Page 12
A8800136 Illustration A Remove the loudspeaker grille as follows: Insert the tool, Volvo P/N 999-5919-46 in the joint between the loudspeaker grille and the dashboard approximately as illustrated, until it engages. Twist the tool 90° so that the bent section engages with the underneath of the loudspeaker grille.
Page 13
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the screws (1). Remove the bracket (2). Place the console to one side, it shall not be used again. M3902613 Applies to cars with centre loudspeakers Remove the four screws in the loudspeaker (1).
Page 14
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Steps 5 – 9 apply to cars up to and including model year – 2004 Remove the panel in front of the gear selector lever. Pry off the panel using a plastic weatherstrip tool.
Page 15
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the two screws from the dashboard environment panel. M8503027 Angle the dashboard environment panel outwards so that it is possible to insert a couple of fingers between the centre console and the reverse of the panel.
Page 16
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the screws from the radio bracket. Pull out the bracket with the radio. Pull the lower corner while pressing downwards. Detach the connectors from the radio and from the keypad to the telephone if fitted.
Page 17
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Engage the handbrake and move the gear selector lever towards the rear. Turn the cover panel to the left for better access. Remove the two screws holding the bracket with the radio and dashboard environment panel in the centre console.
Page 18
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Preparations, dashboard Lock the steering wheel in the lowest, rearmost position. Remove the rubber seal from the upper steering column cover by carefully prying the 5 catches loose using a weatherstrip tool.
Page 19
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the four screws for the combined instrument panel. Pull out the combined instrument panel. Disconnect the connector on the reverse of the combined instrument panel. Place the combined instrument panel to one side.
Page 20
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Press the bracket against the mating surfaces where the three holes are to be drilled. Hold the bracket firmly in place. First drill the two marked holes through the bracket and the dashboard. Use a Ø5 mm (13/64") diameter drill bit.
Page 21
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Preparations, passenger compartment and cargo compartment Remove the side panel (1) on the centre console. First twist the clip at the rear edge of the panel a 1/4 turn. Pull the rear edge of the panel outwards and backwards.
Page 22
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Fold the left-hand rear seat cushion forward (1). Fold the left hand rear backrest (2) forward. M8502805 Remove the left-hand side cushion by pulling the upper edge backwards and lifting it slightly upwards.
Page 24
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Detach the storage box under the rear floor hatch by turning the clips on the left and right-hand sides. Turn each clip a 1/4 turn. Lift out the box. M8503121 Remove the left-hand folding side panel in the cargo compartment.
Page 25
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the left side panel. Remove the cover and the screw from the front edge. Pull the top of the panel inwards until the clips release. Fold the panel in and lift it out. Place the side panel to one side.
Page 26
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the fuse holder by opening the catch (1) on the top of the fuse holder. Following which, fold the holder forward and lift it from the brackets (2). M3703515 Remove the black insulation panel by first removing the four clips, and then pull away the panel down/back starting at the rear edge.
Page 27
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Installing the screen holder and centre loudspeaker Take the holder for the screen from the kit and cut away the attached washer. It shall be used in step 34. File away the burrs on the washer and holder.
Page 29
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Take two screws from the kit and tighten the connector to the holder. M3905170 Take the console which secures the complete unit in the dashboard from the kit. Align the screen's holder in the console and attach it with a screw from the kit.
Page 30
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Take the loudspeaker from the kit. Install the loudspeaker in the console together with the screen's holder, with screws from the kit. The loudspeaker must be aligned with the cable connectors to the right in the car.
Page 31
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Installing the GPS antenna Take the bracket to the GPS antenna from the kit and clean the marked surface using isopropanol P/N 1161721. Wipe dry. M8903912 Take the GPS antenna from the kit and clean the underneath using isopropanol P/N 1161721.
Page 32
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Take the double-sided adhesive tape from the kit and remove the white backing film from the tape. M8903882 Press in the double-sided adhesive tape firmly on the underneath of the GPS antenna.
Page 34
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Install the GPS antenna as far into the combined instrument panel compartment as possible. Take the tie strap with clip from the kit and remove the tie strap from the clip. Press the GPS antenna clip (1) into the existing hole. Tighten the antenna using the screw (2) from the kit.
Page 35
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Installing the remote control holder Step 47 only applies to cars without handsfree telephone. Fit the remote control holder to the bracket. Use the existing plastic screws fitted in the bracket. M3905164...
Page 36
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to cars up to and including model year -2004 Route the cables along the rear cable duct (1). If necessary, detach the connectors in the cable duct and position the three cables beneath them.
Page 37
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to cars from and including model year 2005- Lift the panel and insert the ground lead in the gap between the floor support (1) and the panel (2). Insert the cable as far under the panel as possible. Ensure that the cable is not trapped.
Page 38
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Connection to the relay box Remove the screw in the panel to the bonnet release and remove the bonnet release from the side of the body. Thread the bonnet release through the hole in the carpet and fold the carpet away from the side of the body.
Page 39
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Steps 55–58 apply to cars from and including model year 2005– Remove the 60-pin black connector from the rear side/underneath of the relay box on the left-hand side under the dashboard. First press in the release button at the blue catch, following which turn the catch as far as possible until the connector releases.
Page 40
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Connection in connector Install the cable terminal P/N 9442486 from the kit on the routed black/white (SB/W) solid core wire. Connect the black/white (SB/W) solid core wire to position 59 in the connector. The positions are marked with small figures on end faces of the connector.
Page 41
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Splicing with insulated, water-resistant splicing sleeve Illustration A Select a suitable splicing sleeve based on the area of the cable. See table. Colour Cable area mm² Stripping length mm Green/White 0.3 - 0.5 0.5 - 1.0...
Page 42
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Press the legs of the pliers completely together to ensure a proper splice. The pliers will then release automatically. With your hand, check that the crimping sleeve is securely in place. A3700181...
Page 43
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden A3700190 Steps 62–64 apply to cars up to and including model year –2004 Insert a screwdriver up between the bracket and relay box. Turn the screwdriver so that the bracket expands. At the same time pull the bracket out towards the lower edge of the dashboard.
Page 44
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Undo the screw holding the connector so that it releases from the threads. Feel with your fingers to release the screw. Caution! Take care not to damage the terminal pins. Detach the connector using pliers. Grip the screw and pull it straight out so that the connector and cover follow too.
Page 45
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Installing the CD drive in the console Take the CD drive from the kit. Remove the screw to the adapter and remove the adapter on the side of the CD drive. Do this on both sides.
Page 47
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Press in the Velcro fastener centrally on the rear section of the console. Press hard so that it is firmly secured. M3905254 Take the CD drive from the kit and clean the marked surface on the underside using isopropanol P/N 1161721.
Page 48
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Take a Velcro fastener from the kit and remove the protective tape. A0000334 Press in the Velcro fastener in the centre of the rear section of the CD drive. Press hard so that it is firmly secured.
Page 49
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Insert the CD drive into the console. Fit the two screws from the kit in the console and CD drive. Press in the rear end of the CD drive against the console so that the Velcro fasteners secure.
Page 50
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to cars with towbar from and including model year 2005- Connect: the cable (1) with yellow connector in the routed cable harness to the CD drive, furthest to the left in the connector...
Page 51
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Press the panel into place. Reinstall the screws in the panel. Tighten. M3703650 Applies to cars without towbar up to and including model year -2004 Illustration A Connect: the cable (1) with yellow connector in the routed cable harness...
Page 52
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden from the kit. Applies to cars with towbar up to and including model year -2004 Illustration A Connect: the cable (1) with yellow connector in the routed cable harness to the CD drive, furthest to the left in the connector...
Page 53
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Installing the TMC receiver, only applies to cars in Europe Take the TMC receiver from the kit and clean the marked surface on the underside using isopropanol P/N 1161721. Wipe dry. M3905189 Take two of the long Velcro fasteners from the kit and cut them into four pieces of equal length.
Page 54
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Illustration A Remove the protective tape from two of the cut Velcro fasteners. Illustration B Press in the Velcro fasteners on the underside of the TMC receiver, approximately in the positions illustrated.
Page 56
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Position the TMC receiver on the top of the CD drive as illustrated (rear edge is edge to edge with the rear edge of the CD drive and centred in the middle) and press it in. Press in firmly so that the tape adheres.
Page 57
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove all screws in the tailgate sill trim panel. M8503123 Take the solid core wire from the kit and lay it along the tailgate sill trim panel. Note! The cable end with the angled connector must be on the left- hand side.
Page 58
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Detach the cable and remove the existing amplifier on the right- hand side of the right rear side member, under the right-hand rear lamp. Take the antenna amplifier (1) from the kit. Connect the cable (2) to the connector (3) for the antenna in the rear bumper by the right-hand tail lamp.
Page 59
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Connection to CD drive and TMC receiver, only applies to cars in Europe Applies to cars without towbar from and including model year 2005- Connect: the cables (1) with yellow, green and blue connectors in the...
Page 60
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden The two grey connectors shall not be used. Clamp them up together with all excess cables using a tie strap from the kit, on the left-hand side in the rear edge of the wheel housing in a suitable way, so that there is no rattling.
Page 61
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden lamp to the TMC receiver the cable (6) in the adapter wiring from the kit, with large black and grey connectors, to the corresponding connector in the routed cable harness the cable (7) in the adapter wiring routed earlier to the rear...
Page 62
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden lamp to the TMC receiver the cable (6) in the adapter wiring from the kit with large black and grey connectors, to the corresponding connector in the routed cable harness the cable (7) in the adapter wiring routed earlier to the rear...
Page 63
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Take the new insulation panel from the kit and fit it above the CD drive and brackets to the fuse holder. On cars with TMC receiver the punched out cover may need cutting further in the edges so that the unit has space.
Page 65
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Take the screen from the kit and press it into its holder/connector. M3905191 Take the remote control from the kit, fit batteries and press it into the holder, if fitted. M3905176 Turn the ignition key to position II.
Page 66
Do not forget this! Illustration B Volvo menu M3905305 The system now starts up with the Volvo logo and is ready for use. Applies only if the car has AEM and the Radio Mute function is desired The function mutes the radio when there are navigation messages.