Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 361131 Cleveland, Ohio 44136-0019. MTD LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019 PRINTED IN U.S.A. 21” Self Starter High-Wheel Rotary Mower Model 589 769-00004A.fm FORM NO. (10/2002)
Troubleshooting ... 15 Parts List ... 16 This Operator’s Manual is an important part of your new lawn mower. It will help you assemble, prepare and maintain the unit for best performance. Please read and understand what it says. Before you start assembling your new equipment, please locate the model plate on the equipment and copy the information from it in the space provided below.
SECTION 1: IMPORTANT SAFE OPERATION PRACTICES WARNING: This symbol points out important safety instructions which, if not followed, could endanger the personal safety and/or property of yourself and others. Read and follow all instructions in this manual before attempting to operate this machine. Failure to comply with these instructions may result in personal injury.
20. Never operate mower without proper trail shield, discharge cover, grass catcher, blade control handle or other safety protective devices in place and working. Never operate mower with damaged safety devices. Failure to do so, can result in personal injury. 21.
Page 5
meet the original equipment specifications may lead to improper performance and compromise safety!” Mower blades are sharp and can cut. Wrap the blade or wear gloves, and use extra caution when servicing them. Keep all nuts, bolts, and screws tight to be sure the equipment is in safe working condition.
1/4-20 (2) Disconnecting Spark Plug Wire Before setting up your lawn mower, disconnect the spark plug wire from the spark plug and ground to a bolt on the engine. Leave safety key in locked position. See Figure 1.
WARNING: without the grass catcher assembly or the mulching baffle firmly secured on the machine. Plastic Channel Grass Catcher Figure 7 Figure 8 Never operate the lawn mower...
SECTION 4: KNOW YOUR LAWN MOWER Read this owner’s manual and safety rules before operating your lawn mower. Compare the illustrations in Figure 9 with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference.
The mower is shipped with the safety key in the locked position and the self starter in the de- energized mode, follow instructions as follows. 1. Place lawn mower on a level surface outdoors. 2. Remove clear plastic packaging under fuel cap. 3. Check oil level.
Page 11
The safety key must be in the locked position before it can be removed. Throttle Speed Your lawn mower engine is equipped with a constant speed throttle, which is set at full throttle for best performance. Using Your Lawn Mower...
WARNING: If you strike a foreign object, stop the engine. Remove wire from spark plug and de-energize, thoroughly inspect the mower for any damage, and repair the damage before restarting and operating the mower. Excessive vibration of the mower during operation is an indication of damage. The unit should be promptly inspected and repaired.
SECTION 7: MAINTAINING YOUR LAWN MOWER WARNING: Be sure to disconnect the spark plug wire and DE-ENERGIZE starter before performing maintenance. maintenance or service to the engine and/or mower equipped with the safety key in the unlocked and/or energized mode.
Always stop engine and disconnect spark plug wire before cleaning, lubricating or doing any kind of service work on the lawn mower. Blade Control Lubricate the pivot points on the blade control handle at least once a season with light oil. The blade control must operate freely in both directions.See Figure 14.
SECTION 9: TROUBLESHOOTING Problem Engine fails to start Blade control handle disengaged. Start control button not depressed. Spark plug wire disconnected. Safety key not in run position Fuel tank empty or stale fuel. Blocked fuel line. Faulty spark plug. Engine flooded Self starter already de-energized Engine runs erratic Spark plug wire loose.
Page 17
Model 589 Series Ref. Part No. Part Description 749-04001 Upper Handle 647-0070 Control Handle 712-0324 Hex Lock Nut 1/4-20 712-0397 Wing Nut 710-1205 Rope Guide 710-1174 Carriage Bolt 5/16-18 x 2” 736-0451 Shoulder Washer.320 ID x.930 OD 720-0284 Wing Nut 746-1141 Self Start Control Cable 58.25”...
Page 18
MANUFACTURER’S LIMITED WARRANTY FOR: The limited warranty set forth below is given by MTD LLC with respect to new merchandise purchased and used in the United States, its possessions and territories. MTD LLC warrants this product against defects for a period of two (2) years commencing on the date of original purchase and will, at its option, repair or replace, free of charge, any part found to be defective in materials or workmanship.