Eastwood 31638 Instructions Manual page 16

LUBRICATION
• The Automatic Oiler attached to the Air Regulator/Oiler "ee"
must be kept full of a good quality air tool oil by removing the
fill plug (FIG 17) with a 3mm hex key (not included), adding
oil and replacing the plug. This is critical to keep the various
pneumatic actuating cylinders and valves in the assembly
properly lubricated. Note that the Needle Valve (FIG 17) is
used to control the amount of oil dispensed into the system.
• The slots in the Turntable in which the four sliding Rim
Clamps ride in MUST be cleaned of dirt and grit accumula-
tion and kept well lubricated by adding a good quality auto-
motive chassis grease after every 2 hours of operation time.
• The hexagonal shaft of the Slide Shaft MUST be cleaned of
dirt and grit accumulation and kept well lubricated by adding
a good quality automotive chassis grease after every 4 hours
of operation time.
• The pivoting arm joint of the Vertical Tower must be
lubricated with several drops of a good quality motor oil
after every week of operating time.
• The pivoting arm joint of the Bead Breaker must be
lubricated with several drops of a good quality motor oil
after every week of operating time.
• The pivoting joint Bead Breaker Blade must be lubricated with several drops of a good quality motor oil after every week of operating time.
GENERAL MAINTENANCE
• Disconnect air supply from inlet to release all residual air pressure in Machine.
• After each use, drain water from the moisture trap on the Regulator Unit by gripping the brass nipple on the underside clear vessel of the Regulator
and pulling it down.
• After each use, inspect the machine for any damaged components or loose fasteners and tighten or make repairs as necessary.
• Keep machine out of damp environments, extreme temperatures and keep covered when not in use.
• Always keep air and electrical power supply disconnected when not in use.
16
FIG. 17
Fill Plug
Needle Valve
Eastwood Technical Assistance: 800.343.9353 >> techelp@eastwood.com
Lift
Open Close