Table of Contents
Advertisement
03TA Service Manual
A
A Valve (Liquid Feed Solenoid Valve) ------------- 4-1, 5-1, 9-6
Accumulator ----------------------------------------------------- 4-1, 5-1
Adding Refrigerant --------------------------------------------------- 5-4
Air - cooled Condenser Wiring (3 phase) ------------------- 3-16
Air-Cooled Condenser -------------------------------------------- 9-13
Air-Cooled Condenser Data ------------------------------------- 3-12
Air-Cooled Condenser Installation ----------------------------- 3-10
Air-Cooled Piping Schematic -------------------------------------- 4-4
Air-Cooled Units ------------------------------------------------------ 9-5
Allen-Bradley Switch ------------------------------------------------- 9-3
Assembly Drawing, Air-Cooled ----------------------- 1-4, 1-5, 1-6
Assembly Drawing, Water Cooled ------------------ 1-7, 1-8, 1-9
Automatic blowdown ------------------------------------------------- 9-1
B
Basic Product Warranty ------------------------- inside back cover
Bearing, Cutter ----------------------------------------------- 9-19, 9-20
Bill of Lading ----------------------------------------------------------- 2-1
Bin, Electronic Thermostat Programming ------------------- 3-19
Bin, Electronic Thermostat Installation ----------------------- 3-18
Blowdown -------------------------------------------------------------- 9-1
Burnout, Compressor---------------------------------------------- 9-15
C
Capacity Ratings --------------------------------------------------- 11-2
Centrifugal Pump --------------------------------------------------- 9-11
Charging Refrigeration Systems --------------------------------- 1-2
Check Valve ----------------------------------------------------------- 4-2
Checklist, Daily -------------------------------------------------------- 7-9
Checklist, Start-up---------------------------------------------------- 5-2
Chemical Cleaning --------------------------------------------------- 7-5
Circuit Breaker, Control --------------------------------------------- 6-5
Circulating Water Pump Motor ---------------------------------- 9-11
Clean/Ice Switch ------------------------------------------------------ 6-4
Cleaning Procedure -------------------------------------------------- 7-1
Compressor ------------------------------------------------------------ 7-6
Compressor Crankcase Heater----------------------------------- 9-7
Compressor Lubrication -------------------------------------------- 7-6
Compressor Motor Burnout -------------------------------------- 9-15
Compressor Unloader --------------------------------------------- 9-16
Compressor, Contactor --------------------------------------------- 6-5
Condenser Cleaning ----------------------------------------- 7-5, 9-13
Condenser Fan Contactor (FC) ----------------------------- 6-5, 6-6
Condenser Fan Switch ---------------------------------------------- 9-5
Condenser Piping (Cold Weather Valve Kit) ---------------- 3-14
Condenser Water Usage ---------------------------------------- 11-3
Condenser, Air-cooled Cleaning ------------------------------- 9-13
Condenser, Air-cooled Heat Rejection ----------------------- 3-12
Condenser, Pressure Switch (CPS) ----------------------------- 9-5
Condenser, Water Cooled Maintenance ----------------------- 7-5
Control Circuit Protection ----------------------------------------- 9-10
4/21/14
12. Index
Control Panel ---------------------------------------------------------- 6-1
Control Panel Parts -------------------------------------------------- 6-5
Control, Relay (CR) -------------------------------------------------- 6-5
Cooling Tower --------------------------------------------------------- 3-7
Crankcase Heater ---------------------------------------------- 7-6, 9-7
Crushed Ice Production ------------------------------------------- 9-21
Cutter & Bearing Removal/Installation ------------------------ 9-18
Cutter, Assembly --------------------------------------------------- 9-19
Cutter, Bearing ----------------------------------------------- 9-18, 9-19
Cutter, Bearing Support------------------------------------ 9-18, 9-19
Cutter, Disc Assembly ------------------------------------- 9-18, 9-19
Cutter, Drive Parts ------------------------------------------ 9-18, 9-19
Cutter, Gear Reducer ------------------------ 7-7, 9-10, 9-18, 9-19
Cutter, Motor -------------------------------------------------- 9-18, 9-19
Cutter Assembly ---------------------------------------------------- 9-20
Cutter Parts (crushed Ice) ---------------------------------------- 9-20
Cutter/Water Tank Parts (cylinder ice) ----------------------- 9-18
D
D Valve (Thawing Gas) -------------------------------------- 4-1, 9-6
Daily Check List ------------------------------------------------------- 7-9
Drive gear------------------------------------------------------------- 9-19
E
Electrical Connection ------------------------------------------------ 3-8
Electrical Schematic All Voltages 50-60 Hz. ------------------ 6-7
Electrical, Controls --------------------------------------------------- 6-5
Enclosure --------------------------------------------------------------- 6-1
Energy Saving --------------------------------------------------------- 1-1
Equivalent Feet Due To Friction -------------------------------- 3-15
F
Fan Contactor (FC) -------------------------------------------------- 6-5
Filter/Drier -------------------------------------------------------------- 4-1
Float Valve (Make-Up Water) ------------------------------------- 9-1
Freeze Period --------------------------------------------------------- 4-2
Freeze-Up Due To Extended Freezing Period --------------- 8-4
Freeze-Up Due To Ice Failing To Discharge ------------------ 8-5
Freezer ------------------------------------------------------------------ 4-1
Freezer Pressure Switch ------------------------------------------- 9-3
G
Gear Reducer ------------------------------------------------------- 9-11
H
Harvest Period -------------------------------------------------------- 4-2
Head Pressure -------------------------------------------------------- 9-4
Heat Exchanger ------------------------------------------------------- 4-1
Heater, Crankcase --------------------------------------------------- 9-7
High Head Pressure (Air-Cooled) ------------------------------ 8-10
High Head Pressure (Water Cooled) ---------------------------- 8-9
High/Low Pressure Switch ----------------------------------------- 9-4
12-1
INDEX
Advertisement
Table of Contents
