Page 1
Additional manuals are available from your WELLS DEALER. THIS MANUAL MUST BE READ AND UNDERSTOOD BY ALL PERSONS USING OR INSTALLING THIS APPLIANCE. Contact your WELLS DEALER if you have any questions concerning installation, operation or maintenance of this equipment.
Page 2
Wells’ discretion have the parts replaced or codes, including incorrect gas or electrical connection. Wells is not liable repaired by Wells or a Wells-authorized service agency.
TABLE OF CONTENTS WARRANTY Thank you for purchasing this SPECIFICATIONS Wells Manufacturing appliance. FEATURES & OPERATING CONTROLS PRECAUTIONS & GENERAL INFORMATION Proper installation, profes- AGENCY LISTING INFORMATION sional operation and consistent INSTALLATION maintenance of this appliance OPERATION will ensure that it gives you the...
FEATURES & OPERATING CONTROLS FEATURES & OPERATING DEFINITIONS ITEM COMMENT The char-broiler is INFINITE SWITCH CONTROLLED. Power is applied to the heating elements based on TEMPERATURE the control knob position and the amount of energy used. CONTROL Light will glow when the infinite switch is in any position other that OFF. INDICATOR LIGHT The char-broiler element assembly may be raised for cleaning, or to add water to the drip pan.
Page 5
FEATURES & OPERATING CONTROLS (continued) IL2757 Fig. 1 Countertop Electric Charbroiler...
PRECAUTIONS AND GENERAL INFORMATION WARNING: Broilers are intended for use to cook food products for human consumption. No other use is recommended or authorized by the Electric Shock manufacturer or its agents. Hazard Broilers are intended for use in commercial establishments, where all All servicing requiring users are familiar with the appliance limitations, use and associated access to non-insulated...
INSTALLATION UNPACKING & INSPECTION NOTE: DO NOT discard the carton or other packing Carefully remove the appliance from the carton. Remove all protective materials until you have plastic film, packing materials and accessories from the appliance inspected the appliance for before connecting electrical power or otherwise performing any hidden damage and tested it installation procedure.
Page 8
INSTALLATION (continued) ELECTRCAL HOOK-UP WARNING: Risk of personal Refer to the nameplate. Verify the electrical service power. Voltage injury and phase must match the nameplate specifications. Connecting the griddle to the wrong voltage can severely damage the unit or cause Installation procedures must noticeable decreased performance.
OPERATION PREPARE THE CHAR-BROILER CAUTION: FOR USE Hot Surface When using the broiler for the first Exposed surfaces can be hot time, wipe the entire unit with a to the touch and may cause clean damp cloth or sponge and mild burns.
Page 10
OPERATION (continued) TEMPERATURE CONTROLS CAUTION: Each section of the broiler is equipped with an individual temperature control. The desired temperature is controlled by rotating the Surface TEMPERATURE CONTROL KNOB. Any time the control is turned “ON”, the adjacent indicator light will glow. Each section of the broiler may be set to a different temperature setting.
Page 11
OPERATION (continued) BROILER CHART RECOMMENDED COOKING TIMES AND DIAL SETTINGS NOTE: The times and dial settings in this chart are suggestions only. Your own experience with your own menu items will be your best guide to achieving the best food product. PRODUCT COOKING TIME...
CLEANING INSTRUCTIONS CAUTION: PREPARATION Electric Shock Turn both temperature control knobs OFF. Hazard Allow broiler to cool completely. Disconnect appliance from electric power before Disconnect broiler from electric power. cleaning. FREQUENCY Daily. CAUTION: Burn Hazard TOOLS Allow appliance to cool Steel Brush with scraper completely before cleaning.
One or more section won’t 240V unit run on 208V Verify proper voltage heat—or not hot enough Contact an Authorize Wells Service Agency for Damaged component or wiring repairs Temperature control not set Set temperature control knob to desired temperature...
Page 16
EXPLODED VIEW & PARTS LIST COUNTERTOP ELECTRIC CHAR BROILER MODEL B-44 Model: B44 Electric Charbroiler IL1729 Rev. A 4/14/09 PL161...
Page 17
EXPLODED VIEW & PARTS LIST B44 Electric Charbroiler Application Fig No Part No Description H6-38623 GRATE AS RECD BROILER H6-32740 COVER RR ELEM ASSY B44 WS-57507 CASTING ASSY ELEM REAR 2P-32428 SPRING SUPPORT ROD 2A-34061 ROD HEAD SUUORT B44/B446 H6-35593 PAN GREASE B44-50 2A-32840 L PIVOT BRKT (use mount screw 2C-33890)
Page 18
EXPLODED VIEW & PARTS LIST COUNTERTOP ELECTRIC CHAR BROILER MODEL B-50 Model: B50 Electric Charbroiler IL1730 Rev. C 7/27/11 PL161...
Page 19
EXPLODED VIEW & PARTS LIST B50 Electric Charbroiler Fig No Part No Description H6-38623 GRATE MACH BROILER ASSY H6-32740 COVER RR ELEM ASSY B44, B50 2E-30001 JUMPER, ELEMENT LONG 2E-30002 JMPR-ELEMENT,1-1/4” BRLR WS-57507 CASTING ASSY ELEM REAR 2P-32428 SPRING SUPPORT ROD 2A-32741 ROD HEAD SUPPORT ASSY H6-35593...
Page 20
EXPLODED VIEW & PARTS LIST CONTROL KNOB IDENTIFICATION All versions of the Wells Electric Char-Broiler use control knob p/n 2R-30371. IL2763...
CORDSET 240V 30A NEMA 6-30P, For factory authorized service, B-40, B-44 2E-35259 or to order factory authorized replacement parts, contact your GREASE PAN, B-44 (1 PER UNIT) Wells authorized service agency, B-50 (2 PER UNIT) H6-35593 or call: GREASE PAN, B-40 H6-35594 Wells Manufacturing 10 Sunnen Dr.