Full Maintenance Cycle (Minimal Every Two Years) - Uvar UDI 6Matic 706M002 Maintenance Manual

9.6 - Full maintenance cycle (minimal every two years)

1. Perform full maintenance and replace the following parts listed in the following table.
Refer to chapter 9.1, 9.2, 9.3 and 9.4 for the complete maintenance scope.
# Description
2 Cover Gasket
5 Service Port Gasket
8/2 Collector Upper Guide
8/4 Fine Screen Seal
8/5 Collector Lower Guide
8/6 Guide Stopper
8/9
8/10
9/2.1 Suction Nozzle
10 Shaft Seal (set)
11
12 PE-Tube 12x8 mm
13/2
13/4 Adapter ¾" x 12mm
13/5 Bolt M4
13/6 Nut M4
14 Reversing Unit Assy.
14/6
24B Filter screen (180 mic) ¾"
24B Ballvalve for ¾" filter
43 Shaft Guide
52 Nut M4
53 Shear Pin
72
It is recommended to replace the drive pawl (14/4) every two years. If the drive pawl was not replaced
after two years replace the drive pawl (14/4) and the reversible drive screw (14/1) every three years.
A -Removing the fine screen and the drive unit for inspection and replacement of above mentioned
parts:
1. Switch off the filter and drain the water (see chapter 8)
2. Disconnect the connector of the stainless steel pipe (65) near the front cover (3) by loosening
knee (66) and disconnect the PE adapter (69), remove the stainless steel pipe.
3. Disconnect the PE tube (12) by removing the clamp nut (70), clamp ring (71) and seal (72).
4. Open the front cover (3) by loosening the bolts.
UDI 5-3-2020
Maintenance Manual -
Model: 706M002 /
706M003 / 706M034 /
706M004 / 706M006
4S7863R020082
4S7863R020085
Seal 4S7863R020089
Wiper 4S7863R020810
Seal
4S7863R00012A
Seal
Seal 4S7863R020146
4S7863R00024B1
Seal
Partcode set: Partcode set:
4S7863R02400 4S7863R08401
Model: 706M086 /
706M008 / 706M128 /
4S78519103
4S420209
4S7863R080082
4S7851B9160
4S7863R080085
4S71500302
4S7863R080089
4S7863R080810
4S7863R0207 4S7863R0807
4S71510381
4S71510380
4S7863R00012A
4S7851B9163 4S7851B9163
4S70600314
4S70600013
4S70600052
4S7863R04015 4S7863R04015
4S7863R020146
4S7863R00024B1
4S7863R00023 4S7863R00023
4S7863R00043 4S7863R00043
4S70600052
4S70600053
4S70600072
21
6Matic.
706M012
4S71500833
4S420209
4S71500804
4S71500302
4S71510381
4S71510380
4S70600314
4S70600013
4S70600052
4S70600052
4S70600053
4S70600072