Intertek MES80 Installation Instructions Manual page 3

Always install a furnace to operate within the furnace's in-
tended temperature-rise range with a duct system which has
external static pressure within the allowable range, as speci-
fied on the furnace rating plate and OPERATIONAL CHECKS
section of these instructions.
When a furnace is installed so that supply ducts carry air cir-
culated by the furnace to areas outside the space containing
the furnace, the return air shall also be handled by duct(s)
sealed to the furnace casing and terminating outside the space
containing the furnace.
A gas-fired furnace for installation in a residential garage must
be installed as specified in the LOCATION REQUIREMENTS
AND CONSIDERATIONS section of this manual.
This furnace may be used as a construction site heater only if
certain conditions are met. These conditions are listed in the
PRODUCT APPLICATION section of this manual.
T
O PREVENT PERSONAL INJURY OR DEATH DUE TO IMPROPER
,
INSTALLATION ADJUSTMENT
. F
REFER TO THIS MANUAL OR ADDITIONAL ASSISTANCE OR
,
INFORMATION CONSULT A QUALIFIED INSTALLER
.
THE GAS SUPPLIER
WARNING
FIRE OR EXPLOSION HAZARD
Failure to follow the safety warnings exactly could result
in serious injury, death or property damage.
Never test for gas leaks with an open flame.
Use a commercially available soap solution made
specifically for the detection of leaks to check all
connections. A fire or explosion may result causing
property damage, personal injury or loss of life.
AVERTISSEMENT
RISQUE D'INCENDIE OU D'EXPLOSION
Si les consignes de sécurité ne sont pas suivies à la lettre,
cela peut entraîner la mort, de graves blessures ou des
dommages matériels.
Ne jamais vérifier la présence de fuites de gaz au moyen
d'une flamme nue. Vérifier tous les raccords en utilisant
une solution savonneuse commerciale conçue
spécialement pour la détection de fuites. Un incendie ou
une explosion risque de se produire, ce qui peut entraîner
la mort, des blessures ou des dommages matériels.
WARNING
, ,
ALTERATION SERVICE OR MAINTENANCE
,
SERVICER AGENCY OR
I
F THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED
,
EXACTLY A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY
,
DAMAGE PERSONAL INJURY OR LOSS OF LIFE
D
O NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND
LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE
WHAT TO DO IF YOU SMELL GAS:
D
O NOT TRY TO LIGHT ANY APPLIANCE
D
O NOT TOUCH ANY ELECTRICAL SWITCH
IN YOUR BUILDING
I
MMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR
. F
PHONE OLLOW THE GAS SUPPLIER
I
F YOU CANNOT REACH YOUR GAS SUPPLIER
.
DEPARTMENT
I
NSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED
,
INSTALLER SERVICE AGENCY OR THE GAS SUPPLIER
H
EATING UNIT SHOULD NOT BE UTILIZED WITHOUT REASONABLE
,
ROUTINE INSPECTION
,
BUILDING IN WHICH ANY SUCH DEVICE IS LOCATED WILL BE VACANT
CARE SHOULD BE TAKEN THAT SUCH DEVICE IS ROUTINELY INSPECTED
MAINTAINED AND MONITORED
MAYBE EXPOSED TO FREEZING TEMPERATURES AND WILL BE VACANT
-
ALL WATER BEARING PIPES SHOULD BE DRAINED
BE PROPERLY WINTERIZED
EVENT THAT THE BUILDING MAY BE EXPOSED TO FREEZING
TEMPERATURES AND WILL BE VACANT
SHOULD BE DRAINED AS WELL AND
SOURCES SHOULD BE UTILIZED
S
HOULD OVERHEATING OCCUR OR THE GAS SUPPLY FAIL TO SHUT OFF
TURN OFF THE MANUAL GAS SHUTOFF VALVE EXTERNAL TO THE
FURNACE BEFORE TURNING OFF THE ELECTRICAL SUPPLY
P
OSSIBLE PROPERTY DAMAGE
, ,
FIRE EXPLOSION SMOKE
OR CARBON MONOXIDE MAY RESULT FROM IMPROPER INSTALLATION
,
REPAIR OPERATION OR MAINTENANCE OF THIS PRODUCT
T
O PREVENT PERSONAL INJURY OR DEATH DUE TO ASPHYXIATION
C
FURNACE MUST BE ATEGORY
C III
ATEGORY VENTING
P
ROVISIONS MUST BE MADE FOR VENTING COMBUSTION PRODUCTS
OUTDOORS THROUGH A PROPER VENTING SYSTEM
FLUE PIPE COULD BE A LIMITING FACTOR IN LOCATING THE FURNACE
3
WARNING
.
.
;
DO NOT USE ANY PHONE
.
'
S INSTRUCTIONS
,
CALL THE FIRE
.
WARNING
,
MAINTENANCE AND SUPERVISION
.
IN THE EVENT THAT THE BUILDING
,
THE BUILDING SHOULD
,
AND THE WATER SOURCE CLOSED
,
ANY HYDRONIC COIL UNITS
, ,
IN SUCH CASE ALTERNATIVE HEAT
.
WARNING
WARNING
,
PERSONAL INJURY OR DEATH DUE TO
, , ,
SOOT CONDENSATION ELECTRICAL SHOCK
WARNING
I . D
VENTED O NOT VENT USING
.
. T
HE LENGTH OF
.
'
S
.
,
. I
F THE
,
,
,
.
IN THE
,
.
,
.
,
THIS
.