Subscribe to Our Youtube Channel
Related Manuals for IXOM Medora GridBee GS-12-Air
Summary of Contents for IXOM Medora GridBee GS-12-Air
- Page 1 GridBee GS-12-Air 120V Owner's Manual © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com O&M_GS_12_Air_120V_10389_20210129...
-
Page 2: Table Of Contents
Customer Service About Ixom Ixom combines knowledge and experience from across the water quality spectrum to help solve real-world problems. Whether in Lakes, Stormwater Retention Ponds, Raw Drinking-Source Reservoirs, Water Treatment Plants, Potable Storage Tanks, or Wastewater Treatment Processes, Ixom equipment continues to be at the forefront as the #1 world leader for in-situ water body treatment. - Page 3 Most accidents can be avoided by using common sense and concentration on the job being done. Carefully read safety information when you see any safety symbols. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1949_10036_20200528 O&M_GS_12_Air_120V_10389_20210129 - 1...
- Page 4 CAUTION: EDGES MAY BE SHARP AND CAUSE WARNING: ICE SURROUNDING MACHINE MAY LACERATION IF PROPER CARE IS NOT USED. NOT SUPPORT WEIGHT, KEEP CLEAR OF THIN ICE. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1949_10036_20200528 O&M_GS_12_Air_120V_10389_20210129 - 2...
- Page 5 "OFF" position. The On/Off switch is to be by OSHA. used as the emergency stop. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1949_10036_20200528 O&M_GS_12_Air_120V_10389_20210129 - 3...
-
Page 6: Package Contents
Tank-roof junction box (Optional Accessory Item included with Interior Hose Exterior Hose Heated hose, mounts onto (Optional Accessory Item) (Optional Accessory Item) through-tank fitting, ) © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 10401_20200226 O&M_GS_12_Air_120V_10389_20210129 - 4... - Page 7 GFCI Circuit Breaker lowest point of the hose. Figure 1: Typical GS Placement FULL RATING LOCKED LOAD ROTOR AMPS VOLTS S.F. WATTS AMPS 0.655 © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 10403_20200226 O&M_GS_12_Air_120V_10389_20210129 - 5...
-
Page 8: Installation And Operation
ZONE DIRECT UPLIFT FLOW INDUCED FLOW PATTERN INDUCED FLOW PATTERN WATER PULLED HORIZONTAL TOWARD INTAKE WATER PULLED HORIZONTAL TOWARD INTAKE GS-12-Air Flow Pattern © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 10390_20200529 O&M_GS_12_Air_120V_10389_20210129 - 6... - Page 9 HDPE WASHER SEAL OUTSIDE TANK INSIDE TANK HDPE WASHER SEAL BRASS NUT Penetration Fitting 316SS CORD BOLT SOLARBEE: © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 2.250" E OD: 1.250" 10390_20200529 O&M_GS_12_Air_120V_10389_20210129 - 7 1.250"...
- Page 10 Secure hose using stainless steel zip ties, magnet pads, or adhesive pads attaching hose to structure at a recommended spacing of every 4’. Best attaching method depends on specific tanks. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 10390_20200529 O&M_GS_12_Air_120V_10389_20210129 - 8...
- Page 11 MIXER, BE SURE THAT YOU AND OTHERS ARE CLEAR OF THE +1 866.437.8076 • +1 701.225.4495 • Fax +1 701.225.0002 www.medoraco.com ELECTRIC CORD AND CHAIN TO AVOID ENTANGLEMENT! © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 10390_20200529 O&M_GS_12_Air_120V_10389_20210129 - 9...
-
Page 12: Placement
Water below the mixer will not be circulated. © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 10496_20200522 O&M_GS_12_Air_120V_10389_20210129 - 10... -
Page 13: Final Checklist
Operation Check (While Mixer is Running) Reading / Observation Source Voltage Reading Amperage Reading Normal Operating Range: (7.5 amps to 10.0 amps) Flow Check Auditory Flow Check Visual © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 1931_10003_20200323 O&M_GS_12_Air_120V_10389_20210129 - 11... -
Page 14: Troubleshooting
Loose or Loss of Connection Amperage Reading Circuit Breaker not tripped Ohm Reading Compressor Making Loud Noise Motor Bearing Failure Compressor Gasket Failure © 2020 Ixom | www.medoraco.com | 866 - 437 - 8076 | info@medoraco.com 10409_20200303 O&M_GS_12_Air_120V_10389_20210129 - 12... - Page 15 Some gases can explode when combined with air. Please verify that you have proper ventilation to prevent a buildup of methane gas or other gases in the headspace above the explosion limit. Certifications - Ixom's potable water products are certified to ANSI/NSF Standard 61, and 372 for lead-free content. Learn more at: www.medoraco.com/std61 Maintenance / Warranty - Limited maintenance.
-
Page 16: Warranty
Where labor is included, in lieu of sending a factory service crew to the site for minor repairs, Ixom may choose to send the replacement parts to the owner postage-paid and may pay the owner a reasonable labor allowance, as determined solely by Ixom, to install the parts. -
Page 17: Customer Service
OSHA to perform the necessary work to install or remove SolarBee and GridBee equipment, and are knowledgeable in the regulations and standards of OSHA. If you feel the need to service your SolarBee or GridBee circulation equipment, please contact Ixom's Customer Service Department at: +1 866 437 8076 ©...
Need help?
Do you have a question about the Medora GridBee GS-12-Air and is the answer not in the manual?
Questions and answers