVLO Compensation Compensation...
Page 34
EN 34 TPM15.5L LA IC Data Sheets Diagram 10-4-4 Speaker Amp B04, TAS5729MDDCAR (IC U601) Block diagram TAS5729MD DR_CN DR_CP DRVSS DVDD AVDD ANA_REG1 ANA_REG2 DIG_REG DRVDD PVDD GVDD_REG Analog Supply Gate Drive Regulators Regulator Charge Pump Digital Supply Regulator...
Page 35
IC Data Sheets TPM15.5L LA EN 35 Diagram 10-4-9 TUNER B09, MxL661 (IC U104) Block diagram IF1 Out Channel RF Input Balun Filtering IF2 Out AGC1 Synth Gain Calibration Control Synth Synth AGC2 Crystal Voltage Reference Regulator CLK_OUT Pinning information...
Page 36
EN 36 TPM15.5L LA IC Data Sheets Diagram 10-4-16 DEMOD_Toshiba TC90537 B16, TC90537FG (IC U101) Block diagram Quadrature Interpolation ISIC Adaptive (unguarded IF input Filter Frequency Pilot detection phase pre/post echo interpolation or IQ input extraction suppression) Correction filter Tuner...
Circuit Diagrams and PWB Layouts TPM15.5L LA EN 52 10.4 B 715G6836 SSB 10-4-1 System Power System Power 3V3SB +5V_SW 4,5,6,7,8,9,10,11,12,13,14,15,16,17,18 +5VSB 90mil 12V_AMP 12V_AMP CN701 FB703 120R R738 +12V +12V +12V 4.7K 1/16W +5V_SW 9,10,11,12,15 +5V_SW Pre_12V Pre_12V 7,9,16...
Page 56
Circuit Diagrams and PWB Layouts TPM15.5L LA EN 56 10-4-5 Audio/Video IO/SPDIF VGA IN (V/T) 3,4,5,6,8,9,10,11,12,13,14,15,16,17,18 TP1109 U401C Analog Power AB19 AE24 AL0O 12V_AMP 12V_AMP R1204 C1203 VGA_R VGA_RIN AIN1_L_AADC AL0_ADAC AB21 AD25 AR0O 3,10 +12V +12V AIN1_R_AADC AR0_ADAC 2,3,4,5,7,8,9,10,11,12,13,14,15...
Page 57
Circuit Diagrams and PWB Layouts TPM15.5L LA EN 57 10-4-6 Video YPbPr/CVBS Video YPbPr/CVBS Merged Analog 3.3V Power Analog 1.2V Power 3,4,5,6,7,9,10,11,12,13,14,15,16,17,18 AVDD1V2 3V3SB 3V3SB 3,4,10,13,14 3V3SB 3V3SB U401D 3,13,15 AVDD1V2 AVDD1V2 R1301 VGA_SCL NC 33R 1/16W 5% 20mil 3,4,5,6,9,10,11,13,15,16,17,18...
Page 58
Circuit Diagrams and PWB Layouts TPM15.5L LA EN 58 10-4-7 SPDIF/Mute contorl SPDIF/ Mute contorl DVDD3V3 Audio Mute for SCART 10mil 3,4,5,6,7,8,10,11,12,13,14,15,16,17,18 AC OFF BAS316 +5VSB D602 DVDD3V3 3,4,5,6,8,10,11,13,15,16,17,18 DVDD3V3 DVDD3V3 R657 10K +-1% 1/16W +5VSB 3,7,16 +5VSB DC OFF...
Circuit Diagrams and PWB Layouts TPM15.5L LA EN 72 10.6 E 715G6316 Keyboard control panel 10-6-1 Direction switch Key function Resistance Voltage Center 2-5 short Menu Right 1-5 short 0.5V Left 4-5 short 0.81V Down 3-5 short VOL- 1.65V CN01...
Page 73
Circuit Diagrams and PWB Layouts TPM15.5L LA EN 73 10-6-2 Key board layout Layout Keyboard control panel (top side) SW01 Layout Keyboard control panel (bottom side) 2013-09-17 Keyboard control panel 715G6316 layout top/bottom 19610_546.eps back to 2015-Aug-08 div.table...
Page 74
Styling Sheets TPM15.5L LA EN 74 11. Styling Sheets 11.1 4900/5000 series 32" 4900/5000 series 32" 1053 1184 0095 0040 1054 0030 1057 1056 1184 0050 1050 Pos No. Description Remarks 0030 Bezel 0040 Rear cover 0050 Stand Assembly 0095...
Page 75
Styling Sheets TPM15.5L LA EN 75 11.2 5000 series 40" & 43" 5000 series 40" & 43" 1053 0040 1184 1057 1054 0030 1184 0095 0050 Pos No. Description Remarks 1050 0030 Bezel 0040 Rear cover 0050 Stand Assembly 0095...
Page 76
Styling Sheets TPM15.5L LA EN 76 11.3 5000 series 48" 5000 series 48" 1053 1184 0030 1054 0095 0040 1050 1184 1057 1056 0050 Pos No. Description Remarks 0030 Bezel 0040 Rear cover 0050 Stand Assembly 0095 V0 SHEET 1050...