Provide your child with a cutter and supervise him or her until you are sure that he or she can use it without supervision. We hope you and your child have fun building and experimenting with your SolarBots!
Table of Contents ............... 1 Kit Contents ............... 2 Tips for Assembly and Usage ..........3 Meet the SolarBots! ............4 Solar Panel and Motor Module Assembly Instructions ..6 Solar Gearbox Module Assembly Instructions ....7 Module A & B Assembly Instructions ....... 8 Tips for Disassembly ............
› › › KIT CONTENTS What’s inside your experiment kit: MADE IN TAIWAN 12 12 11 12 19 20 26 27 24 25 MADE IN TAIWAN MADE IN TAIWAN Checklist: Find — Inspect — Check Off Description Quantity Plastic parts group A with parts A1 – A29 Plastic parts group B with parts B1 –...
SolarBots › › › TIPS FOR ASSEMBLY AND USAGE Please read through the tips below before starting and follow them during assembly and usage. Solar • The same solar panel and motor are used gearbox in each model. These are part of a module called the solar gearbox.
MEET THE SOLARBOTS! zOOMER (RacE-CaR SOLARBOT) ARMiE (ARMadILLO SOLARBOT) NAME: NAME: SaLT FLATS gRaSSLandS HOME: HOME: RacinG AlONG LONg, FlaT, SOMERSauLTS, TUMbLinG, STROnG SKILLS: SKILLS: STrAIGHTAWayS dEFENSiVE SkiLLS NOTES: lOVES SuPEr SUNNY dAYS; NOTES: AS lONG AS THE SuN IS SHiNinG, cRUiSiNG ON SaNdY BEACHES;...
Page 7
BRONTO (dinOSAuR SoLaRBOT) AXEL (Big-WHEEL SOLARBOT) NAME: NAME: JUNgLE ciTY SiDEWalKS HOME: HOME: caN gO WHErE BrOnTOSAUruSES MaNEuvERiNG THrOuGH THE ciTy; SKILLS: SKILLS: cOULD NEVEr FiT BEFORE HOPPING cUrbS; PATrOlLING NOTES: BRONTOSAuRUSES ATE PlaNTS FOR NOTES: lOVES To GiVE rIdES TO kiDS — aS ENERgY, BUT BRONTO iS POWErED LONg aS THEY DOn’T SIT On THE DirEcTLy BY THE SUN!
SOLAR PANEL AND MOTOR MODULE ASSEMBLY First, follow the steps starting here to assemble the solar gearbox. Then use the solar gearbox to assemble each model, one at a time. Note: You may need to adjust how much the motor axle sticks out of P2 when you get to step 1 on the next page, to get P2 and P3 to mesh properly.
Assembly Instructions SOLAR GEARBOX MODULE ASSEMBLY (Red) Motor from solar panel and motor module Correct (Green) Incorrect (Red) (Orange) (Orange) (Green) Loop the wires around the post and through the notch as shown. Incorrect Correct...
SOLAR GEARBOX MODULE ASSEMBLY Follow the tips for tightening the screw on page 3. SOLAR GEARBOX TESTING Direct Incandescent or sunlight halogen bulb (50 watts or higher) Place the solar gearbox in direct sunlight. As soon as enough light energy strikes the solar panel, the motor shaft should start spinning.
Assembly Instructions TIPS FOR DISASSEMBLY USING THE PART SEPARATOR TOOL (PART A28) Part A28 is a specially designed tool that can be used to help you disassemble various parts. These diagrams show you how each section of the tool can be used and for which PUSH parts.
Page 14
ZOOMER Disassembly tips Pull here Don’t pull here Use the tool Note: You do not (A28) to remove need to take this Done! the D15 parts. assembly apart.
Page 17
Assembly Instructions Align the two legs so that they are pointing in exactly the same direction. Left side Right side Line up each leg so it is covering the X symbol.
Page 18
ARMIE Done! This diagram shows how the rotating leg causes the model to roll over. Disassembly tip: Use the tool (A28) to remove the D6 and D15 parts.
Page 22
BRONTO Rotate the tail up. Disassembly tips Use the tool (A28) to remove the D15 parts. Done! Note: You do not need to take this assembly apart.
Page 29
Assembly Instructions Incorrect Incorrect Correct Note: Be careful not to apply too much force and break a D15 piece. If you are having trouble, try inserting the D15 pieces into B11 and B12 before inserting them into the C26 pieces.
Page 30
TANK Disassembly tips Done! PUSH Use the tool (A28) to remove the C7, C9, D2, D6, and D15 parts. Note: You can also try using the B8 parts for the tank-tread feet.
Page 34
DIZZY Correct Incorrect Incorrect Done! Note: You can adjust the angle of the solar panel. Disassembly tip: Use the tool (A28) to remove the D6 and D15 parts.
Page 39
Assembly Instructions Correct Incorrect Top View Disassembly tips Use the tool (A28) to remove the D1 and D15 parts. Done! Note: You do not need to take this assembly apart.
Page 44
MAJOR Disassembly tips Done! Use the tool (A28) to remove the D2 and D15 parts. The angle of the head is adjustable. Note: You do not need to take this assembly apart.
SolarBots CHECK IT OUT Incident Solar Energy: the radiant solar energy that hits Earth's surface and is referred to as “global radiation” on a surface. Kilowatt Hours: a measure of electrical energy equivalent to a power consumption of 1,000 watts...
Page 47
Kosmos Quality and Safety More than one hundred years of expertise in publishing science experiment kits stand behind every product that bears the Kosmos name. Kosmos experiment kits are designed by an experienced team of specialists and tested with the utmost care during development and production.
Page 48
Thames & Kosmos Do you have any questions? Email: support@thamesandkosmos.com Our customer Web: thamesandkosmos.com service team will be Phone: 1-800-587-2872 glad to help you!