Delfield FlexiWell Shelleyglas KFW-1-NU Installation, Operation And Maintenance Manual
Hide thumbs
Also See for FlexiWell Shelleyglas KFW-1-NU:
Table of Contents
Advertisement
FlexiWell®
Serving Lines
Installation, Operation and Maintenance Manual
Original Document
Part Number: 9291544 07/20
Fresh Solutions, Fit For You
Shelleyglas
by Del eld
Shelleysteel
by Del eld
Read this instruction before operating this equipment.
Shelleyglas
Shelleybasic
by Del eld
Shelleysteel
Shelleyglas
TM
by Del eld
Shelleysteel
TM
Shelleyspeed
Caution
,
Sh
Sh
TM
TM
by Del eld
Sh
TM
TM
by Del eld
TM
Sh
by Del eld
TM
by Del eld
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Delfield FlexiWell Shelleyglas KFW-1-NU
Summary of Contents for Delfield FlexiWell Shelleyglas KFW-1-NU
- Page 1 Fresh Solutions, Fit For You Shelleyglas Shelleybasic by Del eld by Del eld FlexiWell® Shelleyglas Shelleysteel Shelleyglas by Del eld by Del eld by Del eld Serving Lines Shelleysteel Shelleysteel by Del eld by Del eld Installation, Operation and Maintenance Manual Shelleyspeed by Del eld Caution...
-
Page 2: Table Of Contents
Table of Contents Section 1 General Information Model Numbers ........................5 Serial Number Location ..................... 5 Warranty Information ......................5 Regulatory Certifications ....................5 Section 2 Specifications General Specifications ....................... 6 Weight ..........................7 Dimensions ......................... 8 Clearance Requirements ....................11 Electrical Service ......................11 Voltage .............................. - Page 3 Table of Contents (continued) THIS PAGE INTENTIONALLY LEFT BLANK Part Number: 9291544 07/20...
- Page 4 Safety Notices Warning This product contains chemicals known to the State Warning of California to cause cancer and/or birth defects or Read this manual thoroughly before operating, installing other reproductive harm. Operation, installation, and or performing maintenance on the equipment. Failure servicing of this product could expose you to airborne to follow instructions in this manual can cause property particles of glasswool or ceramic fibers, crystalline...
-
Page 5: General Information
SFW-2-NU • Verify warranty information, SFW-3-NU Shelleysteel® SFW-4-NU • View and download a copy of your warranty, SFW-5-NU at www.delfield.com/warranty SFW-6-NU FlexiWell™ Regulatory Certifications Hot and Cold Combination Serving Counters All models are certified by: 1042G 1042H • National Sanitation Foundation (NSF) 1042I Shelleysteel®... -
Page 6: Specifications
Section 2 Specifications GENERAL SPECIFICATIONS CHART FlexiWell™ Mobile Hot and Cold Combo Serving Counters Shelleyglas® Shelleysteel® 12” x20” Hot Electrical Amps Nema Plug System Heat of R290 Pan Capac- Capacity Rejection Charge (BTU) Amount KFW-1-NU SFW-1-NU 120/208-240 14-20P 150g KFW-2-NU SFW-2-NU 120/208-240 12.5... -
Page 7: Weight
Section 2 Specifications WEIGHT FlexiWell™ Mobile Hot and Cold Combo Serving Counters Shelleyglas® Shelleysteel® Weight KFW-1-NU SFW-1-NU 300lbs (136kg) KFW-2-NU SFW-2-NU 380lbs (172kg) KFW-3-NU SFW-3-NU 460lbs (209kg) KFW-4-NU SFW-4-NU 550lbs (249kg) KFW-5-NU SFW-5-NU 660lbs (299kg) KFW-6-NU SFW-6-NU 720lbs (327kg) FlexiWell™ Hot and Cold Combo Serving Counters Shelleysteel®... -
Page 8: Dimensions
Specifications Section 2 DIMENSIONS FlexiWell™ Mobile Hot and Cold Combo Serving Counters Model Length Depth Height KFW-1-NU 28” (71cm) SFW-1-NU 26” (66cm) KFW-2-NU 50” (127cm) SFW-2-NU 45” (114cm) KFW-3-NU 60” (152cm) SFW-3-NU 55” (140cm) 30” 36” KFW-4-NU 78” (76cm) (91cm) (198cm) SFW-4-NU 75”... - Page 9 Section 2 Specifications Dimensions Continued N8600 Series EcoMark 1042 Series Part Number: 9291544 07/20...
- Page 10 Specifications Section 2 SFW ShelleySteel Series KFW ShelleyGlas Series Part Number: 9291544 07/20...
-
Page 11: Clearance Requirements
Section 2 Specifications Clearance Requirements Clearance Dimensions Model Bottom Sides Back DANGER KFW Series 12” 0” 0” 0” The flooring under the appliance must be made of a SFW Series 12” 0” 0” 0” noncombustible material. EcoMark 12” 0” 0” 0”... -
Page 12: Installation
Section 3 Installation The location selected for the equipment must meet the DANGER following criteria. If any of these criteria are not met, select Installation must comply with all applicable fire and another location. health codes in your jurisdiction. • Units are intended for indoor use only. -
Page 13: Drain Connections
Section 3 Installation Drain Connections Leveling Warning After the cabinet has been placed in the desired location, cabinets with legs must be leveled. Level units from front to Moisture collecting from improper drainage can create a back and from side to side. Leveling will insure proper door slippery surface on the floor and a hazard to employees. -
Page 14: Self-Contained Flexiwell Drop-In Cabinet Dimentions
Installation Section 3 SELF-CONTAINED FLEXIWELL DROP-IN UNITS N8600-FWP For any non-standard installation consult the factory. 1. Cabinet interior minimum dimensions: Dimension N8618-FWP N8635-FWP N8652-FWP 29.75"/76cm 42.5"/108cm 55.25"/140cm 29"/74cm 29"/74cm 29"/74cm 28"/71cm 28"/71cm 28"/71cm 17"/43cm 34"/86cm 51"/130cm 25"/64cm 25"/64cm 25"/64cm 4.75”/12cm Min. - Page 15 Section 3 Installation NOTE: CONT: the condensing unit’s finned coil. Any restriction to the proper air flow will void the compressor warranty. • Louver measures 20.00” x 25.00” (51cm x 64cm). • Louver Cutout Size is 18.50” x 22.50” (47cm x 57cm) (typical installation).
- Page 16 Installation Section 3 THIS PAGE INTENTIONALLY LEFT BLANK Part Number: 9291544 07/20...
-
Page 17: Operation
Section 4 Operation Caution DANGER Units with pans should be operated with pans in place. The on-site supervisor is responsible for ensuring that Operating the unit without all pans in place will lower operators are made aware of the inherent dangers of operating this equipment. -
Page 18: Heated And Refrigerated Combo Counter Operation
Operation Section 4 Heated and Refrigerated Combo Counter Operation Operation DANGER HEATED SECTION OPERATION Steam can cause serious burns. Always use some type of protective covering on your hands and arms when DANGER removing lids from the unit. Lift the lid in a way that will direct escaping steam away from your face and body. -
Page 19: Erc112 Temperature Control & Display
Section 4 Operation ERC112 TEMPERATURE CONTROL & DISPLAY Operation / Indication Notice Status Displayed Comments Temperature displayed is for refrigeration set point Normal (°C) Temp. Unit depends on purposes only. Display does not reflect air or product [°C] setting (parameters in temps in unit. -
Page 20: Changing Display From Fahrenheit To Celsius On Erc112 Control
NOTE: For steps 7 and 8, display will return back to normal display after 30 seconds of inactivity. Look for more! Delfield Bulletin SB_0065 goes into further step-by- step instructions on how to adjust an ERC control from Fahrenheit to Celsius with visuals each step. - Page 21 Section 4 Operation THIS PAGE INTENTIONALLY LEFT BLANK Part Number: 9291544 07/20...
-
Page 22: Maintenance
Section 5 Maintenance Warning DANGER Never use a high-pressure water jet for cleaning or hose It is the responsibility of the equipment owner to down or flood interior or exterior of units with water. perform a personal protective equipment hazard assessment to ensure adequate protection during This will void the warranty. -
Page 23: Interior Cleaning
Section 5 Maintenance INTERIOR CLEANING steel cleaners in attempt to restore the steel. The interior can be cleaned using soap and warm water. If Fiberglass can be polished to eliminate water spotting, this isn’t sufficient, try ammonia and water or a nonabrasive fingerprints and bring out the color of the fiberglass. - Page 24 DELFIELD 980 SOUTH ISABELLA ROAD, MOUNT PLEASANT, MI 48858 800-733-8821 WWW.DELFIELD.COM ©2019 Welbilt Inc. except where explicitly stated otherwise. All rights reserved. Part Number: 9291544 07/20...
Need help?
Do you have a question about the FlexiWell Shelleyglas KFW-1-NU and is the answer not in the manual?
Questions and answers