Table of Contents
Advertisement
General
Information
Thank you for purchasing your
Low Pressure Sewer Basin System.
Before Installation:
This manual contains important
information for the safe use of
this product. Read this manual
completely
and
follow
instructions carefully. Reasonable
care and safe methods relating
to the installation and operation
of
this
product
practiced. Check local codes and
requirements before installation.
Risk of electrical shock or
electrocution.
May
in serious injury or death or
fire hazard. Installer must
disconnect all electrical sources
prior
to
installation.
qualified personnel may install
this system. NFPA 70/National
Electric Code (NEC) or local
codes must be followed. System
must be properly grounded
according to NEC.
Biohazard
risk.
wastewater source has been
connected to system, biohazard
risk exists. Installer(s) and/
or service personnel must use
proper
Personal
Equipment and follow handling
procedures per OSHA 29 CFR
1910.1030
when
equipment after wastewater
source has been connected to
the system.
2
Risk of fire or explosion. Do not
smoke or use open flames in or
around this system. This system is
not intended for use in hazardous
locations per NFPA 70 National
Electric Code. Consult factory
for optional equipment rated for
this use.
Cutting risk. Risk of serious
the
cutting or amputation exists.
Disconnect all power sources
prior to servicing pump or
grinding mechanism. Pump may
should
be
start without warning. Grinding
mechanism is extremely sharp.
Use caution when handling
grinder mechanism.
result
Hydromatic does not recommend
basins with base/bottom diameters
greater than 30" when installing
Only
a simplex Positive Displacement
pump (HPD200) system. When
operational conditions require a
basin with base/bottom diameter
of greater than 30" it is necessary
to perform a sludge pump-out
on the basin at least once per
year to prevent any septic/odor
conditions.
Once
the
DO NOT THROW AWAY OR
LOSE THIS MANUAL. Keep it
in a safe place so that you may refer
to it often for the continued safe
operation of the product.
Protective
CALIFORNIA PROPOSITION
handling
65 WARNING:
related
chemicals known to the State of
California to cause cancer, birth
defects or other reproductive
harm.
This product and
accessories
contain
Installation Skill
Requirements
The installation of a basin system
is a specialized skill, which
requires individuals with the basic
understanding of excavating, pipe
fitting, and electrical wiring.
These instructions are meant only to
be an installation guide; therefore,
unusual installation conditions not
covered in these instructions require
experienced personnel capable
of using reasonable engineering
principles for the installation and
operation of the system.
Excavation
Instructions
Excavation location shall be
made according to local codes
and regulations. Check with
local utility companies for
the location of underground
utilities prior to excavation.
Care should be taken to avoid
buried utility lines, piping, and
other buried structures and
foundations. Failure to follow
these instructions may result
in serious personal injury or
death.
Excavation for Basin Systems:
Effect
appropriate
based on size of the basin, desired
entrance point of the influent line,
and entrance of power connection.
excavation
Advertisement
Table of Contents
