Advertisement
Advertisement
Related Manuals for R-Can Sterilight SC1
Summary of Contents for R-Can Sterilight SC1
- Page 1 Manufactured in Canada by: 425 Clair Road West P.O. Box 1719 Guelph, ON N1L 1R1 Canada EPA# 57987-CN-001 t. 519 763 1032 f. 519 763 5069 January 2008 e. water@r-can.com i. www.r-can.com P/N 520074...
- Page 2 Government and most states to determine whether or not spent fluorescent lamps should be characterized as hazardous waste. Recycle ... • R-Can encourages the recycling of all spent UV lamps at the end of lamp life. Please refer to www.lamprecycle.org for information on recycling regulations in your area.
-
Page 3: Table Of Contents
Table of contents: Parts / Schematic Breakdown Safety Instructions Water Chemistry Installing Your UV Disinfection System Operating and Maintenance Instructions Fluence (Dose) Curves Manufacture’s Warranty Specifications 10-11 symbols: Protective Caution Ground Electrical Fragile Warning Eye Protection AC Current... - Page 4 Parts: integral ballast and lamp connector with green LED lamp/power indicator 2 meters (6.5‘) power cord retaining clip Hard glass, coated Sterilume EX UV ®- lamps for long, consistent life (9000 hours) S212RL FOR SC1, SC1/2 S287RL FOR SC2.5, SC2.5/2 S330RL FOR SC4, SC4/2 aluminum gland nut...
-
Page 5: Safety Instructions
safety Instructions: WARNING - to guard against injury, basic safety precautions should be observed, including the following: 1. ReAD AND FoLLoW ALL SAFeTY INSTRuCTIoNS. 2. CAuTIoN - Always disconnect power before servicing. 3. DANGeR - To avoid possible electric shock, special care should be taken since water is present near electrical equipment. -
Page 6: Water Chemistry
Water chemistry: Water quality is extremely important for the optimum performance of your UV system. The following levels are recommended for installation: • Iron: < 0.3 ppm (0.3 mg/L) • Hardness*: < 7 gpg (120 mg/L) • Turbidity: < 1 NTU •... -
Page 7: Installing Your Uv Disinfection System
Installing your UV Disinfection system: • The ideal installation is vertical, with the inlet at the bottom and the outlet at the top (side). • The complete water system, including any pressure or hot water tanks, must be disinfected before start up by flushing with chlorine (household bleach) to destroy any residual contamination. - Page 8 1. For shipping purposes, the UV lamp is shipped in a separate cardboard tube. Carefully remove the UV lamp from the shipping tube being careful not to touch the glass portion with your fingers. Insert the UV lamp into the quartz sleeve and chamber making sure the connection end is inserted last.
-
Page 9: Operating And Maintenance Instructions
Operating & Maintenance Instructions: Caution: prior to performing any work on the disinfection system, always disconnect the power supply first. UV Lamp Replacement / Cleaning: 1. To replace the lamp, there is NO need to disconnect the system from the water supply, nor to drain the water from Figure 1 the reactor chamber. - Page 10 Quartz Sleeve Replacement / Cleaning: 1. If the water contains any hardness minerals (calcium or magnesium), iron or manganese, the quartz sleeve will require periodic cleaning. To remove the quartz sleeve, first remove the UV lamp as outlined in step 1-4 (page 6) then perform the following steps: Figure 5 Caution: prior to performing any work on the...
-
Page 11: Fluence Dose Curves
Fluence Dose curves: sc1 & sc1/2 sc2.5 & sc2.5/2 sc4 & sc4/2... -
Page 12: Manufacture's Warranty
Manufacture’s Warranty: Manufacturer warrants the ultraviolet disinfection system hardware and electrical systems to be free from defects in material and workmanship for a period of three (3) years from the date of purchase by the original owner (consumer) on a pro-rated basis. -
Page 13: Specifications
15.9 lpm (4.2 gpm) 28.4 lpm (7.5 gpm) 16mJ/cm (0.45 m /hr) (0.95 m /hr) (1.70 m /hr) R-Can Standard 4 lpm (1 gpm) 9.5 lpm (2.5 gpm) 15 lpm (4 gpm) 30 mJ/cm (0.24 m /hr) (0.57 m /hr) (0.91 m... -
Page 14: Specifications
15.9 lpm (4.2 gpm) 28.4 lpm (7.5 gpm) 16mJ/cm (0.45 m /hr) (0.95 m /hr) (1.70 m /hr) R-Can Standard 4 lpm (1 gpm) 9.5 lpm (2.5 gpm) 15 lpm (4 gpm) 30 mJ/cm (0.24 m /hr) (0.57 m /hr) (0.91 m...