SNOWJOE iON100V-21SB Operator's Manual

SNOWJOE iON100V-21SB Operator's Manual

Cordless snow blower 21-inch, 100-volt max, led lights

Advertisement

OPERATOR'S MANUAL
A Division of Snow Joe
, LLC
®
IMPORTANT!
Safety Instructions
All Operators Must Read These
Instructions Before Use
Read all instructions when using cordless snow blowers.
Basic safety precautions should always be followed to reduce
the risk of fire, electric shock, and personal injury.
General Safety Rules
Notice the personal safety alert symbol
manual to draw your attention to a WARNING given along
with the particular operating instruction. This means that
the operation requires special ATTENTION, CAUTION, and
AWARENESS.
• Keep work area clean and well lit – Cluttered, dark areas
invite accidents.
• Keep bystanders away – All bystanders and pets should
be kept a safe distance away from the work area.
• Dress properly – Do not wear loose clothing or jewelry.
They can get caught in moving parts. Protective rubber
gloves and non-slip footwear are recommended when
working outdoors.
• Use the right product – Do not use this machine for any
job except that for which it is intended.
m
CAUTION! – Exercise caution to avoid slipping or falling.
Wear protective footwear that will protect your feet and
improve your footing on slippery surfaces.
• Use safety glasses – Also use safety footwear, snug-fitting
clothing, protective gloves, hearing and head protection.
• Do not force the snow blower – Use the snow blower
at the rate for which it was designed to ensure optimal
performance and safe operation.
• Stay alert – Watch what you are doing. Use common
sense. Do not operate the snow blower when you are tired
or under the influence of alcohol or drugs.
• Do not overreach – Keep proper footing and balance at
all times.
• Store indoors – When not in use, the snow blower should
be kept dry and stored out of the reach of children in a high
or locked place.
• Maintain snow blower with care – Follow instructions for
lubricating and changing accessories.
© 2018 by Snow Joe
, LLC
®
All rights reserved. Original instructions.
CORDLESS SNOW BLOWER
R
21-INCH | 100-VOLT MAX* | LED LIGHTS
Model iON100V-21SB
m
used in this
m
WARNING!
Always disengage the switch bar lever,
and disconnect the battery pack; wait for all movement to
stop before making any adjustments, inspecting, servicing,
changing accessories, cleaning the snow blower, or when
any other dangerous conditions present. Any such operation
should be performed after revolving parts inside the snow
blower stop completely. Such preventive safety measures
reduce the risk of starting the power tool accidentally.
m
WARNING!
When replacing any parts, you must strictly
observe the instructions and procedures described in this user
manual. Special care should be paid to any rubber parts, since
these parts may increase the engine load and decrease its
mechanical power if damaged.
m
WARNING!
If you notice that the snow blower is not
running properly or hear abnormal sounds from the engine
when it is in use, immediately stop the machine, disconnect
the battery pack, and contact Snow Joe
service center at 1-866-SNOWJOE (1-866-766-9563).
• Surfaces – This snow blower is intended for use on
paved surfaces. Do not use on gravel, stone or other
unpaved surfaces unless the snow blower is adjusted for
such surfaces according to the instructions given in the
operator's manual.
• Moving parts present risks – Keep your face, hair,
clothing, hands, and feet away from moving parts. All
guards and safety attachments must be installed properly
before using the unit. Shut off and disconnect the battery
pack before touching any parts other than the handles and
switch.
• Avoid accidental starting – Make sure the safety button is
off and the switch bar lever is disengaged before inserting
the battery pack into the unit. Do not transport the snow
blower with the safety button and the switch bar lever
engaged.
• Do not overreach – Maintain proper footing and balance at
all times. Place heels firmly on the ground and tightly grasp
the handle grips. Watch for uneven surfaces and do not
overreach. In case you fall or collide with the snow blower,
inspect the unit for any damages or cracks. When stepping
backwards, be careful to avoid obstacles beneath your feet
or behind you to avoid falling.
m
WARNING!
If the snow blower strikes any object,
follow these steps:
i) Stop the snow blower and remove the battery pack.
ii) Inspect for damage.
SAVE THESE INSTRUCTIONS
1
Form No. SJ-iON100V-21SB-880E-M
+ Sun Joe
customer
®
®

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the iON100V-21SB and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for SNOWJOE iON100V-21SB

  • Page 1 ® ® • Keep work area clean and well lit – Cluttered, dark areas service center at 1-866-SNOWJOE (1-866-766-9563). invite accidents. • Surfaces – This snow blower is intended for use on • Keep bystanders away – All bystanders and pets should paved surfaces.
  • Page 2: Battery + Charger Safety Instructions

    ® ® battery pack in rain, snow or in damp or wet locations. 1-866-SNOWJOE (1-866-766-9563) for assistance. Do not use the battery pack or charger in the presence of • Battery chemicals cause serious burns – Never let a explosive atmospheres (gaseous fumes, dust or flammable damaged battery pack contact the skin, eyes or mouth.
  • Page 3: Information About The Battery

    ® ® ® (15°C) and charged to at least 40%. customer service center at 1-866-SNOWJOE (1-866-766-9563). 4. Lithium-ion batteries are subject to a natural aging process. The battery pack must be replaced at the latest 3. Electrical plugs must match the outlet. Never modify when its capacity falls to just 80% of its capacity when the plug in any way.
  • Page 4: Protection From Environmental Influences

    Snow Joe + Sun Joe customer ® ® ® service center at 1-866-SNOWJOE (1-866-766-9563) for assistance. Safety Instructions for Walk-Behind • Noise control – When using the snow blower, respect Snow Blowers the local laws and regulations regarding noise control and environmental protection.
  • Page 5 model. When replacing any parts, you must strictly observe the instructions and procedures described in this manual. Special care should be paid to any rubber parts, since these parts may increase the engine load and decrease its mechanical power if damaged. • Tip over hazard –...
  • Page 6: Safety Symbols

    Safety Symbols The following table depicts and describes safety symbols that may appear on this product. Read, understand and follow all instructions on the machine before attempting to assemble and operate. Symbols Descriptions Symbols Descriptions READ THE OPERATOR'S MANUAL(S) – Read, understand WARNING! Do not expose the and follow all instructions in the unit to rain or wet conditions.
  • Page 7 100- ® Volt 5.0 Ah lithium-ion battery (included). Additional batteries will provide extended runtime, and are sold separately. Battery options available at snowjoe.com. 1. Soft grip 14. Scraper bar 2. Switch bar level 15. Wheels (2) 3. Chute rotate buttons (left and right) 16.
  • Page 8: Technical Data

    ® ® Handle frame 1-866-SNOWJOE (1-866-766-9563). NOTE: Do not discard the shipping carton and packaging material until you are ready to use the cordless snow blower. The packaging is made of recyclable materials. Properly dispose of these materials in accordance with local regulations or save the packaging for long-term product storage.
  • Page 9: Battery Pack Operation

    Battery Pack Operation 3. Lock the handle frame in position by rotating the handle frame locks on both sides counter-clockwise (Fig. 3). This equipment is powered by either one or two lithium-ion Fig. 3 batteries (additional batteries sold separately). The battery packs are completely closed and maintenance free.
  • Page 10: Charger Operation

    NOTE: If the charge level button does not appear to be Fig. 8 working, place the battery pack on the charger and charge as LED light needed. NOTE: Immediately after using the battery pack, the charge level button may display a lower charge than it will if checked a few minutes later.
  • Page 11 Wait for a while and try to reinsert the battery into the charger. If the situation still persists, contact Snow Joe + Sun Joe customer service at 1-866-SNOWJOE ® ® (1-866-766-9563). Temperature abnormal...
  • Page 12 Use the table below to determine charger light patterns and possible causes. For all other issues, contact Snow Joe + Sun ® • Abnormal performance customer service center at 1-866-SNOWJOE – Something is wrong with ® (1-866-766-9563). the battery or the charger.
  • Page 13 MIN. Auger Speed MAX. Auger Speed Fig. 13 Battery Runtime 30 min 15 min Battery Plowing Capacity 12.5 tons/charge 16 tons/charge compartment 25 ft (7.6 m) 30 ft (9 m) Throw Distance cover NOTE: The specs in above table are based on the power provided by one Snow Joe iON100V-5AMP battery that ®...
  • Page 14: Led Headlights

    1. To turn on the LED light, press the LED light button Maintenance (Fig. 19). To order genuine replacement parts or accessories for the Fig. 19 Snow Joe iON100V-21SB cordless snow blower, please visit ® snowjoe.com or contact the Snow Joe + Sun Joe customer ®...
  • Page 15 2. Check bolts and screws at frequent intervals for proper tightness to ensure that the equipment is in safe working Fig. 20 condition. 3. After each snow removal, shut off the motor, wait for all revolving parts to stop completely, remove the battery and wipe residual ice and snow off the unit.
  • Page 16 2. Follow the same instruction to remove the other 3 blades Fig. 21 located on the sides. Rotate the auger when working on the blades on the back. 3. After 4 blades on the side are removed, move to the two blade pieces that are fixed on the middle steel plate.
  • Page 17 Snow Joe + Sun Joe ® ® ® customer service center at 1-866-SNOWJOE (1-866-766-9563) for assistance. Drive belt 2. Clean the snow blower before storing or transporting. Be sure to secure the unit while transporting. Auger pulley 3.
  • Page 18: Battery Caution + Disposal Information

    Battery + Charger Off-Season Storage 1. Do not expose your battery pack(s) or charger to water, If your Snow Joe iON100V-21SB cordless snow blower ® rain or allow them to get wet. This could permanently requires service or maintenance, please call the Snow Joe ®...
  • Page 19: Federal Communications Commission (Fcc)

    iON100V-RCH Federal Communications Commission (FCC) WARNING! Any changes or modifications to this unit not expressly approved by the party responsible for compliance could void the user's authority to operate the equipment. Class B device: NOTE: This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules.
  • Page 20 Troubleshooting WARNING! Always turn the tool OFF and remove the battery before performing any adjustments, maintenance, or repairs to your cordless snow blower. Problem Possible Cause Solution Unit will not 1. Batteries are flat. 1. Charge the batteries start 2. Batteries are not locked in 2.
  • Page 21: Optional Accessories

    NOTE: Accessories are subject to change without any obligation on the part of Snow Joe + Sun Joe to provide notice of such ® ® changes. Accessories can be ordered online at snowjoe.com or via phone by contacting the Snow Joe + Sun Joe customer ® ®...
  • Page 22 NOTES...
  • Page 23 WHO CAN SEEK WARRANTY COVERAGE? Wearing parts like belts, augers, chains and tines are not covered under this warranty, and can be purchased at snowjoe.com or This Warranty is extended by Snow Joe + Sun Joe to the owner ®...
  • Page 24 snowjoe.com...

Table of Contents

Save PDF