All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by QM/EH 0965 BU TV Consumer Care, the Netherlands...
& drivers. Table 2-1 Described Model Numbers: Model Number Styling Published in 42PFL3604/12 Click 3122 785 18280 42PFL3604/60 Note: The given Model Numbers are subject to change. 2009-May-29...
Page 3
Technical Specifications, Connections TPS2.2E LA EN 3 Connections SER V. C 18280_001_090420.eps 090515 Figure 2-1 Connection overview Note: The following connector colour abbreviations are used 3 - HDMI: Digital Video, Digital Audio - In (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Grey, Rd= Red, Wh= White, Ye= Yellow.
Page 4
EN 4 TPS2.2E LA Technical Specifications, Connections - D0- Data channel - Audio R 0.5 V / 1 kΩ 10 - CLK+ Data channel - Audio R 0.5 V / 10 kΩ 11 - Shield - Audio L 0.5 V / 1 kΩ...
Spare Parts • Check the strain relief of the Mains/AC Power cord for proper function. For the latest spare part overview, consult your Philips Spare • Check the electrical DC resistance between the Mains/AC Part web portal. Power plug and the secondary side (only for sets that have a Mains/AC Power isolated power supply): 1.
Page 6
EN 6 TPS2.2E LA Precautions, Notes, and Abbreviation List 3.3.6 Alternative BOM identification Abbreviation List It should be noted that on the European Service website, 0/6/12 SCART switch control signal on A/V “Alternative BOM” is referred to as “Design variant”. board.
Page 7
6.5 MHz. L' is Band E-DDC Enhanced Display Data Channel I, L is all bands except for Band I (VESA standard for communication LG.Philips LCD (supplier) channel and display). Using E-DDC, Loudspeaker the video source can read the EDID LVDS Low Voltage Differential Signalling information form the display.
System on Chip Sync On Green SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4- wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board STBY STand-BY SVGA 800 ×...
Mechanical Instructions TPS2.2E LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assy/Panel Removal 4.4 Set Re-assembly.
Page 10
EN 10 TPS2.2E LA Mechanical Instructions 4.2.1 Foam Bars 4.3.3 Power Supply Unit (PSU) Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the PSU. 1. Unplug all connectors. 2.
RC-transmitter, can be navigated through the menus. 18280_201_090420.eps 090519 General • Model Philips Model type number (12 characters Figure 5-2 Factory Mode Menu maximum) • Production serial number Displays the production serial How to Navigate number of the TV. Note that if an NVM is replaced or is...
3122 785 90630. Note: While having problems, contact the local support desk. Introduction ComPair (Computer Aided Repair) is a Service tool for Philips Consumer Electronics products. and offers the following: Error Codes 1. ComPair helps to quickly get an understanding on how to repair the chassis in a short and effective way.
Alignments TPS2.2E LA EN 13 6. Alignments Index of this chapter: White Balance Adjustment 6.1 General Alignment Conditions 6.2 CVI (YPbPr) source Auto Colour Adjust 6.3.1 Equipment Requirements 6.3 White Balance Adjustment 6.4 Serial Number Definition Color analyzer. Note: The Service Alignment Mode (SAM) are described in 6.3.2 Input requirements chapter...
EN 14 TPS2.2E LA Circuit Descriptions 7. Circuit Descriptions Index of this chapter: 7.1 General Description 7.2 Main Supply 7.3 MST9B885GL Notes: • Only new circuits (circuits that are not published recently) are described. • Figures can deviate slightly from the actual situation, due to different set executions.
Page 15
Circuit Descriptions TPS2.2E LA EN 15 7.1.1 Block Diagram • EXT3: YPbPr component video input (RCA jack) with audio R/L (RCA jack) • Side AV: AV input (CVBS, RCA jack) with audio R/L (RCA The tuner supports PAL\SECAM RF signal by region, For TV jack) signal, MST9B885GL-1 embeds analog video demodulator, •...
Page 16
EN 16 TPS2.2E LA Circuit Descriptions 7.1.2 SSB Cell Layout CLASS D Flash Scaler TUNER AV Input Scart HDMI Component 18280_204_090420.eps 090518 Figure 7-2 SSB top view 2009-May-29...
Page 18
EN 18 TPS2.2E LA Circuit Descriptions MST9B885GL 7.3.1 Instruction The MST9B885GL-1 is a high performance and fully integrated IC for multi-function LCD monitor/TV with resolutions up to full HD (1920 × 1080). It is configured with an integrated triple- ADC/PLL, an integrated DVI/HDCP/HDMI receiver, a multi- standard TV video and audio decoder, a video de-interlacer, a scaling engine, the MStar ACE-3 color engine, an on-screen display controller, an 8-bit MCU and a built-in output panel...
IC Data Sheets TPS2.2E LA EN 19 8. IC Data Sheets This section shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 20
EN 20 TPS2.2E LA IC Data Sheets MST9B885GL-1-LF (IC U4201) GPIOB[1] GPIOB[0] REXT HSYNC1 USB _CID Pin 1 USB _DP VSYNC1 USB _DM VCLAMP REFP USB _VBUS REFM VDDP IRIN BIN1P SOG I N1 GIN1P DDCA_SCL DDCA_SDA RIN1P VCOM2 DDCR_SCL DDCR_SDA BIN0P PWM1...
Page 21
IC Data Sheets TPS2.2E LA EN 21 WT6703F-SG240WT (IC U4101) Block Diagram Turbo 8051 MCU 8K bytes code flash 8051 UART, Timer0, Timer1 Internal 256 bytes SRAM Eternal 128 bytes SRAM Slave IIC 32K Oscillator HV DPMS Detector RC Oscillator IR Detector Reset Processor Clock Processor...
Page 22
EN 22 TPS2.2E LA IC Data Sheets TPS62203DBVRG4 (IC U7101) Block Diagram Current Limit Comparator Undervoltage Lockout Bias Supply Skip Comparator Soft Start 1 MHz (COMP) Oscillator P-Channel Power MOSFET Comparator Driver Shoot-Through Control Sawtooth Logic Logic Generator N-Channel Comparator High Power MOSFET Comparator Low Comparator Low 2...
Page 23
IC Data Sheets TPS2.2E LA EN 23 DRV601RTJR (IC U1201,U1901,U6101) Block Diagram SVDD Short SVSS Circuit SGND SVDD Protection SVSS C 1P Charge Bias Pump Circuitry C 1N PVSS Pin Configuration PGND PVSS OUTR 18280_304_090420.eps 090519 Figure 8-5 Internal block diagram and pin configuration 2009-May-29...
Page 24
EN 24 TPS2.2E LA IC Data Sheets MX25L1605DM2I-12G (IC U4402) Block Diagram Address Generator Memory Array Page Buffer Data SI/SIO0 Register Y-Decoder SO/SIO1 SRAM Buffer Sense CS#, Amplifier Mode State WP#/ACC, Logic Machine HOLD# Generator SCLK Clock Generator Output Buffer Pin Configuration HOLD# SO/SIO1...
Circuit Diagrams and PWB Layouts TPS2.2E LA EN 36 SSB: Video Input & CVBS Output AP/China n.c. n.c. CVBS Out With S-Video: CN1203 Without S-Video: CN1206 Placement should be close to chip side Audio output impedance maximum 1kΩ 18280_505_090420.eps 090525 2009-May-29...
Circuit Diagrams and PWB Layouts TPS2.2E LA EN 42 SSB: Scaler MST6B885GL-1 Without WT6703F: R4262 = 0Ω & AP/China: R4301, R4302 n.c. : R4301 = 47 Ω, R4302 = 10 kΩ AP/China: R4226 = 10 kΩ : R4226 = 3.3 kΩ, without WT6703F, R4261 = 0 Ω 18280_511_090420.eps 090420 2009-May-29...
Page 43
Circuit Diagrams and PWB Layouts TPS2.2E LA EN 43 SSB: WT6703F Standby MCU 18280_512_090420.eps 090420 2009-May-29...
Page 44
Circuit Diagrams and PWB Layouts TPS2.2E LA EN 44 SSB: Flash ROM & Memory Ripple voltage reduction DDR 2M × 16 bit × 4 Banks 18280_513_090420.eps 090420 2009-May-29...
Page 45
Circuit Diagrams and PWB Layouts TPS2.2E LA EN 45 SSB: Key, IR BD, & Compair I/F l a i 18280_514_090420.eps 090420 2009-May-29...
Page 46
Circuit Diagrams and PWB Layouts TPS2.2E LA EN 46 SSB: Panel I/F " 2 " 6 18280_515_090420.eps 090420 2009-May-29...
Page 47
Circuit Diagrams and PWB Layouts TPS2.2E LA EN 47 SSB: iTV I/F and AOC Hotel 18280_516_090420.eps 090420 2009-May-29...
Page 48
Circuit Diagrams and PWB Layouts TPS2.2E LA EN 48 SSB: USB Close to connector 18280_517_090420.eps 090420 2009-May-29...
Page 49
Circuit Diagrams and PWB Layouts TPS2.2E LA EN 49 SSB: Audio/AMP 18280_518_090420.eps 090420 2009-May-29...