Related Manuals for VOLTA VM4
Summary of Contents for VOLTA VM4
- Page 1 TRICYCLE USER MANUAL Please, read this manual thoroughly before using your tricycle.
-
Page 2: Preface
If, there is any problem with your tricycle, never use any part other than originals provided by an authorized service. This manual is prepared for electric tricycles of Volta Motor. Images and technical specifications in the manual might not be identical with your tricycle. - Page 3 - These headings are written for preventing fatal accidents and personal in- WARNING juries. ATTENTION -These headings are written for preventing you from severe personal inju- ries and mechanical damages CAUTION - Laws restrict driving electric tricycles with age and driver's license. Drivers with a driver's license in any class can safely use the electric tricycle.
-
Page 4: Table Of Contents
3. Charging the Battery ..................13 4. Driving Instructions ..................15 5. Instructions for a Safe Drive ................18 6. Maintenance and Care ..................21 7. Storage Guide ..................26 8. Troubleshooting ....................27 9. Technical Specifications ..............28 10. Authorized Service ·············································································29 11. Guarantee ·······························································································30 www.volta.com.tr... -
Page 5: Devices And Accessories
1. DEVICES AND ACCESSORIES 1- Headlight 8- Signals 2- Mirror 9- Front Wheel 3- Brake Handle 10- Wind Spoiler 4- Display Panel 11- Motor 5- Starter 12- Rear Wheels 6- Seat 13- Compensating Wheel 7- Rear Stop Light and Signals www.volta.com.tr... - Page 6 1. DEVICES AND ACCESSORIES Vm4+ 8- Signals 1- Headlight 2- Mirror 9- Front Wheel 3- Display Panel 10- Wind Spoiler 4- Brake Handle 11- Motor 5- Starter 12- Rear Wheels 6- Front seat 13- Rear Stop Light and Signals 14- Rear Bucket 7- Backseat www.volta.com.tr...
- Page 7 2- Front Signals 9- Backrest 3- Front Bucket 10- Front Seat 4- Disk Brake 11- Backseat 5- Front Wheel 12- Backrest of the Backseat 6- Display Panel 13- Rear Bucket 14- Rear Stop Light and Signals 7- Right-Left mirror www.volta.com.tr...
- Page 8 9- Hand Brake 3- Throttle Lever 10- Stiffener 4- Seat 11- Motor 5- Backrest 12- Rear Wheels 6- Safety Deposit Box 13- Stop Light and Signals 7- Front Wheel - Please, do not pull the stiffener while driving the tricycle. WARNING www.volta.com.tr...
-
Page 9: Displays
2. DISPLAYS vm4 - vm4+ 1- Main and dipped beam setting 5- Signal button“◄” indicates left button turn, “►” indicates right turn. 2- Mirror 6- Horn 3- Display Panel 7- Forward backward button If, you turn the throttle lever counter-... - Page 10 DISPLAY INDICATORS GEAR Headlight Remaining Brake Fault Gear Power :- All parts listed in the manual are for reference purposes. Manufacturer firm can WARNING change them without any notification. - Do not use your horn in forbidden zones. ATTENTION www.volta.com.tr...
- Page 11 “►” indicates right turn, DISPLAY INDICATORS Remaining Ambient Headlight Power Temperature - All parts listed in the manual are for reference purposes. Manufacturer firm can WARNING change them without any notification. - Do not use your horn in forbidden zones. ATTENTION www.volta.com.tr...
- Page 12 Protect your tricycle from direct sunlight. ABS plastic parts and paint of your tricycle exposed to direct sunlight react to high temperatures and UV beams. Your tricycle turns color. Protect your tricycle from direct sunlight. Do not expose it to sunlight when you do not use it. www.volta.com.tr...
-
Page 13: Charging The Battery
1-2 hours, you will have a better charge. When, charge is completely over, remove the charger. In addition, remove the plug from mains socket when you do not use the charger. This will extend the life of your product. www.volta.com.tr... - Page 14 - A charger damaged by voltage differences in your electrical installation might harm ATTENTION your tricycle. Such problems are not considered within the guarantee. Therefore, please remove the charger from tricycle if it is not charged. www.volta.com.tr...
-
Page 15: Driving Instructions
4.2.3 Put your right hand on throttle lever. Turn it slowly for avoiding surge. Tricycle will gain speed as you turn the throttle lever. Remove your hand from the throttle lever for stopping you tricycle and pull brake lever slowly to you. If, you pull brake lever, throttle will be automatically stopped. www.volta.com.tr... - Page 16 Do not use brakes for long. If, you pull the brake for long, brake sets overheat and lose their performance. This extends your brak- ing distance. Please, release the throttle lever while pulling brake levers www.volta.com.tr...
- Page 17 The path taken by the outer tire while taking a corner is longer than the inner tire. NOTE : Oil in differential should be checked and replaced in 180-day main- tenance period. Permanent damage might arise if it is not replaced. www.volta.com.tr...
-
Page 18: Instructions For A Safe Drive
If you exceed maximum bearing capacity, this might cause permanent damages on the tricycle. 1.2 Rainy Weather 1.2.1 Show more attention on wet surfaces. 1.2.2 Brake earlier considering that your stopping distance will extend on wet surfaces. www.volta.com.tr... - Page 19 - Check whether the brake lever and brake pedal are flexible enough. - Brake distance affects your stopping range under rain. 1.5 Tires 1.5.1 For your safety, care your tires and check tire pressure in addition to periodical maintenances www.volta.com.tr...
- Page 20 Overpressure causes driving roughly and feeling road impacts more, decreases contact with road and loss of control and skids. Furthermore, overpressure does not increase load bearing capacity. www.volta.com.tr...
-
Page 21: Maintenance And Care
6.2 Charger 6.2.1 Only use the original charger designed for your tricycle. 6.2.2 Your tricycle must be OFF while being charged. 6.2.3 Do not tilt the tricycle while charging. www.volta.com.tr... - Page 22 6.3.4 Always use standard cleaning materials while cleaning dyed plastic parts. Dry with fabric after cleaning. - Do not use pressurized water for washing your tricycle; this might cause penetration of water in some parts of your tricycle. The leaking parts may WARNING: lose performance and break down. www.volta.com.tr...
- Page 23 There is about 10-20 mm empty space between A-B positions. 6.4.2.2 . If, empty space is not 10-20 mm, this means the brake fluid is low. Remove the C and D bolts and add brake fluid to the opened section. www.volta.com.tr...
- Page 24 60 Days 180 Days Tire pressure Horn Bulbs Charge device and batteries Brake Front fork Gas lever and rotating parts Brake system - Tricycles which are not periodically maintained (once in every 4 months) will be out of guarantee. www.volta.com.tr...
- Page 25 While handling your tricycle, make sure that the starter and the fuse are OFF. Also, remove one of the battery connections. Tighten the front and rear brakes. In order to prevent any external damage on your tricycle, you can carry it safely by coating cardboard on a metal cage. www.volta.com.tr...
-
Page 26: Storage Guide
Drive it for the first time in an area closed to traffic. Hit the roads after making sure that all parts of your electric tricycle work properly and at full performance. Loading • Do not carry inappropriate loads on your electric tricycle. Otherwise, related parts will be damaged www.volta.com.tr... -
Page 27: Troubleshooting
1. Charge your batteries 1. Low battery. Electrical tricycle fully. 2. Faulty battery decelerates 2. Replace your batteries NOTE If, any fault arises, please do not try to repair it on yourself. Please, contact the closest authorized service. www.volta.com.tr... -
Page 28: Technical Specifications
9. TECHNICAL SPECIFICATIONS VM4+ Parameters Properties (Length x Width 1570/710/1080 mm 1960/740/1080 mm 2270/970/1110 mm 3070/1280/1412 mm Dimensions x Height) [cm] Weight Birim (kg) 112 kg 130 kg 219 kg 345 kg Maximum Speed 25 km/h 25 km/h 35 km/h... -
Page 29: Authorized Service
10. AUTHORIZED SERVICE You can see locations of our authorized services by visiting www.volta.com.tr MANUFACTURER Volta Motor Sanayi A.Ş. Merkez Mh. Yıldıztepe Cad. NO:10 Gümüşova OSB Gümüşova / DÜZCE Tel : 0850 222 28 65 - 0380 731 25 25... -
Page 30: Guarantee
+90 380 731 25 25 +90 850 222 28 65 +90 380 731 25 35 +90 380 731 25 35 OF THE PRODUCT TYPE TRICYCLES BRAND Volta MODEL CHASIS NUMBER DELIVERY DATE and PLACE MAXIMUM REPAIR DURATION 45 BUSINESS DAYS WARRANTY PERIOD 2 YEARS... - Page 31 - Problems arising adding any parts on the tricycle, which are not manufactured/sold by Volta Motor, - Penetration of water in parts after the tricycle passes in deep water higher than the rear wheel shaft or it is washed by pressurized washing machines, - Abrasion, wear and tear of axle, differential, transmission, motor, rim, etc.
- Page 32 DÜZCE GEBZE Merkez Mh. Yıldıztepe Cad. No:10 Tübitak MAM Teknoloji Serbest Bölgesi +90 850 222 28 65 0380 731 25 25 info@volta.com.tr info@volta.com.tr...