Related Manuals for ILMOR ONE-TOUCH
Summary of Contents for ILMOR ONE-TOUCH
- Page 1 June 2019 OWNER’S MANUAL ONE-TOUCH CONTROL SYSTEM · 844-GO-ILMOR (464-5667) www.ilmor.com...
- Page 3 Ilmor Marine, LLC (Ilmor) is pleased to welcome you to boating ILMOR ONE-TOUCH CONTROL SYSTEM enjoyment available only through use of the Ilmor line of products. Ilmor is a recognized leader in the marine industry, having originated through championship-caliber, high-performance engines.
-
Page 4: Table Of Contents
SAFETY INSTRUCTIONS ................................6 DANGERS, WARNINGS, CAUTIONS, AND NOTICES ....................................7 GENERAL SAFETY CONCERNS ..............................7 SAFETY NOTICES ..................................8 One-Touch Joystick Operation ..............................8 Electronic Helm Operation ................................9 FUNCTIONS AND DESCRIPTIONS ........................... 10 TWIN ENGINE THROTTLE CONTROL ............................10 MERLIN DISPLAY ..................................10 ONE-TOUCH JOYSTICK ................................10 POSITION ASSIST .................................. - Page 5 Control Panel .....................................13 MERLIN DISPLAY ..................................14 Propulsion Screen ..................................14 Engine Information Screens ..............................14 Main Menu ....................................15 ONE-TOUCH JOYSTICK ................................17 Engage One-Touch Joystick ..............................17 Operate One-Touch Joystick ..............................18 Disengage One-Touch Joystick ..............................19 POSITION ASSIST ..................................19 Anchor Assist .....................................19 Location Assist ..................................20 Heading Assist ...................................21...
- Page 6 Every 2 Years of Operation (Regardless of Operation Hours) ..............................23 Every 1,000 Hours of Operation ..............................23 TROUBLESHOOTING ..............................24 TROUBLESHOOTING CHART ..............................24 FAILURES AND CORRECTIVE ACTIONS ..........................25 Electronic Helm Failure ................................25 Engine Stops During One-Touch Joystick Operation ........................26 · 844-GO-ILMOR (464-5667) www.ilmor.com...
-
Page 7: Introduction
The Owner’s Manual contains information critical for safe operation and maintenance of your marine products purchased from Ilmor that is required to activate and keep the limited warranty statement in effect throughout the applicable warranty period. -
Page 8: Safety
All requirements of the Federal Occupational Safety and Health (OSH) Act must be met when Ilmor products are operated in areas that are under the jurisdiction of the United States of America. Ilmor products operated in other countries must be installed, operated, and serviced in compliance with any and all applicable safety requirements of that country. -
Page 9: Dangers, Warnings, Cautions, And Notices
When service and maintenance are required, return the boat to an authorized Ilmor service center. Failure to follow procedures outlined in this Owner’s Manual or through published technical information at may void the warranty. -
Page 10: Safety Notices
SAFETY NOTICES One-Touch Joystick Operation WARNING! Always use genuine Ilmor replacement parts. WARNING! Operating the joystick may become difficult when The electrical and ignition components have been designed to cruising under stormy weather. -
Page 11: Electronic Helm Operation
CAUTION! Be sure to stop the engine before you inspect the sure that the drive moves in the intended direction. joystick control system components. · 844-GO-ILMOR (464-5667) www.ilmor.com... -
Page 12: Functions And Descriptions
Twin engine throttle control ONE-TOUCH JOYSTICK The One-Touch joystick allows for detailed progressive-throttle operation of the drives and steering in areas requiring slow and close- quarter maneuvering. It consists of a stick controller and a top and bottom semicircle shaped button. -
Page 13: Position Assist
Tachometer Display and Gauge Toggle Position assist maximizes the smooth shifting hydraulic clutch of the Ilmor One-Drive by pairing it with precise Global Positioning System (GPS) correction to hold a fixed position while waiting on a draw bridge, fueling, etc. -
Page 14: Operation
Perform the following inspections before starting the engine and using the joystick control system. Carefully read the Ilmor engine and boat manufacturer’s Owner’s Manual operation section for additional information and details. This is a critical component of safe and enjoyable boating. -
Page 15: Check Engine And Stern Drive
CAUTION! The Neutral (NTRL) button is normally used by Service Center Technicians while servicing the engines. Ilmor does not recommend use by the owner/operator. If the NTRL button is used, DO NOT rev the engines beyond 3,000 RPM. Failure to do so could result in damage to equipment not covered under manufacturer’s warranty. -
Page 16: Merlin Display
OPERATION Voltage • CAUTION! Ilmor does not recommend operating the vessel • Drive Trim while drives are in trailer position. If it is attempted, an alarm Throttle Demand • will indicate on the Merlin display screen requesting drives are Rudder Position •... -
Page 17: Main Menu
CAUTION! The operator accepts all liabilities associated with automatic drive trim control. Ensure vessel is at proper Press the Ilmor Logo (Home) button to go to the main menu. It displays the following functions: water depth before engaging Planing Assist. Failure to do so could result in accidents that could cause injury or damage to •... - Page 18 A red engine warning icon will animate and flash in the bottom right corner of the display to indicate an issue with the drives or One-Touch joystick. Many issues are simple to fix, such as drive trim too high for joystick operation or low fuel levels.
-
Page 19: One-Touch Joystick
Contact your nearest Ilmor service center or call 844-GO-ILMOR for further information. 4. The One-Touch joystick screen will appear on the Merlin display and the joystick icon will illuminate. The One-Touch joystick screen displays a top-down view graphic of the vessel to assist the operator during joystick operation. -
Page 20: Operate One-Touch Joystick
OPERATION One-Touch Joystick screen Joystick direction control CAUTION! Practice operating the One-Touch joystick in an open area prior to first use in a congested area. Failure to do so could result in collision with other vessels or obstacles and could cause injury or damage to equipment. -
Page 21: Disengage One-Touch Joystick
• The propellers rotate automatically, even if not noticeably. • The propellers can injure someone in the water, anywhere around the boat. 4. Press the front button to quickly return to the One-Touch joystick • The boat may suddenly move in any direction. -
Page 22: Location Assist
1. To engage Location Assist, ensure throttle levers are in neutral 7. If the vessel is within 10 feet of the initial anchor point, a blue (see twin engine throttle control section) and One-Touch joystick is screen frame will flash. GOOD will display under CONTROL engaged (see One-Touch joystick section). -
Page 23: Heading Assist
ANCHOR ASSIST screen. Heading Assist 1. To engage Heading Assist, ensure throttle levers are in neutral (see twin engine throttle control section) and One-Touch joystick is engaged (see One-Touch Joystick section). 2. On the Merlin display, go to the home screen. -
Page 24: Tilt-Adjust Steering (Optional)
Center Steering Wheel If steering wheel is not centered, do the following: 1. Ensure throttle levers are in neutral and One-Touch Joystick is engaged (see One-Touch Joystick section in this chapter). 2. Press SEL Button on the twin engine throttle control panel (See Twin Engine Throttle Control section in this chapter). -
Page 25: Maintenance
• Check One-Touch Joystick Operation Run engine for 3-5 minutes, and slowly turn the steering wheel port • Check that the top button opens the One-Touch Joystick screen • to starboard repeatedly during this time. when pressed. Shut down engine and remove the stop lanyard to prevent •... -
Page 26: Troubleshooting
• Operate the engines in the both sides. A button on the joystick. • Joystick failure. • See authorized Ilmor service center. • Joystick lamp and internal connection failure. • See authorized Ilmor service center. The beep does not sound when you press the A button. • Display buzzer and internal connection failure. -
Page 27: Failures And Corrective Actions
Navigate the vessel by operating turn backward and the opposite stern drive forward. the joystick (see operate One-Touch Joystick section in the operation chapter). 4. If the electronic helm and joystick are unresponsive, use the throttle/shift levers to maneuver the vessel to safety. -
Page 28: Engine Stops During One-Touch Joystick Operation
TROUBLESHOOTING Engine Stops During One-Touch Joystick Operation When the engine in one side stops due to any failures during the joystick control system operation, the buzzer sounds and the alarm screen is displayed. In this case, you can operate the boat in forward and reverse directions. - Page 29 NAUTICAL NOTES...
- Page 30 NAUTICAL NOTES...
- Page 31 NAUTICAL NOTES...
- Page 32 NAUTICAL NOTES...
- Page 33 NAUTICAL NOTES...
- Page 34 NAUTICAL NOTES...
- Page 35 NAUTICAL NOTES...
- Page 36 NAUTICAL NOTES...
- Page 38 · 844-GO-ILMOR (464-5667) www.ilmor.com 06.01.2019 Version 1.0...