Recommended operating ambient temperature is or damage must be made to the carrier. The between 75°F(23.9°C) to 80° (26.7°C). Maximum carrier will provide any necessary inspection relative humidity is 55%. reports and/or claim forms. GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Do NOT stand or walk on top of products at below freezing temperatures. merchandiser. Do not store items or Carefully read and follow the instructions prior flammable materials atop the unit. operating the merchandiser. P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
“Proposition 65.” secured in place, the merchandiser may be slid off the skid and placed in its final location. This warning does not mean that Hussmann products will cause cancer or reproductive DO NOT TILT MERCHANDISER ON ITS harm, or is in violation of any product-safety SIDE OR END WHEN REMOVING SKID.
NOTE: Do not allow trim to cover any intake or discharge grilles located in the lower front panel. P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Page 10
LEGAL DISCLAIMER: Hussmann shall not be liable for any repair or replacements made without the written consent of Hussmann, or when the product is installed or operated in a manner contrary to the printed instructions covering installation and service which accompanied such product.
Page 12
• NOTICE – Not related to personal injury – Indicates[s] situations, which if not avoided, could result in damage to equipment. P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
This includes, but is not limited to, such items as doors, lights, fans, heaters, and thermostats. Merchandiser must be grounded. Do not remove the power supply cord ground. GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
If panels are not in place airflow from the condenser will not be directed over the evaporator pan and defrost water in the pan may overflow. P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Page 15
Lights while the refrigeration coil is controller has connections for sensors and defrosting. switched equipment. Temperature or Sensor Alarm (red): Lights if the temperature is too warm or too cold. Flashes if a sensor fails. GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Page 16
24 hours and reaches desired operating temperature.behavior match- es the LEDs on the controller. Product will be degraded and may spoil if allowed to sit in a non-refrigerated area. P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Page 17
(The green LED will be lit.) 1, and the time to subsequent defrost will reset. 2. The compressor will start after a 30 second delay once power is applied. GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
The graph below shows an example of duty cyle operation during a case sensor failure. IMPORTANT: Return the control knob to its original setting (Step 1) once the manual defrost has been initiated. P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
(cut out value). A few The dial should be set at Postition 3 for seconds after the temperature is set, the conducting DOE compliance testing. controller reverts to the sensed temperature in the merchandiser. GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Page 20
DO NOT SCALE. DIMENSIONS TO OUTSIDE UNLESS OTHERWISE NOTED. PART TO BE FREE OF BURRS, SHARP EDGES, AND CORNERS P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com MATERIAL- SEE NOTES MODEL BY / DWG BY- S.G.E / S.G.E...
Defrosts are temperature controlled for self the newest to the back. contained. The defrost setting is factory set as shown below. GSVM 4060F GSVM 4060F -20° to -5°F Electric 45°F GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
(56.7 kg). The bottom sheet metal area has customers and staff. a weight limit of 250 (113.4). For wire baskets the weight limit is 100 lbs (45.4 kg) P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1800-890-2900 • www.hussmann.com...
•Do not use high pressure water hoses. Product will be degraded and may spoil if Do NOT allow cleaning agent or allowed to sit in a non-refrigerated area. cloth to contact food product. GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
DO NOT FLOOD! Use only enough water necessary to clean surface. Water must not drip down the case! Never use ammonia based cleansers, abrasive cleansers, or scouring pads. P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Wipe down heater coil with a cloth and warm water. Be sure to remove any dirt, debris or liquids from the heater coil. Water introduced during cleaning will cause the evaporation pan to overflow. GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
1. Use steel wool to smooth out the surface area of the bumper. 2. Clean area. 3. Apply vinyl or car wax and polish surface for a smooth glossy finish. P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Page 27
Verify unit doors and lids work and are sealed correctly. Verify that all the panels, shields and covers are in place. Technician Notes: Form HSCW03 Rev-29 OCTOBER13 0525210_C GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
To maintain product integrity, move all prod- uct to a cooler until the unit has returned to Product will be degraded and may spoil if normal operating temperatures. allowed to sit in a non-refrigerated area. GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
2. Replace with similar Hussmann power the standard shelf. This stop is mounted under supply. tension and should not be confused with the wire front in the partition kit. 3. Reassemble. P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Compressor runs continuously; product too cold 2. Control sensing element not 2. Assure proper contact in positive contact 3. Leak check, replace drier 3. Short on refrigerant evacuate and recharge GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Page 32
3. Check to see if bulbs are inserted properly in sockets 4. Check voltage TROUBLESHOOTING DOOR GUIDE Door Do Not Close (gaskets do not seal) Doors Do Not Stay Open P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Page 33
P/N 3003960_A TROUBLESHOOTING DOOR GUIDE CONTINUED Condensation Between Panes of Glass Condensation on Unheated Doors Condensation on High Humidity Heated Doors GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Page 34
11/16” wrench. 4. Repeat Step 1 and 2 as needed for each door. Risk of injury. Pinching hazard due to potential pre-loaded pressure. P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Page 35
A — T P/N 3003960_A ppendix echnicAl Hussmann refrigerated merchandisers configured for sale for use in the United States meet or surpass the requirements of the DOE 2012 energy efficiency standards. Parts List Model GSVM4060F Standard Parts Description Part Number...
Page 36
Optional End Bumpers (One Pair) 2 in. (51 mm) Waste Outlet LH end of case (from outside of End Assembly) in. (520.7 mm) to center of waste outlet P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Page 39
Note: This data is based on store temperature and humidity that does not exceed 80°F and GSVM4060F 55% R.H. unless otherwise stated. Schedule defrost at night while lights are off. GSVM4060F A GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
/case ( 0.55 m /case) Computed using AHRI 1200 standard methodology: Total Display Area, ft ] / Unit of Length, ft [m] 404A 12.7 5-20P G SV M 4060 P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Page 41
GSVM 4060F (R404A) 18 oz 0.510 kg ESTIMATED SHIPPING WEIGHT Self Contained Case with Shipping Crate 434 lb (197kg) 493 lb (223.6kg) GSVM 4060F Included Actual weights will vary according to optional kits included. GSVM 4060F Merchandisers HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Page 42
A — T 5-14 ervice ppendix echnicAl P/N 3003960_A U.S. & Canada 1-800-922-1919 • Mexico 1 800-890-2900 • www.hussmann.com...
Page 43
To obtain warranty information or other support, contact your Hussmann representative. Please include the model and serial number of the product. Hussmann Corporation, Corporate Headquarters: Bridgeton, Missouri, U.S.A. 63044-2483 01 October 2012...
Page 44
Hussmann Corporation 12999 St. Charles Rock Road Bridgeton, MO 63044-2483 www.hussmann.com...