Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 368022 Cleveland, Ohio 44136-9722. MTD PRODUCTS INC. P.O. BOX 368022 CLEVELAND, OHIO 44136-9722 ECO # 2844 PRINTED IN U.S.A. 21” Rear Discharge Rotary Mower Model 589 770-10111C.fm FORM NO. (10/2000)
SECTION 1: IMPORTANT SAFE OPERATION PRACTICES WARNING: This symbol points out important safety instructions which, if not followed, could endanger the personal safety and/or property of yourself and others. Read and follow all instructions in this manual before attempting to operate this machine. Failure to comply with these instructions may result in personal injury.
other safety protective devices in place and working. Never operate mower with damaged safety devices. Failure to do so, can result in personal injury. 21. Muffler and engine become hot and can cause a burn. Do not touch. 22. Only use parts and accessories made for this machine by the original equipment manufacturer (O.E.M).
Page 5
only, listed in this manual. “Use of parts which do not meet the original equipment specifications may lead to improper performance and compromise safety!” Mower blades are sharp and can cut. Wrap the blade or wear gloves, and use extra caution when servicing them. Keep all nuts, bolts, and screws tight to be sure the equipment is in safe working condition.
SECTION 3: ASSEMBLING YOUR LAWN MOWER This unit is shipped without gasoline or oil IMPORTANT: in the engine. Be certain to service engine with gasoline and oil as instructed in the separate engine manual before operating your mower. Removing Unit From Carton •...
Attaching Starter Rope • The rope guide is attached to the right side of upper handle. Loosen the wing nut which secures the rope guide. See Figure 5. Upper Handle Starter Rope Wing Nut Rope Guide Figure 5 • With the spark plug wire disconnected and grounded, hold the blade control handle against the upper handle, and pull the starter rope out of the engine.
SECTION 4: KNOW YOUR LAWN MOWER Read this owner’s manual and safety rules before operating your lawn mower. Compare the illustrations in Figure 10 with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference.
SECTION 5: OPERATING YOUR LAWN MOWER WARNING: Read, understand, and follow all instructions and warnings on the machine and in this manual before operating. Gas & Oil Fill-Up • Check oil level and add oil if necessary. Follow relevant instructions in the engine manual for this. •...
SECTION 6: MAKING ADJUSTMENTS WARNING: Do not at any time make any adjustments without first stopping engine and disconnecting spark plug wire. Cutting Height Height Adjustment Lever Figure 11 An adjusting plate and spring lever at each wheel position provides cutting height adjustment. Each adjusting plate has several height positions.
leaves, dirt, or other matter. If this debris is allowed to accumulate, it will invite rust and corrosion, and may prevent proper mulching, discharge, or bagging. The deck may be cleaned by tilting the mower and scraping clean with a suitable tool (make certain the spark plug wire is disconnected).
SECTION 8: STORING YOUR LAWN MOWER The following steps should be taken to prepare your lawn mower for storage. • Clean and lubricate mower thoroughly as described in the lubrication instructions. We do not recommend the use of a IMPORTANT: pressure washer or garden hose to clean your unit.
Page 15
Model 11A-589 Series Ref. Part No. Part Description 747-0824 Control Handle Assembly 710-1205 Rope Guide 720-0279 Handle Knob 710-1174 Carriage Bolt 5/16-18 x 2” 710-0654A Hex Washer Screw 3/8-16 x 1.00” 720-0314 Hand Knob 710-1270 C-Sunk Screw 1/4-20 x 1.3”...
Page 16
MANUFACTURER’S LIMITED WARRANTY FOR: The limited warranty set forth below is given by MTD PRODUCTS INC (“MTD”) with respect to new merchan- dise purchased and used in the United States, its posses- sions and territories. MTD warrants this product against defects in material and workmanship for a period of two (2) years commencing on the date of original purchase and will, at its option, repair or replace, free of charge, any part found to be defective in...