Table of Contents
Advertisement
Quick Links
Download this manual
See also:
Service Manual
OPERATOR MANUAL
IMPORTANT INFORMATION, KEEP FOR OPERATOR
This manual provides information for:
MODELS CBE-10G
& (2) CBE-10G
COMBOEASE
· Self Contained
· Gas Heated
· Capacity:
CBE-10G = 10 Steamer Pans Per Cavity
or 10 Full Size Baking Sheets Per Cavity
THIS MANUAL MUST BE RETAINED FOR FUTURE REFERENCE.
READ, UNDERSTAND AND FOLLOW THE INSTRUCTIONS AND
WARNINGS CONTAINED IN THIS MANUAL.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
POST IN A PROMINENT LOCATION
Instructions to be followed in the event user smells
gas. This information shall be obtained by consulting
your local gas supplier. As a minimum, turn off the gas
and call your gas company and your authorized service
agent. Evacuate all personnel from the area.
WARNING
Improper installation, adjustment, alteration, service
or maintenance can cause property damage, injury or
death. Read the installation, operating and maintenance
instructions thoroughly before installing or servicing this
equipment.
NOTIFY CARRIER OF DAMAGE AT ONCE
It is the responsibility of the consignee to inspect the container upon receipt of
same and to determine the possibility of any damage, including concealed dam-
age. Unified Brands suggests that if you are suspicious of damage to make a
notation on the delivery receipt. It will be the responsibility of the consignee to file
a claim with the carrier. We recommend that you do so at once.
Manufacture Service/Questions 888-994-7636.
Information contained in this document is known to be current and accurate at the time
of printing/creation. Unified Brands recommends referencing our product line websites,
unifiedbrands.net, for the most updated product information and specifications.
PART NUMBER 155492, REV. D (12/10)
1055 Mendell Davis Drive
Jackson, MS 39272
888-994-7636, fax 888-864-7636
unifiedbrands.net
Advertisement
Table of Contents
Related Manuals for Groen CBE-10G
Summary of Contents for Groen CBE-10G
- Page 1 COMBOEASE · Self Contained · Gas Heated · Capacity: CBE-10G = 10 Steamer Pans Per Cavity or 10 Full Size Baking Sheets Per Cavity THIS MANUAL MUST BE RETAINED FOR FUTURE REFERENCE. READ, UNDERSTAND AND FOLLOW THE INSTRUCTIONS AND WARNINGS CONTAINED IN THIS MANUAL.
-
Page 2: Important Operator Warnings
THAT IS ALKALINE. WARNING: USE OF ANY REPLACEMENT PARTS OTHER THAN THOSE SUPPLIED BY GROEN OR THEIR AUTHORIZED DISTRIBUTOR VOIDS ALL WARRANTIES AND CAN RESULT IN BODILY INJURY TO THE OPERATOR AND DAMAGE THE EQUIPMENT.SERVICE BY OTHER THAN FACTORY-AUTHORIZED PERSONNEL WILL VOID ALL WARRANTIES. -
Page 3: Table Of Contents
60 Batterymarch Park Quincy, Massachusetts 02269 NFPA/70 The National Electrical Code NFPA/54 The National Fuel Gas Code NSF INTERNATIONAL 789 N. Dixboro Rd. P.O. Box 130140 Ann Arbor, Michigan 48113 CSA INTERNATIONAL 8501 Ease Pleasant Valley Road Cleveland, Ohio 44131 OM-CBE-10G 3... -
Page 4: Equipment Description
Equipment Description Your Groen Combination Oven is a stainless steel cooking chamber consisting of an air heating compartment with fan, a boilerless steam generator, and a control compartment which houses electrical components. All major components of the Combination Oven are encased in a heavy duty stainless steel cabinet. - Page 5 BURNER FIRING RATES INPUT RATES, BTU/HOUR NATURAL GAS LP GAS MODE at 3.5” W.C.* at 10.0” W.C.* Oven 75,000 75,000 Steam 75,000 75,000 Combo 75,000 75,000 *Manifold Pressure OM-CBE-10G 5...
-
Page 6: Inspection And Unpacking
FROM THE SKID AND MOVE IT TO ITS PLACE the back of this manual. OF INSTALLATION. When starting installation, use material handling equipment to lift the unit straight up off the skid. Check packing materials to make sure loose parts are not discarded with the material. OM-CBE-10G... -
Page 7: Water Quality And Treatment
(TDS) and should have a pH (acidity rating) of 7.0 to 9.0. Please follow these simple precautions: The best way to prevent scale is to use a Groen PureSteam™ Water Treatment System which has been specifically designed for Groen steamers and combination ovens. -
Page 8: Installation
The unit must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than ½ psi (3.5 kPa). OM-CBE-10G... - Page 9 Connection to the gas supply shall be ½” NPT pipe size. Double stack units WITH RESTRAINING REQUIREMENT AS LISTED. require 2 separate gas connections. NOTE: For operation at high altitudes (2000’ and above), please consult Groen Engineering Department. Ratings for Gas Combination Oven...
- Page 10 There must also be no other elbows or restrictions between the unit drain and the free air gap. WATER TRAP Install the drain line with a constant downward pitch. BUILDING DRAIN IMPROPER DRAIN LINE CONNECTION BUILDING DRAIN AIR GAP OM-CBE-10G...
-
Page 11: Installation
Separate gas connections are required for both units. Gas supply must be adequate under all conditions as listed on the previous page. Drain Connection For all factory-stacked units, a 1-½ inch ID hose is attached to the unit drain. It must be rated for boiling water. OM-CBE-10G 11... -
Page 12: Initial Start-Up
Press the LIGHT button to turn on interior lights. The lights will automatically turn off after aproximately 30 seconds. If the unit operates as described, the unit is functioning correctly and ready for USE. NOTE: For operation at high altitudes (2000 ft. and above), please consult the Groen Engineering Department. OM-CBE-10G... -
Page 13: Controls
ON side to start the unit and OFF side to shut unit down. It is recommended that this switch be used once or twice per day at the beginning of cooking period. Hour meter: Shows the unit’s total hours of operation. OM-CBE-10G 13... -
Page 14: Operation
5000 BTU, while also draining reservoirs to eliminate additional moisture addition. To Re-Light Push power switch to OFF. Wait 5 minutes, then repeat step 1. To Shut-Off Push power switch to OFF. Close gas valve on rear left of unit. OM-CBE-10G... - Page 15 1. Always wear suitable gloves and protective safety glasses. Failure to do so can cause serious burns. 2. Take precautions to keep chemicals from contacting your skin. 3. Keep the chemical(s) away from the door gasket and front control panel gasket. Failure to do so can drastically reduce gasket life. OM-CBE-10G 15...
- Page 16 Any maintenance and repair to the unit must be performed by qualified service personnel. It is recommended that all service be performed by Groen or their authorized agent. Contact factory to locate a qualified agent.
-
Page 17: Sequence Of Operation
Fill timeout could also mean that the water pressure is very low or the main water valve is turned off. Drain timeout could mean that the drain is plugged and should be cleaned. OM-CBE-10G 17... - Page 18 The condensate spray is turned off when not draining to conserve water. 10. Spray Nozzle The spray nozzle is used in the clean cycle to rinse the cavity walls. Both of the nozzles should be oriented with the flats vertical and the slots up. (see photo) OM-CBE-10G...
-
Page 19: Maintenance
A leaking gasket could cause severe burns. Replace the gasket as needed. If your unit is equipped with Groen supplied stand and optional pan racks, check the pan racks for a secure fit. If they are loose and not level, reinstall them properly or call your authorized service agency. -
Page 20: Cleaning
The message PUSH CLEAN TO FINISH CLEANING appears in the display. No other cooking mode buttons will operate. When the clean cycle is complete the oven turns off. The oven can then be turned on and operate in any mode. OM-CBE-10G... -
Page 21: Cleaning
PUSH CLEAN TO FINISH CLEANING. The oven enters the clean cycle at the rinse step to remove all delimer from the reservoirs and it shuts itself off. It can then be turned on and operated in any mode. OM-CBE-10G 21... -
Page 22: Service Log
Service Log Model No: Purchased From: Serial No: Location: Date Purchased: Date Installed: Purchase Order No: For Service Call: Date Maintenance Performed Performed By OM-CBE-10G... - Page 23 NOTES: OM-CBE-10G 23...
- Page 24 1055 Mendell Davis Drive • Jackson MS 39272 888-994-7636 • 601-372-3903 • Fax 888-864-7636 unifiedbrands.net PART NUMBER 155492 REV D (12/10) © 2010 Unified Brands. All Rights Reserved. Unified Brands is a wholly-owned subsidiary of Dover Corporation.