Table of Contents
Advertisement
Operation
Manual
Product Valves
Door-Display
Connector
Cable
Power Switch
(on side)
Drip Tray
Product Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Important . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Unpacking and Setup. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Initial Cleaning and Sanitizing . . . . . . . . . . . . . . . . . . . . . . . .
Loading the Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Calibrating the Unit / Adjusting Shot Size . . . . . . . . . . . . . . .
Setting Time and Date . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation - General. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
P
RINCE
355 East Kehoe Blvd. • Carol Stream, IL 60188 USA
Telephone: 630-462-8800 • Toll Free: 1-800-PCASTLE
Fax: 630-462-1460 • www.princecastle.com
36948-EN
Product Identification
Display Panel
USB Port
Cup Guide
Power Cord
TABLE OF CONTENTS
C
LLC
ASTLE
W O R L D W I D E
Home Button
Up Arrow
(under)
Silver King tubes (Part No.
DCP SKU 711490) must be on order for this unit.
1
Operation - Dispensing a Drink . . . . . . . . . . . . . . . . . . . . . . . 10
Operation - Refilling the Product Tanks . . . . . . . . . . . . . . . . 11
2
3
Operation - Changing the Temperature Set Point . . . . . . . . . 12
3
Operation - Setting Coolatta Base. . . . . . . . . . . . . . . . . . . . . 13
3
Cleaning and Maintenance - General . . . . . . . . . . . . . . . . . . 14
3
Drip Tray Cleaning and Daily Wipe Down . . . . . . . . . . . . . . . 14
4
Cleaning the Product Tanks . . . . . . . . . . . . . . . . . . . . . . . . . 15
5
Refrigerated Product Compartment Cleaning . . . . . . . . . . . . 16
6
Cleaning Exterior of Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
7
Shot Size Targets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
8
Troubleshooting Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
9
Parts List and Exploded View . . . . . . . . . . . . . . . . . . . . . . . . 19
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
3-Product
Dairy Dispenser
Model SKBD3LS
LCD Display
Select Button
Back Button
S E L E C T
P P
R
O D U C T
M I L K
C R
M
S K I M
Down Arrow
LEDs
Size Buttons
Recipe Buttons
Product Buttons
IMPORTANT
37222/
Printed in USA 10/13 © 2013
Advertisement
Table of Contents
Related Manuals for Silver King SKBD3LS
Summary of Contents for Silver King SKBD3LS
-
Page 1: Table Of Contents
Power Switch (on side) Power Cord IMPORTANT (under) Silver King tubes (Part No. 37222/ Drip Tray DCP SKU 711490) must be on order for this unit. TABLE OF CONTENTS Product Identification ....... -
Page 2: Limited Warranty
W O R L D W I D E Limited Warranty This Silver King branded product is warranted to be free from • Damage to coated surfaces is not covered by this Limited defects in material and/or workmanship for a period of two (2) Warranty. -
Page 3: Safety Information
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Safety Information General The 3-Product Dairy Dispenser is designed to house, refrigerate WARNING and dispense three dairy products (2% or whole milk, cream, and skim milk). -
Page 4: Unpacking And Setup
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Unpacking and Setup Inspect for shipping damage. Examine the shipping Meet electrical requirements. Prior to connecting the container immediately upon receipt. Any damage to the... -
Page 5: Installation
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Installation Install the drip tray and the cup guide. Hang the drip tray on the bottom two screws on the front apron of the WARNING unit. -
Page 6: Initial Cleaning And Sanitizing
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Initial Cleaning and Sanitizing Soak the tanks and covers. Place the tanks and covers in the three compartment sink, filled with a CAUTION Dunkin approved dairy dispenser detergent, making All product tanks must be cleaned, sanitized and air dried sure to follow manufacturer’s specifications for... -
Page 7: Loading The Unit
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Loading the Unit Turn on the power Move the valves into the closed position. Move the switch (left side of product valves into position by pulling them out slightly unit near the front). -
Page 8: Calibrating The Unit / Adjusting Shot Size
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Calibrating the Unit / Adjusting Shot Size Dispense a shot. NOTE: Unit must be calibrated before the unit is put into C C a a l l i i b b r r a a t t... -
Page 9: Setting Time And Date
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Setting Time and Date Navigate to the Adjust the date and Manager Menu. On time. Press Select to the display panel, begin the adjustment,... -
Page 10: Operation - General
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Operation – General The 3-Product Dairy Threshold Levels – The Milk and Skim levels are set to 600 g Dispenser consists of a and the Cream level to 850 g. The unit goes into lockout (will not... -
Page 11: Operation - Refilling The Product Tanks
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Operation – Refilling the Product Tanks Open the front and top access doors of the unit. Open the lid of the product tank to be refilled. -
Page 12: Operation - Changing The Temperature Set Point
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Operation – Changing the Temperature Set Point Choose the NOTE: If product temperature is not within spec (33 to 41°F), 3 3 6 6 º F F temperature. -
Page 13: Operation - Setting Coolatta Base
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Operation – Setting Coolatta Base Choose “Coffee” or NOTE: The Coolatta drink base comes in two types, coffee and C o f f e e Neutral”. -
Page 14: Cleaning And Maintenance - General
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Cleaning and Maintenance – General Because this unit is intended for use with dairy products, it must Recommended Cleaning Schedule be cleaned and sanitized prior to the first use and every 72 hours The following table is a recommended cleaning schedule for the during regular use. -
Page 15: Cleaning The Product Tanks
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Cleaning the Product Tanks Turn the power switch to the OFF position. Soak the tanks and covers. Place the tanks and covers in the three compartment sink, filled with a Dunkin approved dairy dispenser detergent, making sure to follow manufacturer’s specifications for... -
Page 16: Refrigerated Product Compartment Cleaning
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Refrigerated Product Compartment Cleaning Wipe down the interior. Wipe using a clean, soft cloth, NOTE: Each time a new product tank is loaded, check the and dry thoroughly. -
Page 17: Shot Size Targets
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Shot Size Targets With machine set to COFFEE With machine set to NEUTRAL Base Base ALL SHOTS ARE LISTED AND MEASURED IN GRAMS ALL SHOTS ARE LISTED AND MEASURED IN GRAMS... -
Page 18: Troubleshooting Guide
SOLUTION Not dispensing accurately Containers not in correct position Check container position (L,C,R). Wrong tubes being used Use Silver King tubes only (Part No. 37222). Unit out of calibration Run daily calibration (See Calibrating the Unit). Valve hanging up Call for service (888-375-2938). -
Page 19: Parts List And Exploded View
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Parts List and Exploded View NOTE: To order Parts/Service, Contact Silver King Refrigeration at 800-328-3329 for technical assistance. Item Part Item Part Description Description 25226S Hinge w/Screws &... -
Page 20: Wiring Diagram
3-Product Dairy Dispenser RINCE ASTLE Model SKBD3LS W O R L D W I D E Wiring Diagram BLACK RED (+) POWER BLACK WHITE SUPPLY RED (+) 24V DC 120V AC GROUND GRAY TEMP SENSOR CONTROL LOAD CELLS BOARD ←...
Need help?
Do you have a question about the SKBD3LS and is the answer not in the manual?
Questions and answers
Why my dairy dispenser showing panel error
A panel error in the Silver King SKBD3LS dairy dispenser can be caused by the panel being disabled for cleaning. This can be resolved by pressing and holding the Home button for 2–3 seconds.
This answer is automatically generated