Table of Contents
Advertisement
Quick Links
P/N 900634-00 REV. B 12/2019
P900634-00
INSTALLER: Leave this manual with the appliance.
DANGER
CARBON MONOXIDE WARNING
• This appliance can produce carbon
monoxide which has no odor.
• Using it in an enclosed space can kill
you.
• Never use this appliance in an en-
closed space such as a camper, tent,
car or home.
WARNING: Do not store gasoline or other flammable vapors and liquids in the vicinity of this or any other appli-
ance. An LP-cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing prop-
erty damage, personal injury, or loss of life
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could result in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appli-
ance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire department.
- Installation and service must be performed by a qualified installer, service agency or the gas supplier.
PFS
®
US
Report No. F10-087
WHEN USED AS AN OUTDOOR APPLIANCE
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
• Shut off gas to the appliance.
• Extinguish any open flame.
• If odor continues, leave the area immediately.
• After leaving the area, call your gas supplier or fire department.
Failure to follow these instructions could result in fire or explosion, which
could cause property damage, personal injury, or death.
WARNING: For Outdoor Use Only.
Installation and service must be performed by a qualified installer, service
agency, or the gas supplier.
WHEN USED AS INDOOR VENTED APPLIANCE
Installation and Operation Instructions
Vented Gas Log and Burner Set
Models
MAGNIFLAMEOD30NM
For use with log sets
SOUTHERNCOMFORT30A/B
SOUTHERNCOMFORT36A/B
CONSUMER: Retain this manual for future reference.
MAGNIFLAMEOD30PM
SHADYHOLLOW30A/B
SHADYHOLLOW36A/B
Advertisement
Table of Contents
Related Manuals for Astria Fireplaces MAGNIFLAMEOD30NM
Summary of Contents for Astria Fireplaces MAGNIFLAMEOD30NM
- Page 1 Installation and Operation Instructions Vented Gas Log and Burner Set Models MAGNIFLAMEOD30NM MAGNIFLAMEOD30PM P/N 900634-00 REV. B 12/2019 For use with log sets SOUTHERNCOMFORT30A/B SHADYHOLLOW30A/B ® SHADYHOLLOW36A/B SOUTHERNCOMFORT36A/B P900634-00 Report No. F10-087 INSTALLER: Leave this manual with the appliance. CONSUMER: Retain this manual for future reference.
-
Page 2: Table Of Contents
Thank you for your purchase. We appreciate your TABLE OF CONTENTS business! Safety ..................... 2 Product Identification ..............3 Please carefully read and follow all instructions in this manual. Pay Local Codes ................... 4 special attention to all warnings and safety information. Optional Remote Control Accessories ........... - Page 3 SAFETY Continued You must operate this appliance with the fireplace WARNING: Vent-free products are prohibited for screen and hood in place. Make sure fireplace screen bedroom and bathroom installation in the Common- and hood are in place before running appliance. The wealth of Massachusetts.
-
Page 4: Product Identification
SAFETY Continued • The flexible gas line connector used shall not exceed 36 inches (92 centimeters) in length. 6. If fireplace has glass doors, never operate this appliance with • The individual manual shut-off must be a T-handle type valve. glass doors closed. - Page 5 INSTALLATION CHECK GAS TYPE WARNING: DO NOT INSTALL IN SLEEPING Use the correct type of gas (natural or propane/LP). If your gas supply ROOM OF MOBILE HOMES. is not the correct gas type, do not install appliance. Call dealer where you bought appliance for proper type appliance.
- Page 6 Installation Continued Carefully follow the instructions below. This will ensure safe instal- Noncombustible Requirements for Safe Installation lation into a masonry, UL127-listed manufactured fireplace or listed Material Distance (A) outdoor firebox. Minimum Clearances For Side Combustible Material, 12" or more Noncombustible material OK.
- Page 7 Installation Continued MANTEL CLEARANCES NOTICE: Surface temperatures of adjacent walls and In addition to meeting noncombustible material clearances, you mantels become hot during operation. Walls and must also meet required clearances between fireplace opening and mantels above the firebox may become hot to the mantel shelf.
- Page 8 Installation Continued INSTALLING DAMPER CLAMP ACCESSORY FOR VENTED INSTALLING APPLIANCE BASE ASSEMBLY OPERATION NOTE: When used as a vented indoor appliance, appliance must be WARNING: You must secure this appliance to fire- installed only in a solid-fuel burning fireplace with a working flue and place floor.
- Page 9 Installation Continued Masonry Screw * An equipment shutoff valve with 1/8" NPT tap is an acceptable al- ternative to test gauge connection. Purchase the optional equipment shutoff valve from your dealer. For propane/LP units, the installer must supply an external regulator. The external regulator will reduce incoming gas pressure.
- Page 10 Installation Continued Test Pressures In Excess Of 1/2 PSIG (3.5 kPa) Equipment Shutoff Valve PROPANE/LP With 1/8" NPT Tap* From External 1. Disconnect appliance with its appliance main gas valve (control Regulator valve) and equipment shutoff valve from gas supply piping system. Approved Flexible Gas (11"...
- Page 11 Installation Continued INSTALLING OPTIONAL REMOTE ACCESSORIES Propane/LP Equipment Installing Remote Receiver Supply Tank Shutoff Valve Remote control accessories are available separately (see Accessories, Page 23). Read instructions shipped with remote control along with instructions below before attempting installation. 1. If unit is already installed in fireplace, continue with these instruc- tions.
- Page 12 Round Tube Burner System Model For Use With This Burner Burner System SOUTHERNCOMFORT30A/B SOUTHERNCOMFORT36A/B MAGNIFLAMEOD30NM, MAGNIFLAMEOD30PM SHADYHOLLOW30A/B SHADYHOLLOW36A/B INSTALLING LOGS AND VOLCANIC STONE WARNING: Failure to position the parts in accor- dance with these diagrams or failure to use only parts specifically approved with this appliance may result in property damage or personal injury.
- Page 13 Installation Continued Vertical Portion of Burner Tube Figure 19B - Installing Back Left Log (D-018) Rear View Figure 18C - Installing Right Front Log, Side View 3. Find the front left log (SouthernComfort30A/B or ShadyHollow30A/B 2. Find the back left log (SouthernComfort30A/B or ShadyHollow30A/B models: D-017, SouthernComfort36A/B or ShadyHollow36A/B mod-...
- Page 14 Installation Continued Square Grate Log Notch Grate Finger Log Slot Figure 21B - Installing Charred Log Top Side View Figure 20B - Installing Front Left Log 5. Find the middle split log (SouthernComfort30A/B or ShadyHollow30A/B models: D-021, SouthernComfort36A/B or 4. Find the charred log (D-020). See Figures 21, 21A, and 21B. The ShadyHollow36A/B models: D-028).
- Page 15 Installation Continued Right Split Back Top Log Crossover 6. Find the right split crossover log (D-022) The bottom of the log (D-023 or D029) Log (D-022) has a rectangular stand off that fits in the slots on the right side of the front right log and the middle split log.
-
Page 16: Operation
OPERATION FOR YOUR SAFETY 9. Slightly push in and turn control knob counterclockwise READ BEFORE LIGHTING the ON position. 10.Wait one minute and move switch to the ON position to light WARNING: If you do not follow these instructions burner. exactly, a fire or explosion may result causing property NOTE: AUTO is only functional when using optional remote control accessory. -
Page 17: Inspecting Burners
INSPECTING BURNERS Check pilot flame pattern and burner flame patterns often. Dark Orange PILOT ASSEMBLY Flames The pilot assembly is factory preset for the proper flame height. Alterations may have occurred during shipping and handling. Call a qualified service person to readjust the pilot if necessary. The height of the thermopile must be 3/8"... - Page 18 CLEANING AND MAINTENANCE Continued 6. In case any large clumps of dust have now been pushed into the LOGS burner repeat steps 3 and 4. • If you remove logs for cleaning, refer to Installing Logs and Volcanic Clean pilot assembly also. Additional cleaning may be needed for Stone, Page 12, to properly replace logs.
-
Page 19: Specifications
SPECIFICATIONS MAGNIFLAMEOD30NM MAGNIFLAMEOD30PM • Rating (Variable): 29,000/40,000 Btu/Hr • Rating (Variable): 29,000/40,000 Btu/Hr • Type Gas: Natural • Type Gas: Propane/LP • Ignition: Electronic • Ignition: Electronic • Manifold Pressure: 3.4" W.C. • Manifold Pressure: 7.9" W.C. • Inlet Gas Pressure (in. of water): •... -
Page 20: Troubleshooting
TROUBLESHOOTING WARNING: Turn off appliance and let cool before servicing. Only a qualified service person should service and repair appliance. NOTE: All troubleshooting items are listed in order of operation. OBSERVED PROBLEM POSSIBLE CAUSE REMEDY When igniter button is pressed, there is no 1. - Page 21 TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Burner does not light after pilot is lit 1. Inlet gas pressure is too low 1. Contact local natural or propane/LP gas company 2. Burner orifice(s) clogged 2. Clean burner (see Cleaning and Main- tenance, Page 16) or replace burner orifice(s) 3.
- Page 22 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Leave the building immediately •...
-
Page 23: Accessories
ACCESSORIES Purchase these appliance accessories from your local dealer. If they can not supply these accessories, contact IHP at Astria.US.com for referral information. You can also write to the address listed on the back Page of this manual. Only kits supplied by IHP shall be used in the installation of this appliance. -
Page 24: Parts
PARTS REMOTE-READY CONTROL MODELS MAGNIFLAMEOD30NM and MAGNIFLAMEOD30PM WARNING: Failure to position the parts in accordance with these diagrams or failure to use only parts specifi- cally approved with this heater may result in property damage or personal injury. Cat. No. - Page 25 PARTS REMOTE-READY MODELS MAGNIFLAMEOD30NM and MAGNIFLAMEOD30PM This list contains replaceable parts used in your appliance. When ordering parts, follow the instructions listed under Replacement Parts on Page 28 of this manual. WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP.
- Page 26 PARTS LOG SET MODELS SOUTHERNCOMFORT30A/B AND SOUTHERNCOMFORT36A/B This list contains replaceable parts used in your appliance. When ordering parts, follow the instructions listed under Replacement Parts on Page 28 of this manual. SOUTHERNCOMFORT30A/B SOUTHERNCOMFORT36A/B CAT. NO. Log Id. # CAT. NO. Log Id.
- Page 27 PARTS LOG SET MODELS SHADYHOLLOW30A/B, AND SHADYHOLLOW36A/B This list contains replaceable parts used in your appliance. When ordering parts, follow the instructions listed under Replacement Parts on Page 28 of this manual. SHADYHOLLOW30A/B SHADYHOLLOW36A/B CAT. NO. Log Id. # CAT. NO. Log Id.
-
Page 28: Replacement Parts
SERVICE HINTS REPLACEMENT PARTS When Gas Pressure Is Too Low See Pages 24-27 for a complete replacement parts list. Use only • pilot will not stay lit parts supplied from the manufacturer. • burners will have delayed ignition Normally, all parts should be ordered through your IHP distributor •... -
Page 29: Warranty
Innovative Hearth Products Astria Brand Gas Log Set & Outdoor Gas Fire Pit ® Limited Three Year Warranty THE WARRANTY Innovative Hearth Products Limited Three Year Warranty ("IHP") warrants your Astria ® brand Gas Log Set or Outdoor Gas Fire Pit ("Product") to be free from defects in materials and workmanship at the time of manufacture. - Page 30 Astria.us.com Record the following important information about your appliance: Appliance model number Appliance serial number Date appliance was Installed Type of gas appliance uses Dealer name Innovative Hearth Products (IHP) reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.
Need help?
Do you have a question about the MAGNIFLAMEOD30NM and is the answer not in the manual?
Questions and answers