Servicing The Engine Oil And Filter; Fuel System - Toro Reelmaster 6700-D Operator's Manual

6. Insert new filter properly into air cleaner body. Make
sure filter is sealed properly by applying pressure to
outer rim of filter when installing. Do not press on
flexible center of filter.
7. Reinstall cover and secure latches. Make sure cover is
positioned with TOP side up.
8. Reset indicator (Fig. 43) if showing red.
Servicing the Engine Oil and
Filter
Change oil and filter initially after the first 50 hours of
operation, thereafter change oil and filter every 100 hours.
1. Remove drain plug (Fig. 47) and let oil flow into drain
pan. When oil stops, install drain plug.
1
1
Figure 47
1. Drain plugs
2. Remove oil filter (Fig. 48). Apply a light coat of clean
oil to the new filter seal before screwing it on. Do not
over-tighten.
1
Figure 48
1. Oil filter
3. Add 10W-30 CD, CE, CF, CF-4, or CG-4 oil to
crankcase. Capacity is 7.5 qt. (7 L) with filter.

Fuel System

Fuel Tank
Drain and clean fuel tank every 2 years. Also, drain and
clean tank if fuel system becomes contaminated or if
machine is to be stored for an extended period. Use clean
fuel to flush out the tank.
1
1. Fuel tank drain
Danger
Under certain conditions, diesel fuel and fuel
vapors are highly flammable and explosive. A fire
or explosion from fuel can burn you and others
and can cause property damage.
Use a funnel and fill the fuel tank outdoors, in
an open area, when the engine is off and is cold.
Wipe up any fuel that spills.
Do not fill the fuel tank completely full. Add fuel
to the fuel tank until the level is 1/4 to 1/2 in. (6
to 13 mm) below the bottom of the filler neck.
This empty space in the tank allows the fuel to
expand.
Never smoke when handling fuel, and stay away
from an open flame or where fuel fumes may be
ignited by a spark.
Store fuel in a clean, safety-approved container
and keep the cap in place.
Fuel Lines and Connections
Check lines and connections every 400 hours or yearly,
whichever comes first. Inspect for deterioration, damage, or
loose connections.
Fuel Filter / Water Separator
Drain water or other contaminants from fuel filter / water
separator (Fig. 50) daily.
35
Figure 49