Table of Contents
Advertisement
WARNING AND SAFETY INSTRUCTIONS
IMPORTANT SAFETY INSTRUCTIONS
READ AND FOLLOW ALL INSTRUCTIONS
SAVE THESE INSTRUCTIONS
Turbotemp 125 High Performance Heater
Congratulations on your purchase of a Turbotemp 125 high performance heating system. Proper
installation and service of your new heating system and correct chemical maintenance of the
water will ensure years of enjoyment. The Turbotemp 125 heater is a compact, lightweight,
ef cient, induced-draft, gas red high performance pool and spa heater that can be directly
connected to schedule 40 PVC pipe. The heater also comes equipped with the Pentair
multifunction temperature controller which shows, at a glance, the proper functioning of the
heater. All Turbotemp 125 heaters are designed with a direct ignition device, HSI (hot-surface
ignition), which eliminates the need for a standing pilot. The Turbotemp 125 heater requires an
external power source (240 VAC 50 Hz) to operate.
SPECIAL INSTRUCTIONS TO OWNER: Retain this manual for future reference. This
instruction manual provides operating instructions, installation and service information for the
Turbotemp125 high performance heater. The information in this manual applies to all Turbotemp
125 heater models. READ AND REVIEW THIS MANUAL COMPLETELY, it is very important
that the owner/installer read and understand the section covering installation instructions, and
recognize the local and state codes before installing the Turbotemp 125 heater. Its use will
reduce service calls and chance of injury and will lengthen product life. History and experience
has shown that most heater damage is caused by improper installation practices.
IMPORTANT NOTICES
For the installer and operator of the Turbotemp pool and spa heater: The manufacturer's
warranty may be void if, for any reason, the heater is improperly installed and/or operated. Be
sure to follow the instructions set forth in this manual. If you need more information or if you
have any questions regarding to this pool heater, please contact Waterco Limited - Australia
02 98988600.
WARRANTY INFORMATION
The Turbotemp 125 pool heater is sold with a limited factory warranty. Speci c details are
described on the warranty registration card which is included with the product.
Waterco Limited high standards of excellence include a policy of continuous product improvement
resulting in your state-of-the-art heater. We reserve the right to make improvements which
change the speci cations of the heater without incurring an obligation to update the current
heater equipment.
These heaters are designed for the heating of chlorine, bromine or salt system swimming pools
and spas or in non-stationary installations, and should never be employed for use as space
heating boilers or general purpose water heaters. The manufacturer's warranty may be void
if, for any reason, the heater is improperly installed and/or operated. Be sure to follow the
instructions set forth in this manual.
!
CAUTION
OPERATING THIS HEATER CONTINUOUSLY AT WATER TEMPERATURE BELOW 20°
C (68° F). WILL CAUSE HARMFUL CONDENSATION AND WILL DAMAGE THE HEATER
AND VOID THE WARRANTY. Do not use the heater to protect pools or spas from
freezing if the final maintenance temperature desired is below 20° C (68° F), as this will
cause condensation related problems.
CODE REQUIREMENTS
Installation must be in accordance with the following:
• Manufacturer's Installation Instructions
• AS/NZS 5601.1 for Gas Installations
• Local Gas Fitting Regulations,
• Municipal Building Codes,
• S.A.A. Wiring Code,
• Local Electrical Regulations
• Any other statutory regulations
CONSUMER INFORMATION AND SAFETY
!
WARNING
Should overheating occur or the gas supply fail to shut off, turn off the manual gas
control valve to the heater. Do not use this heater if any part has been under water.
Immediately call a qualified service technician to inspect the heater and to replace any
part of control system and gas control which has been under water.
!
DANGER
CARBON MONOXIDE GAS IS DEADLY – Exhaust from this pool heater contains toxic
levels of carbon monoxide, a dangerous, poisonous gas you cannot see or smell.
Turbotemp 125 Pool and Spa Heater Installation and User's Guide
I pg 04
Advertisement
Table of Contents
Troubleshooting
