Related Manuals for IXOM Medora GridBee GS-9
Summary of Contents for IXOM Medora GridBee GS-9
- Page 1 GridBee GS-9 Single Phase Operation & Maintenance Manual © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com O&M_GS9_10012_20200811...
-
Page 2: Table Of Contents
Customer Service About Ixom Ixom combines knowledge and experience from across the water quality spectrum to help solve real-world problems. Whether in Lakes, Stormwater Retention Ponds, Raw Drinking-Source Reservoirs, Water Treatment Plants, Potable Storage Tanks, or Wastewater Treatment Processes, Ixom equipment continues to be at the forefront as the #1 world leader for in-situ water body treatment. -
Page 3: Safety Instructions
Most accidents can be avoided by using common sense and concentration on the job being done. Carefully read safety information when you see any safety symbols. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1949_10036_20200528 O&M_GS9_10012_20200811 - 1... - Page 4 CAUTION: EDGES MAY BE SHARP AND CAUSE WARNING: ICE SURROUNDING MACHINE MAY LACERATION IF PROPER CARE IS NOT USED. NOT SUPPORT WEIGHT, KEEP CLEAR OF THIN ICE. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1949_10036_20200528 O&M_GS9_10012_20200811 - 2...
- Page 5 "OFF" position. The On/Off switch is to be by OSHA. used as the emergency stop. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1949_10036_20200528 O&M_GS9_10012_20200811 - 3...
-
Page 6: Package Contents
Sealant Tube Kellem Grip 75’ or 150’ 1 5/16” Hole Saw Cord Strain Relief Stainless Steel Chain Top of Tank Junction Box Cord Seal © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1926_10005_20200225 O&M_GS9_10012_20200811 - 4... -
Page 7: Machine Requirements
Motor Rating 60° C and 75° C Insulation - AWG Copper Wire Size Volts 0000 0.37 1190 1460 1780 2160 2630 3140 3770 © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1912_10008_20200225 O&M_GS9_10012_20200811 - 5... -
Page 8: Top Of Tank Junction Box
9. Kellem grip to support cable weight and to provide strain relief. NOT DESIGNED AS A SUBMERSIBLE PENETRATION. Alternative Method: Penetration through hatch neck © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1914_10007_20200618 O&M_GS9_10012_20200811 - 6... - Page 9 9. 3/4” NPT electrical conduit connection: conduit to juction box not included. *Not included in standard contents Contact Ixom for exchange. NOT DESIGNED AS A SUBMERSIBLE PENETRATION. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1914_10007_20200618 O&M_GS9_10012_20200811 - 7...
- Page 10 12. Eyebolt drilled through support I-beam to support kellem grip and retrieval chain. Eyebolt not included. NOT DESIGNED AS A SUBMERSIBLE PENETRATION. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1914_10007_20200618 O&M_GS9_10012_20200811 - 8...
-
Page 11: Placement
GFCI Protected Optional Mixer Junction Box & GS Mixer Source Power Control Panel Tank Penetration © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1916_10006_20200514 O&M_GS9_10012_20200811 - 9... - Page 12 The mixer should be immersed in water shortly after having been decontaminated to pre- vent corrosion caused by contact with chlorine or alternate disinfectant. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1916_10006_20200514 O&M_GS9_10012_20200811 - 10...
- Page 13 Water below the mixer will not be circulated. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 10496_20200522 O&M_GS9_10012_20200811 - 11...
-
Page 14: Final Checklist
Operation Check (While Mixer is Running) Reading / Observation Source Voltage Reading Amperage Reading Normal Operating Range: (7.5 amps to 10.0 amps) Flow Check Auditory Flow Check Visual © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1931_10003_20200323 O&M_GS9_10012_20200811 - 12... -
Page 15: Troubleshooting
Mixer Not Operating but Circuit Loose or Loss of Connection Breaker not tripped Amperage Reading Mixer Making Loud Noise Motor Bearing Failure Ohm Reading Impeller Misalignment © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1930_10004_20200811 O&M_GS9_10012_20200811 - 13... - Page 16 The four screws that were removed in Step 2 should be put back in Figure 2: Impeller View place at this point as well. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1930_10004_20200811 O&M_GS9_10012_20200811 - 14...
-
Page 17: Technical Specifications
150 ft unit - Box 1 of 2: 44x16x12 in. / 127 lbs, Box 2: of 2: 17x13x8 in. / 41 lbs: Total shipment weight: 168 lbs Certifications - Ixom's potable water products are certified to ANSI/NSF Standard 61 and 372 for lead-free content. -
Page 18: Warranty
Where labor is included, in lieu of sending a factory service crew to the site for minor repairs, Ixom may choose to send the replacement parts to the owner postage-paid and may pay the owner a reasonable labor allowance, as determined solely by Ixom, to install the parts. -
Page 19: Customer Service
OSHA to perform the necessary work to install or remove SolarBee and GridBee equipment, and are knowlegeable in the regulations and standards of OSHA. If you feel the need to service your SolarBee or GridBee circulation equipment, please contact Ixom's Customer Service Department at: +1 866 437 8076 ©...
Need help?
Do you have a question about the Medora GridBee GS-9 and is the answer not in the manual?
Questions and answers